2001 VOLKSWAGEN BEETLE Electrical System Problems

Car caught on fire 2 times it was electrical and fuel problem the fire department was present. I reported this once already and the company acted like they didnt care

A HUGE AMOUNT OF 2.0L ENGINES (1998-2006) SEEM TO STALL WHEN DRIVING OR STATIONARY AFTER 20 MIN FROM COLD START IN HIGH TEMPS (+75F) . LOSS OF POWER STEERING AND POWER ASSIST BRAKES. IT HAPPENED TO ME 2X WHILE DRIVING 45 MPH. SCARY. DEALERS AND MECHANICS CAN'T LOCATE ISSUES BECAUSE ITS INTERMITTENT. CARS OPERATE NORMAL AGAIN AFTER 10-20 MINS. SEE HTTP://NEWBEETLE.ORG/FORUMS/2-0-LITER-GAS/139065-HOT-WEATHER-STOP-GO-CAR-STALLS-DANGEROUS-2.HTML#POST1508562 FOR A LIST OF DIFFERENT SITES ALL LISTING SIMILAR ISSUES. APPARENTLY, AND ACCORDING TO MY RESEARCH, THE ISSUE STOPPED ON MODEL YR 2007 AND HIGHER.

DRIVING DOWN THE ROAD ON 3 DIFFERENT MY OCCASIONS CAR OVERHEATED NOW IT WON'T START.

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE. WHILE DRIVING AT APPROXIMATELY 35 MPH, ALL THE GAUGES DROPPED TO ZERO AND FAILED TO FUNCTION. IN ADDITION, THE TEMPERATURE AND OIL WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT THE TEMPERATURE WARNING LIGHT REMAINED ILLUMINATED, BUT THE OIL WARNING LIGHT WAS NOT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

CAR WAS IN SHOP 2 TIMES FOR COILS GOING BAD DROVE CAR TO HAMMOND INDIANA FROM CROWN POINT CAME BACK TO CROWN POINT PARKED CAR WENT IN TO GO TO BED WAS ASLEEP FOR AN HOUR NEXT THING WE HEAR KNOCKING ON DOOR GO OUT SIDE AND CAR IS ON FIRE FIRE DEPARTMENT WAS OUT SIDE PUTTING CAR OUT FIRE DEPARTMENT SAID SOMETHING IN ENGINE COMPARTMENT CAUGHT ON FIRE RIGHT WHERE THE COILS ARE. *TR

THE LIGHT ON MY DASH CAME ON FOR THE DRIVERS AIRBAG AND HAD IT CHECKED BY THE DEALER MARCH, 2010 FOR MY 2001 VW BEETLE 1.9 DIESEL. I WAS TOLD THE CHIP IN THE SEAT BELT HAD GONE BAD NEEDS TO BE REPLACED. APPROX. $175.00 THE SERVICE DEPT. CALLED VW AND THEY COULD NOT TELL ME IF MY DEFECTIVE CHIP IN THE SEATBELT WILL DEPLOY UPON IMPACT. 50% CHANCE IT MIGHT. I HAVE NOTICED ALL THE $ I HAVE PUT INTO THIS CAR VW GENERALLY IS NOT ON THE RECALL LISTS FOR ANYTHING. ALSO, THE HEADLIGHT BULBS GENERALLY BURN OUT EVERY YEAR AND THEY NEED TO BE REPLACED. VW DOESN'T TELL HOW TO CHANGE THE BULBS IN THE MANUAL. HAD TO GO TO THE DEALER TO SHOW HOW TO CHANGE A LIGHT BULB WHICH I FEEL IS A SAFETY ISSUE. I WILL NOT BUY ANOTHER VW BECAUSE THEY DO NOT...

CONTINUE OVER HEATING BLOWING HEAD TWICE ENGINE LIGHT STAY ON BRAKE LIGHTS ON LEFT SIDE DON'T WORK ALARM WONT LOCK LEFT SIDE DOESN'T WORK AND BACK SEAT IS TOTALLY UNSAFE FOR KIDS. FRONT IS VARY UNSTABLE IT FEEL LIKE IT GOING TO FALL OFF TO LOW TO THE GROUND , ETC......IT GOES ON AND ON. *TR

THE BRAKE LIGHTS ARE INOPERATIVE, REMAIN OFF. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. PREVIOUS RECALL 06V183000: BRAKE LIGHT SWITCH DEFECT MAKE/MODELS: MODEL/BUILD YEARS:VOLKSWAGEN/JETTA 1999-2002VOLKSWAGEN/NEW BEETLE 1998-2002MANUFACTURER: VOLKSWAGEN OF AMERICA, INC.NHTSA CAMPAIGN ID NUMBER: 06V183000 MFG'S REPORT DATE: MAY 24, 2006COMPONENT: EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH. VW IS NOT INTERESTED TO INVESTIGATE THE PROBLEM SAYING THAT HAVE COMPLETED THE RECALL AND THIS IS MY PROBLEM NOT THEIRS EVEN THOUGH BRAKE LIGHT PROBLEM IS BACK. *TR

THE HAZARD LIGHTS, TURN SIGNALS AND HEADLIGHTS ON MY CAR DO NOT WORK. I'VE TAKEN IT IN TO AN AUTO SHOP AND THEY CANNOT FIND OUT WHAT IS WRONG WITH THE CAR. HOPING MAYBE THERE IS A RECALL THAT I HAVE MISSED. *TR

THROTTLE BODY GOES OUT (02-03-2009) CV AXEL GOES OUT (03-31-2009 BRAKE LIGHTS GO OUT (02-18-2010) CV AXEL GOES OUT AGAIN (4-31-2010) ALTERNATOR GOES OUT (06-21-2010) IGNITION COILS FAIL (09-13-2010) IGNITION COILS FAIL AGAIN(01-21-2011) BRAKE SWITCH REPLACED AGAIN (01-21-2011) AIR FLOW SENSOR FAILS (01-21-2011) AIR FLOW SENSOR FAILS AGAIN (07-26-2011) TIMING BELT REPLACED (06-15-2011) THERMOSTAT REPLACED (06-15-2011) WATER PUMP REPLACED (06-15-2011) NOW HAVING PROBLEMS WITH THROTTLE BODY/ THROTTLE BODY SENSOR/ ELECTRICAL ISSUE. DEALER IS NOT SURE WHAT THE PROBLEMS IS AND WANTS TO THROW MONEY AT IT TO SEE WHAT THE PROBLEMS IS. THIS CAR IS JUST ONE PROBLEM AFTER ANOTHER AFTER ANOTHER.

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE GLS . WHILE THE VEHICLE WAS PARKED THE CONTACT PLACED THE KEY IN THE IGNITION AND HEARD A CLICKING SOUND BUT THE VEHICLE WOULD NOT START. THE VEHICLE WOULD ONLY START WHEN IT WAS JUMP STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE OCCURRED A SECOND TIME AND WAS TOWED TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THE ALTERNATOR NEEDED TO BE REPLACED. THE ALTERNATOR WAS REPLACED BUT THE FAILURE CONTINUED. THE MECHANIC STATED THE VEHICLE BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE CONTINUED AND THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIANS STATED THE ALTERNATOR NEEDED TO BE REPLACED A SECOND TIME. THE FAILURE CONTINUED AFTER THE REPLACEMENT OF THE ALTERNATOR. THE VEHICLE...

2001 VW BEETLE. FROM THE VERY BEGINNING, IT HAS BEEN NOTHING BUT PROBLEMS. FOR THE FIRST FEW YEARS IT WAS COVERED UNDER THE WARRANTY, FREE OF CHARGE REPAIRS. I HAVE LOW MILEAGE SO I THOUGHT THAT BY THE TIME THESE ITEMS WERE REPAIRED IT WOULD BE FINE WHEN THE WARRANTY EXPIRED. THERE IS ALWAYS SOMETHING WRONG WITH THE CAR AND IN PARTICULAR THE ELECTRICAL SYSTEM. THE CHECK ENGINE LIGHT IS ALWAYS GOING OFF. THE SAFETY ISSUE COMES IN WITH ITS CURRENT PROBLEM. I HAD A FUEL INJECTION FLUSH WHICH INCLUDED THE CARBON DEPOSITS REMOVAL KNOWN AS INDUCTION, AIR FILTER REPLACED, ENGINE FUEL FILTER REPLACED, AND A BRAKE FLUID FLUSH PLUS 4 NEW SPARK PLUGS. PRIOR TO THIS SERVICE, MY CAR WAS HAVING DIFFICULTY STARTING WITH MAJOR SHAKING. I HAD TO PUT MY FOOT ON THE ACCELERATOR TO GET IT GOING WHILE STARTING. NOW AFTER THE SERVICE IT RUNS MUCH BETTER...

CAR IS STALLING, SPUTTERING, BUT NOT DYING COMPLETELY. COIL PACKS HAVE BEEN DETERMINED TO BE THE ISSUE. THERE IS AN OPEN RECALL ON THE COIL PACKS, BUT I NEVER RECEIVED THE RECALL NOTICE. THE COIL PACKS ON THIS CAR NEED TO BE REPLACED, FREE OF CHARGE, FREE LABOR AND DIAGNOSTIC SERVICES. PLEASE SEND DETAILS ON HOW TO ACCOMPLISH THIS FOR MY 2001 VW NEW BEETLE GLX 1.8T. *TR

THE HEADLAMPS HAVE BEEN REPLACED FOUR TIMES. ACCORDING TO A VW DEALERSHIP WHO SERVICED THE VEHICLE, I WAS INFORMED THAT THE VEHICLE'S WIRING HARNESS IS DEFECTIVE, CAUSING THE HEADLIGHTS AND INSTRUMENTATION CLUSTER TO FAIL. THE DEALERSHIP INFORMED ME THAT THEY ARE AWARE OF THE WIREING HARNESS PROBLEM, BUT ARE NOT AWARE OF ANY SERVICE RECALLS.

2001 VW BEETLE: 189944 MILES. SUDDEN PERMANENT FAILURE OF SPEEDOMETER, TACHOMETER AND FUEL GAUGES. WILL INVESTIGATE REPAIR/REPLACEMENT COST. *TR

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT WHEN DRIVING AT HIGH SPEEDS OR IDLING, THE VEHICLE WOULD SUDDENLY HESITATE AND WOULD ATTEMPT TO STALL. THE DIGITAL CLOCK WOULD INDEPENDENTLY RESET TO MIDNIGHT AND THE FUEL LEVEL GAUGE NEEDLE WOULD DROP TO ZERO. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE IGNITION SWITCH WAS REPLACED. THE FAILURE RECURRED. THE FUEL LEVEL GAUGE HAD NOT MOVED BACK UP SO THE CONTACT WAS UNAWARE OF HOW MUCH FUEL WAS IN THE TANK. THE CONTACT SCHEDULED ANOTHER APPOINTMENT WITH THE DEALER AT THE TIME OF THE COMPLAINT. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 148,000.

SUDDEN FAILURE OF ALL "POINTER GAUGES" IN THE INSTRUMENT CLUSTER (SPEEDOMETER, TACHOMETER AND FUEL GAUGE. I HAVE BEEN GIVEN AN ESTIMATE OF $550 TO REPLACE THE ENTIRE INSTRUMENT CLUSTER, BUT SO FAR HAVE NOT FOLLOWED THROUGH. *TR

EPC LIGHT ON,CAR LOOSING POWER. I HAVE CHANGE EVERYTHING YOU CAN IMAGINE THAT COULD BE CHANGE TO FIX IT AND NOTHING. NOBODY KNOWS HOW TO FIX IT, NOBODY WANTS TO BE RESPONSIBLE FOR IT.VW CORPORATION DON'T HAVE RECALLS FOR IT, AND NO DEALER OR MECHANIC KNOWS HOW TO FIX IT. *TR

SUDDEN PERMANENT FAILURE OF SPEEDOMETER, TACHOMETER AND FUEL GAUGES. *TR

ENGINE AND TRANSMISSION OVERHEATING JUST A TERRIBLE CAR. WAX MATERIAL INTERIOR REMOVES EASILY WITH NAILS CHILDREN CAN EAT IT HAS CRAYOLA SMELL.SHOULD HAVE BEEN MADE OF PLASTIC OR VINYL. THIS WHOLE CAR SHOULD BE RECALL. EPC BRAKE SWITCH ALWAYS ON HAD IT REPAIRED 3 TIMES ENGINE LIGHT IS ALWAYS ON. BAD ELECTRICAL. INTERIOR AC LIGHT IS ALWAYS OFF. IN AND OUT OF MECHANIC.

I PURCHASED A 2001 VW BEETLE NEW AND I HAVE HAD TO TAKE IT TO THE SHOP 4 TIMES DUE TO SEAT BELT WARNING LIGHT. THIS SEEMS TO BE AN ON-GOING PROBLEM EVEN AFTER VW MADE A RECALL AND SUPPOSEDLY "FIX" THE SEAT BELT PROBLEM. THIS VERY FIRST TIME THIS HAPPENED THE CAR HAD LESS 1500 MILES ON IT. *TR

I HAVE A 2001 VW NEW BEETLE. I HAVE REPLACED BRAKE LIGHT, WHICH WAS DRAINS THE BATTERY, SERPENTINE BELT, REMOTELESS KEY WHICH IS STILL BROKEN- BASICALLY 6 DAYS AFTER BUYING THIS CAR- I SPENT $1200 ON REPAIRS- NOW THE CHECK ENGINE LIGHT IS ON, THE TRANSMISSION IS ACTING FUNNY, AND BASICALLY- MY VW DEALERSHIP HAS A FIELD DAY WITH ME. TO TOP IT OFF- MY BATTERY DIED A MONTH AGO- AND CAUGHT ON FIRE WHEN I TRIED TO JUMP IT. I AM AFRAID THAT THIS CAR WILL BLOW UP ON ME AT ANY TIME. PLEASE HELP ME! *TR

SINCE THE PURCHASE OF MY VEHICLE 2001 VW BEETLE, I HAVE HAD A CONTINUOUS BEEPING AND ILLUMINATION OF VARIOUS CRAZY LIGHTS IN MY DASHBOARD. I HAVE CONTINUALLY TAKEN MY CAR TO VW, AT THE RATE OF $350+ EACH TIME, I AM AT MY WITS END...THESE ELECTRICAL ISSUES CANNOT BE FOUND OR FIXED BY A VW REP, AND ARE A DANGER TO MYSELF, MY PASSENGERS, AND SURROUNDING CARS. I HAVE CONTACTED VW AMERICA, AND HAVE BEEN TREATED LIKE I WAS BOTHERING THEM. I HAD ONE SHOP IN SPRINGFIELD, MO FIX THE CONSTANT MIND BOGGLING BEEP THAT I'VE HAD TO LISTEN TO FOR YEARS NOW...THIS REPAIR OF THE BEEP LASTED THE LONGEST OF ALL...(1YEAR)...BUT THE ONLY WAY TO FIX IT MADE THE BRAKE LIGHT ILLUMINATE CONTINUALLY, SO THAT I NEVER COULD TELL IF I HAD BRAKE ISSUES OR NOT. THEN WHEN MY VEHICLE NEEDED TO HAVE A SMOG TEST FOR REGISTRATION BACK...

EMERGENCY LIGHT SWITCH (HAZARD SWITCH) THERE WAS A VW RECALL ISSUED TO REPLACE THIS SWITCH THAT NOT ONLY CONTROLS THE HAZARD FLASHERS BUT ALSO THE TURN SIGNALS, IN THE JETTA, GOLF, & GTI. MY BEETLE USES THE SAME SWITCH I AM WONDERING WHY IT WAS NOT INCLUDED IN THIS RECALL (VW RECALL VX). MY SWITCH HAS THE SAME INTERMITTENT PROBLEM AS DESCRIBED IN THE MARCH 2005 RECALL LETTER, I WILL BE REPLACING THE SWITCH ON MY OWN ACCORD, BUT THIS BULLETIN SHOULD INCLUDE THE VW NEW BEETLE MODEL IN MY OPINION. *NM

ALMOST TOO MANY TO LIST O2 SENSOR AT 20K MILES - TWICE TEMP SENSOR FOR COOLING FAN ($5 PART - $200 TO INSTALL) AT 30K MILES IGNITION COILS AT 50K MILES. VW HAD INITIATED A "CUSTOMER ACTION" ON ALL 1.8L ENGINES FOR DEFECTIVE IGNITION COILS ON VW AND AUDI MODELS. CUSTOMER SERVICE ACTION MEANS NOTHING, COST ME $600 WITHOUT RENTAL CAR ADDED. THEY REFUSED TO ACKNOWLEDGE THIS PRESS RELEASE WHEN CONTACTED DIRECTLY. WATER PUMP WENT SOUTH AT 61K MILES ELECTRONIC CONTROL MODULE WENT SOUTH AT 61K MILES ALSO. WARRANTY COVERED STILL COST ME $300 FOR RENTAL CAR FOR 5 DAYS. TIMING BELT DAMAGED WHEN WATER PUMP WENT. VOA WILL TELL YOU TO "CHECK" IT AT 50K BUT IT SHOULD LAST TO 108K. PAID FULL LABOR EVEN THOUGH ENGINE WAS APART FOR PUMP WORK. VW SHOULD BE FORCED TO HONOR THE QUALITY PROBLEMS WITH THIS CAR. NHTSA SHOULD INVESTIGATE AND FORCE...

I OWN A 2001 BEETLE. IT HAS ONLY 50,000 MILES ON IT. THE OTHER DAY THE CHECK ENGINE LIGHT CAME ON. I JUST TOOK IT IN TO THE DEALER, AND THEY TOLD ME THEY HAVE TO REPLACE A COIL AND AN O2 SENSOR. ALL THIS IS GOING TO COST ME CLOSE TO $1000! AFTER DOING SOME RESEARCH ONLINE, I FOUND THAT THIS IS A VERY COMMON COMPLAINT FOR VW BEETLES. VW NEEDS TO ISSUE A RECALL SINCE THIS IS A PROBLEM FOR SO MANY PEOPLE. I READ OF PEOPLE HAVING THE CAR STOP RUNNING WHILE THEY WERE DRIVING. THIS COULD CAUSE ACCIDENTS. *NM

THE POWER SHUTS DOWN IN MY 2001 BEETLE TURBO WHILE I AM DRIVING. I HAVE TO PULL OFF THE ROAD, KILL THE CAR, AND THEN START IT BACK UP. AFTER THAT, IT SEEMS FINE. *NM

DT: HAVING THE SAME PROBLEM FOR THE RECALL. EPC LIGHT CAME ON AND OFF, CAME ON AGAIN. CURRENTLY, THE BRAKE LIGHTS WERE OFF. TRIED TURNING OFF THE VEHICLE, JUST TURNING THE KEY HAVE WAY , BUT THEY STILL WILL NOT COME ON. IT CAME ON ONCE BEFORE ABOUT 4 OR 5 MONTHS, BUT IT WENT BACK OFF. CONTACTED DEALER ,THEY HAD CHECKED WITH THE MANUFACTURER. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN.*AK

I HAVE A 2001 BEETLE WITH THE 1.8T ENGINE. MY CAR HAS BEEN DISABLED TWICE DUE TO DEFECTIVE COIL PACKS. RESEARCH ON THE VWVORTEX.COM WEBSITE REVEALED THERE IS A LARGE HISTORY OF PROBLEMS WITH THESE COIL PACKS WHICH CAN FAIL AT ANY TIME RENDERING THE VEHICLE UNDRIVEABLE. THERE IS CURRENTLY A SHORTAGE OF THIS PART (PART # 06B-905-115-J COIL) DUE TO THE VOLUME OF VEHICLES THAT HAVE HAD THIS PROBLEM. VWVORTEX IS RECOMMENDING OWNERS CONTACT NHTSA TO FACILITATE A RECALL OF COIL PACKS AS VW IS UNWILLING TO ADDRESS THE ISSUE AT THIS TIME. IT IS A SAFETY ISSUE BECAUSE THEY CAN FAIL WHILE DRIVING RESULTING IN LOSS OF CONTROL OF THE VEHICLE.