2008 TRIUMPH TIGER 1050 CCM ABS Engine And Engine Coolingcooling System Problems

MY TRIUMPH TIGER 1050 OVERHEATED MANY TIMES IN TRAFFIC. THE BIKE WOULD GO FROM 6-9 ON THE TEMP GAUGE VERY QUICKLY AND THE OVERHEATING WARNING LIGHT WOULD COME ON. I PULLED OVER TO LET IT COOL DOWN AND AFTER 15 MIN OR SO I WOULD START AGAIN AND IT WOULD TAKE ONLY A FEW MINUTES TO OVERHEAT AGAIN. THEN I NOTICED THE COOLANT RESERVE WAS BOILING AND THE COOLANT BLEW ALL OVER THE GROUND. I DISCOVERED THE COOLING FAN WAS NOT WORKING AND CHECKED THE FUSES. THE FAN FUSE WAS BLOWN AND I REPLACED IT. IT WOULD ONLY TAKE ABOUT 15 MIN IN TRAFFIC FOR THE FUSE TO BLOW AGAIN AND RESULT IN OVERHEATING. THIS PERSISTED UNTIL I COULD GET IT TO THE DEALER LATER IN THE AFTERNOON. I WAS PUT IN HARMS WAY AS I HAD TO REPEATEDLY PULL OVER ON NON SAFE ROADS TO LET THE BIKE COOL...

AFTER PICKING MY TRIUMPH TIGER 1050 FROM CORSA MOTORSPORTS IN NYC FOR A OVERHEATING REPAIR, WHICH ALL THEY DID WAS REPLACE A FAN FUSE, MY MOTORCYCLE CONTINUED TO OVERHEAT AND BLOW APPROX 8-10 FUSES THROUGHOUT THE DAY UNTIL I COULD GET IT BACK TO THE DEALERSHIP THAT AFTERNOON. I WAS LEFT STRANDED ON MAJOR HIGHWAYS WITH NO SHOULDER IN RUSH HOUR TRAFFIC WHILE I WAITED FOR THE BIKE TO COOL DOWN. THE BIKE WOULD OVERHEAT 5 MIN AFTER IT COOLED DOWN AND THE OVERHEATING WARNING LIGHT WENT OFF. IT BLEW COOLANT OUT FROM BELOW THE BIKE A FEW TIMES. I TOOK THE BIKE BACK TO THE DEALERSHIP AND THEY HAD THE BIKE FOR 3 WEEKS AND REPLACED THE FAN, 140DIA, SQUARE COWL UNDER WARRANTY. *TR

AROUND THE END OF MAY AND BEGINNING OF JUNE 2010 MY TRIUMPH TIGER 1050 WOULD CONTINUE TO OVERHEAT IN TEMPS HIGHER THAN 75 DEGREES AND I WOULD HAVE TO PULL OVER TO LET THE BIKE COOL DOWN. ON AROUND JUNE 24, 2010 THE BIKE WOULD NOT START AGAIN, AND WITH MY RECURRING OVER HEATING ISSUES I HAD THE BIKE TOWED TO TREBOUR MOTORCYCLES. THE BIKE WAS IN THEIR POSSESSION FOR APPROX 1 MONTH. AT WHICH TIME THE SHOP MANAGER JOE COULD NOT GET THE BIKE TO OVERHEAT. ALTHOUGH HE NEVER TEST ROAD THE BIKE IN THE TYPE OF CONDITIONS THAT I SPECIFIED. UPON PICKING UP THE BIKE HE SAID THE BATTERY TESTED "GOOD" AND THE STARTER SOLENOID AND FUEL PUMP RELAY WHERE REPLACED UNDER WARRANTY. *TR

AFTER MULTIPLE OVERHEATING AND STARTING PROBLEMS WITH MY TRIUMPH TIGER 1050 I PICKED MY BIKE UP FROM TREBOUR MOTORCYCLES AND THEY SAID THAT THE BIKE WAS IN GREAT WORKING ORDER AND THAT IT WILL NO LONGER OVERHEAT. APPROX 1 1/2 HOURS LATER AFTER I ARRIVED IN NEW YORK CITY, THE TEMP GAUGE WAS AT 9 THE WARNING LIGHT WAS ON AND THE FAN FUSES WHERE BLOWING LIKE CRAZY. I PULLED OVER CALLED TREBOUR WITH THE NEWS THAT THEY FAILED AGAIN TO REPAIR MY BIKE AND PURCHASED A PACK OF FUSES FROM RADIO SHACK AND PROCEEDED HOME TO FIND ANOTHER SHOP TO TAKE THE BIKE TO. *TR

AS A RESULT OF MULTIPLE OVERHEATING ISSUES THAT WHERE NOT RESOLVED BY TREBOUR MOTORCYCLES I HAD MORE OVERHEATING PROBLEMS WITH FUSES BLOWING AND THE BIKE REACHING THE MAXIMUM TEMP VERY QUICKLY. ONCE THE OUTSIDE TEMPS DIPPED BELOW 70 I COULD RIDE THE BIKE WITHOUT IT OVERHEATING AND I TOOK IT TO LOCOMOTION MOTORSPORTS. THEY HAD IT FOR ALMOST A MONTH AND DID EXTENSIVE TESTS WITH IT. THEY EVEN BENCHMARKED IT AGAINST AND BRAND NEW BIKE IN THEIR SHOP AND FOUND OUT THAT MY BIKES FAN WAS COMING ON MUCH LATER THAN ON THE NEW BIKE AND RESULTING IN A HIGHER TEMP AND THEN THE SHOP WAS ABLE TO GET THE BIKE TO OVERHEAT. THEY REPLACED THE FOLLOWING PARTS: A RELAY EFI, FAN SQUARE COWL, COOLING FAN, AND COOLING FAN RELAY. (THIS IS MY 2ND REPLACEMENT FAN IN A YEAR AND 3RD TOTAL FAN INSTALLED ON THE BIKE) ALL OF THIS...

LESS THAN 2 HOURS AFTER PICKING UP MY TRIUMPH TIGER 1050 FROM TREBOUR MOTORCYCLES AND AFTER THE SHOP MANAGER JOE REASSURED ME THAT THE BIKE WAS IN TOP-NOTCH CONDITION AFTER MY OVER HEATING AND NON STARTING REPAIRS BY HIS SHOP, THE BIKE STARTED TO OVERHEAT IN TRAFFIC. I WAS ON A DANGEROUS ROAD WITHOUT A SHOULDER AND WAS LUCKILY ON A DOWNGRADE. I NOTICED THE COOLANT IN THE RESERVE TANK WAS BOILING SO I TURNED THE BIKE OFF AND COASTED DOWN THE DECLINE. ONCE I GOT TO THE BOTTOM OF THE DOWNGRADE, WHICH WAS A TOLL ENTRANCE INTO THE LINCOLN TUNNEL IN NEW JERSEY, I WAS ABLE TO PUSH THE BIKE TO A NON USED LANE. AFTER THE BIKE COOLED DOWN AND THE OVERHEATING WARNING LIGHT WENT OFF, I TRIED TO START THE BIKE. NOTHING HAPPENED. I TRIED AGAIN AND THE BIKE WOULD NOT TURN OVER. THE PORT AUTHORITY POLICE...