2002 VOLKSWAGEN EUROVAN Engine And Engine Coolingcooling Systemfan Problems

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN EURO VAN. WHENEVER THE CONTACT DROVE THE VEHICLE AT 35 MPH THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE ENGINE FAN BLADES BROKE. THE CURRENT AND FAILURE MILEAGES WERE 73300.

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN EUROVAN. THE CONTACT NOTICED VIBRATION IN THE STEERING WHEEL AND HEARD A NOISE COMING FROM THE ENGINE COMPARTMENT. THE FAILURES WOULD OCCUR ONLY WHEN THE ENGINE WAS RUNNING. THE COOLING FAN FAILED, BUT THE VEHICLE DID NOT OVERHEAT. THE SPEED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 112,000.

WHILE TRAVELING ON A UPHILL PAVED ROAD GRADE AROUND 11 AM GOING AT A SLOW SPEED, APPROXIMATELY 25 MPH AND THE BLADE ON THE COOLING FAN ON THE 2002 VOLKSWAGEN EUROVAN BROKE OFF. FAN WAS UNBALANCED AND BEGAN TO VIOLENTLY SHAKE. ENGINE WAS TURNED OFF AND THE FAN STILL CONTINUED TO RUN VIOLENTLY SHAKING THE VAN, FINALLY STOPPED AND IN ABOUT 5 MINUTES THE FAN TURNED ON AGAIN VIOLENTLY SHAKING THE VAN. RIALTA HAS A RECALL FOR THE SAME VOLKSWAGEN PROBLEM WITH FAN BLADES SEPARATING FROM COOLING FAN. NHTSA RECALL. 04V107000/VOLKSWAGEN RECALL NO. WB NHTSA CASE NUMBER PE0315 OPENED ON APRIL 2003 AND CLOSED AUGUST 2003. WHAT WAS THE FINAL OUT COME OF THE INVESTIGATION? THIS IS A ON GOING SAFETY ISSUE, THERE ARE OTHER CASES POSTED ON YAHOO WEB SITE. VOLKSWAGEN ISSUE FAN WARNING LABELS (LABEL WAS ISSUED A FEW YEARS AGO, WHEN I ASKED FOR DATE OF ISSUE...

RADIATOR FAN BLADE EXPLODED/PARTIALLY DISINTEGRATED WITHOUT WARNING. VIN [XXX] HAD ONLY 16000 MILES ON IT, AND NO WORK HAS BEEN DONE TO THE ENGINE TO DISTURB THE FAN BLADE. *TR UPDATED 07/10/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN EUROVAN. WHILE DRIVING AT 30 MPH THE VEHICLE STALLED. THE CONTACT STATED THAT THIS FAILURE OCCURRED ON SEVERAL OCCASIONS. ALSO, THE CONTACT STATED THAT THE GENERATOR AND BATTERY INDICATORS REMAINED ILLUMINATED ON THE INSTRUMENT PANEL. ON FEBRUARY 23, 2006, THE ENGINE FAN WAS REPAIRED ON THE VEHICLE AND COST THE CONTACT $977. THE DEALER STATED THAT THE CONTACT NEEDED TO PAY AN ADDITIONAL $92 FOR THE DIAGNOSTICS OF THE GENERATOR. THE CONTACT WAS ISSUED CASE # 60034264 BY THE MANUFACTURER. THE CURRENT MILEAGE IS 37,000 AND FAILURE MILEAGE WAS 15,000.*AK

RADIATOR COOLING FAN DISINTEGRATED AND DESTROYED RADIATOR. *JB

RADIATOR FANS DISINTEGRATED WHILE DRIVING AND MADE A HOLE IN RADIATOR. THIS IS A VW EUROVAN 2002, AND THERE WAS A RECALL ON THIS FOR MODEL YEARS 1998-2000. VW HAS REFUSED TO INCLUDE MINE IN THE RECALL. THE REPAIR COST $2060. *NM