2006 TOYOTA PRIUS Steering Problems

The contact owns a 2006 Toyota Prius. The contact stated that while driving approximately 35 MPH, the steering wheel erroneously steered to the left direction on its own. The contact used force to maneuver the vehicle however the steering wheel independently veered again to the left, right, left, and then back to the right. The vehicle crashed into a curb, and violently accelerated across 2 lanes of oncoming traffic where a van crashed into the vehicle head-on. The air bags deployed upon impact. The contact sustained 11 fractured bones (L1 through L5 lower lumbar, pelvic, pelvis, 11th rib, and sacrum) and received medical attention via trauma center where she remained for over 2 weeks. The other driver of the van sustained unknown injuries but did not receive any known medical attention. A police report was not on file for the incident. A dealer was not contacted. The manufacturer was not...

LOSS OF VEHICLE STEERING CONTROL WHILE DRIVING. LUCKILY THE VEHICLE WAS JUST GOING DOWN THE DRIVEWAY AT LOW SPEED SO NO ONE WAS INJURED.*DT*JB

CLOCK SPRING FAILURE. CONTROLS ON THE RIGHT SIDE OF THE STEERING COLUMN ARE NOT WORKING. CONCERNED THAT THIS CLOCK SPRING FAILURE WILL ALSO CAUSE THE DRIVER'S AIRBAG TO FAIL TO DEPLOY IN A CRASH.

BAUGHT THE CAR OFF A PRIVATE SALE. CAR IS A COMPLETE BAD CONDITION FRON THE SUSPENSION TONTHE MOTOR MAKES STRANGE NOISES AIR CONDITIONER WONT WORK TIRES FALL FROM ALLIGHMENTS SEAT BEATS ARE OFF BURNING A PIL CHANGE IN LESS THEN A WEEK.NO ACCIDENTS NO CHANGES AS IS AND HAVE BEEN USING IT FOR WORK.

TL* THE CONTACT OWNS A 2006 TOYOTA PRIUS. WHILE OPERATING THE VEHICLE, THE POWER STEERING SUDDENLY MALFUNCTIONED AND CAUSED THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING ECU WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. ALSO, WHILE DRIVING THE VEHICLE, IT SUDDENLY STALLED AND WOULD NOT RESTART. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY WAS FAULTY. THE FAILURE WAS REPAIRED. THE CONTACT ALSO INDICATED THAT THE AIR CONDITIONER BLOWER STOPPED OPERATING AND THE FRONT WINDSHIELD COULD NOT BE DEFROSTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 200,500. *DT*JB

I WAS IN A 2006 TOYOTA PRIUS CAR ACCIDENT ON THE FREEWAY WHEN THE STEERING WHEEL STARTED JERKING (TO THE POINT OF NO CONTROL), THE BRAKES STOPPED WORKING AND THE CAR KEPT ACCELERATING. CAR LOST CONTROL.*DT*JB CAR WAS TOTALED, TWO WITNESSES AND A POLICE REPORT. I WAS SENT THE EMERGENCY ROOM. NO RESPONSIBILITY WAS ASSUMED BY TOYOTA, WHICH COMPLETED THEIR "INSPECTION" ON MARCH 9TH, 2012. THEN EIGHT MONTHS LATER ON NOVEMBER 14, 2012 THEY COME OUT WITH TWO RECALLS: A STEERING RECALL & AN ENGINE AND ENGINE COOLING, HYBRID PROPULSION SYSTEM RECALL, PROBABLY AS PART OF WHAT THEY SAW HAPPENED TO ME. I WAS NEVER NOTIFIED AFTER ABOUT THESE RECALLS THAT MY CAR POTENTIALLY COULD'VE BEEN DEFECTIVE FROM AND PART OF.

WATER PUMP WAS REPLACED IN 2011 AND AGAIN 2015. MY CAR HAS 160,000 MILES AT THIS TIME IN NOV 2015.

I WAS DRIVING ON INTERSTATE HIGHWAY 5 NORTH TO LOS ANGELES LATE EVENING AROUND 9:00PM. THE STEERING COLUMN BEGAN MAKING A GRINDING NOISE AND VIBRATING. EACH TIME I TURNED THE STEERING WHEEL EITHER TO THE LEFT OR TO THE RIGHT THE CAR MADE A VIBRATION AND GRINDING NOISE AND FELT STIFF. THE JARRING WAS FELT IN THE ACCELERATION PAD AND IN THE BRAKE PADS EACH TIME I EITHER ACCELERATED OR BRAKED. I TOOK THE CAR TO THE DEALER WHERE I SERVICE MY CAR ON JULY 5TH 2014. THE SERVICE DEPARTMENT WAS ABLE TO DUPLICATE THE EXACT COMPLAINT I HAD. THE SERVICE DEPARTMENT GAVE ME AN INVOICE INFORMING ME THAT THE CHARGES TO FIX THE STEERING COLUMN AND THE ELECTRIC MOTOR INSIDE WOULD COST ME OVER $2000.00. I CALLED TOYOTA ON 14TH JULY TO ASK IF THEY WOULD TAKE CARE OF THIS ISSUE. I WAS INFORMED BY TOYOTA ON JULY 18TH,...

I AM REQUESTING THAT NHTSA INVESTIGATE EXPANDING/ADDING-TO THE RECALL OF TOYOTA PRIUS COOLANT INVERTER PUMP FAILURES* TO INCLUDE COOLANT STORAGE PUMP FAILURES BLOWING A MAIN FUSE CAUSING DANGEROUS LOSS OF ALL POWER AND CONTROL. *TR ON MAY 31ST, 2014, WHILE TRAVELING AT ABOUT 60MPH, WITHOUT ANY WARNING, THE CAR INSTANTLY SHUT DOWN: NO DRIVE POWER, NO POWER STEERING, NO POWER BRAKES, NO FRONT PANEL DISPLAY. THIS WAS A DANGEROUS SITUATION. AFTER DIAGNOSIS, THE TOYOTA DEALER WITH ASSISTANCE FROM TOYOTA CORPORATE CONCLUDED THAT THE "COOLANT STORAGE PUMP" (NOT THE COOLANT INVERTER PUMP AS IN THE RECALL) WAS THE CAUSE OF THIS BLOWN "AM-2" 15-AMP FUSE WHICH SHUT DOWN THE HYBRID SYSTEM, POWER STEERING, BRAKES, ETC. THEY INDICATED THAT THE COOLANT STORAGE PUMP FAULT WAS A KNOWN CAUSE. THIS CAR IS WELL-MAINTAINED, DEALER MAINTAINED. IT HAD ALL THE RECENT RECALL UPDATES INSTALLED. IT WAS A MILD DAY ~75DEG. WE'D BEEN DRIVING ABOUT...

TL* THE CONTACT OWNS A 2006 TOYOTA PRIUS. THE CONTACT STATED WHILE APPROACHING AN EXIT FROM THE HIGHWAY AT 30 MPH THE STEERING WHEEL COULD NOT BE TURNED TO THE RIGHT OR LEFT; HOWEVER, THE FAILURE ONLY OCCURRED FOR A BRIEF MOMENT. THE STEERING WHEEL BEGAN TO FUNCTION NORMALLY WITHIN A FEW MINUTES. THE VEHICLE WAS TAKEN TO THE DEALER A DIAGNOSTIC TEST THAT WAS UNABLE TO LOCATE A FAILURE CODE. THE DEALER ALSO TEST DROVE THE VEHICLE BUT THE FAILURE DID NOT RECUR. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 75,000.

THE COOLING SYSTEM IN MY CAR IS DEFECTIVE. THE WATER PUMP IS APPARENTLY LEAKING WHEN I HAVE COMMITTED NO PRECURSIVE ACTION TO CAUSE IT. THIS ISSUE IS RELATED TO THE SAME ISSUE IN MY OTHER SIMILAR TOYOTA PRIUSES, WHERE DEFECTIVE ELECTRIC WATER PUMPS UNEXPECTEDLY STOP WORKING. THE OTHER CARS ARE CONSEQUENTLY RECALLED AND I BELIEVE MINE SHOULD BE AS WELL. HTTP://NEWS.CONSUMERREPORTS.ORG/SAFETY/2012/11/TOYOTA-PRIUS-AND-OTHER-VEHICLES-RECALLED-DUE-TO-WATER-PUMP-AND-STEERING-ISSUES.HTML THANKS. *TR

2006 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO STEERING RECALL NOTICE. *SMD THE CONSUMER STATED HE RECEIVED AN URGENT RECALL NOTICE IN THE MAIL. HOWEVER, WHEN SHE CALLED THE DEALER TO SCHEDULE AN APPOINTMENT, SHE WAS INFORMED THE PART WAS NOT AVAILABLE AND THEY WERE NOT SURE, WHEN IT WOULD ARRIVE.

TL* THE CONTACT OWNS A 2006 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE REVERSING AT 5 MPH, THE POWER STEERING ASSIST FAILED AND THE STEERING WHEEL COULD NOT BE MOVED IN EITHER DIRECTION. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE SPIRAL CABLE, STEERING SHAFT, THE CONNECTING YOKE, AND THE STEERING COLUMN SHAFT EXTENSION NEEDED TO BE REPLACED. THERE WAS A RECALL FOR THE STEERING FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 06V188000: (STEERING: ELECTRIC POWER ASSIST SYSTEM) HOWEVER, THE VEHICLE WAS REPAIRED BY THE CONTACT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO FILED A COMPLAINT AND OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 77,000. UPDATED 10/19/12 *CN UPDATED 10/23/2012 *JS UPDATED 11/19/12 *BF UPDATED 11/20/2012 *JS *DT *TP

WHILE MY 16 YEAR OLD SON WAS PRACTICING DRIVING MANEUVERABILITY WITH MY WIFE IN A PARKING LOT, THE STEERING SHAFT COMPLETELY FAILED AND THE VEHICLE COULD NOT BE CONTROLLED OR STEERED. THEY PARKED THE CAR SAFELY AND GOT A RIDE HOME. IT WAS FOUND THAT THE SPLINES ON ONE OF THE INTERMEDIATE STEERING SHAFTS COMPLETELY FAILED. THE UPPER PARTS OF THE STEERING MECHANISM COULD TURN WITHOUT TURNING THE LOWER PARTS. TOYOTA HAD A RECALL ON SOME 2004-2006 VEHICLES WITH THIS EXACT DESCRIPTION OF PARTS BUT MY VIN IS NOT INCLUDED IN THE RECALL. MY FAILURE IS EXACTLY AS DESCRIBED: LOW SPEED WITH THE STEERING TURNED AT THE END OF TRAVEL. SEARCHING THE PRIUS FORUMS ON LINE, THIS IS A COMMON PROBLEM. EVEN CARS THAT HAVE HAD THEIR STEERING MECHANISMS REPLACED HAVE FAILED A SECOND TIME. THE ISSUE IS A DEFECTIVE DESIGN OF THE STEERING SHAFT. FIRST, THE ELECTRIC POWER STEERING...

SERVICE VISIT FOR OUR 2006 PRIUS WAS COMPLETED ON FEB 5, 2011 AND UPON DRIVING HOME THE CAR STEERED DIFFERENTLY. A SECOND SERVICE VISIT WAS INITIATED AT OUR REQUEST AND THE DEALER INSPECTED THE CAR AND FOUND NO PROBLEM. ON FEBRUARY 25, 2011 A THIRD SERVICE VISIT WAS INITIATED AT OUR REQUEST AND THE SERVICE DEPARTMENT PROVIDED A WRITTEN ESTIMATE FOR REPLACING A "FAILING STEERING MOTOR ASSEMBLY" FOR AN OUT OF WARRANTY COST OF $1950.00 PLUS TAX AND INSTALLATION. I ASKED IF THIS WAS A RECALL ITEM AND THEY INDICATED NO AND A CALL TO TOYOTA ON CASE NUMBER 1102251605 ARRIVED AT THE SAME CONCLUSION. OUT OF WARRANTY AND NO RECALL AT THIS TIME. THE RESPONSE TO A QUESTION "IS THIS CAR SAFE TO DRIVE" TO THE DEALER SERVICE EMPLOYEES WAS RESPONDED TO WITH YES THE CAR IS SAFE TO DRIVE. I HAVE READ ON THE INTERNET THAT IF THIS...

DRIVING IN GOOD WEATHER ON A LOCAL ROAD AND CAR SKID LIGHT WENT ON AND WHEELS LOCKED TO THE RIGHT. STEERING WAS NOT RESPONSIVE. THE LACK OF STEERING CAUSED THE ACCIDENT. HOWEVER, THE AIRBAGS DID NOT DEPLOY.

1) STEERING WHEEL/SHAFT APPEARS TO BE IMPROPERLY SUPPORTED; FEELS LOOSE WHEN TURNING LOCK TO LOCK SINCE NEW. HAVE BROUGHT TO THE ATTENTION OF FOUR (4) TOYOTA DEALERS WHEN SERVICE PERFORMED (HAVE TAKEN TO TOYOTA FOR ALL SERVICE WORK SINCE NEW), ALL HAVE ADVISED THAT THERE IS "NOTHING WRONG" WITH THE VEHICLE. IT IS THE ONLY VEHICLE WE HAVE EVER OWNED THAT HAS THIS SENSE OF DISCONNECT AND POTENTIAL FOR A MUCH MORE SERIOUS ISSUE WERE THERE EVER A STEERING FAILURE. 2) OVER ROUGH ROADS (WHEN VEHICLE WAS DRIVEN IN SEATTLE AND BELLEVUE, WA) WHEN STOPPING, THE ABS SYSTEM SEEMS TO ACTIVATE PREMATURELY AND INCREASE STOPPING DISTANCES. WE HAVE OTHER VEHICLES WITH ABS BRAKES WHICH DO NOT ACTIVATE SO READILY AND STOP SO SLOWLY. AS IT RELATES TO INCIDENT DATE(S): SINCE NEW, VEHICLE PURCHASED NOVEMBER 2005. *TR

I WAS DRIVING AT ABOUT 65 M/HR ON I-95 AND NOTICED MY CAR VEERING FIRST TO THE LEFT THEN TO THE RIGHT. I WAS PUZZLED BY THIS AND LOOKED OVER TO NOTICE THAT TREES WERE NOT MOVING, I.E., IT DID NOT FEEL WINDY OUTSIDE. THIS WAS A VERY PECULIAR INCIDENT THAT HAS HAPPENED TO MY CAR ABOUT 3-4 TIMES IN THE PAST 3 YEARS. I LATER HEARD ON THE NEWS THE RECALL OF COROLLAS FOR THE SAME TYPE OF ISSUE. THEY ACTUALLY SHOWED A TEST MODEL SIMULATION AND IT LOOKED EXACTLY LIKE WHAT I HAVE BEEN EXPERIENCING. I DON'T KNOW IF THIS IS MY IMAGINATION BUT IT CERTAINLY DID NOT FEEL THAT WAY WHEN THE INCIDENT OCCURRED. *TR

MY 2006 TOYOTA PRIUS HAS SEVERAL ISSUES WITH ACCELERATION, BRAKING, TURNING CAR OFF AND ON ALARM GOES OFF CONSTANTLY AND TERRIBLE GAS MILEAGE AROUND 30 MILES PER GALLON. *TR

IN 10/06, I HAD AN INCIDENT WHERE THE BRAKES AND STEERING OF MY 2006 PRIUS CEASED TO FUNCTION BRIEFLY, AS I TRIED TO BRAKE AT AN INTERSECTION. I TOOK THE CAR IN TO MY TOYOTA DEALER SHORTLY AFTER -- THEY CHECKED IT BUT FOUND NOTHING WRONG, SO NOTHING WAS DONE. THE DAY IN QUESTION WAS DRIZZLY AND THE ROADS WET. IT WAS DAYTIME, AND I WAS DRIVING WITH MY CHILDREN IN BOSTON, APPROACHING THE FOREST HILLS INTERSECTION. THERE WERE TROLLEY TRACKS IN THE ROAD (SINCE REMOVED), WHICH I TRY TO AVOID, SINCE I KNOW THEY CAN BE SLIPPERY. AS I APPROACHED THE INTERSECTION, GOING ABOUT 20 MPH, I PUT MY FOOT TO THE BRAKE. AT THAT POINT, IT SEEMED TO ME THAT BOTH THE BRAKES AND THE STEERING CEASED TO FUNCTION OR FROZE UP, SO THAT I COULDN'T STOP THE CAR OR KEEP IT GOING STRAIGHT. THUS THE CAR KEPT...

TL*THE CONTACT OWNS A 2006 TOYOTA PRIUS. WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL SUDDENLY JERKED OUT OF HIS HANDS AND TURNED SHARPLY TO THE LEFT. THE CONTACT COULD NOT MAINTAIN CONTROL OF THE VEHICLE AND THE VEHICLE WAS TOWED TO THE DEALER. THE FAILURE HAS OCCURRED TWICE SINCE LAST YEAR. THE DEALER STATED THAT THE STEERING COMPUTER CONTROLS THE ELECTRIC POWER STEERING SYSTEM. THE COMPUTER WAS SENDING THE WRONG OR FALSE SIGNALS. THE DEALER IS CURRENTLY REPAIRING THE VEHICLE. THE FAILURE MILEAGE WAS 90,000. UPDATED 2/17/09 *CN THE DEALER REPLACED THE TORQUE SENSORS.UPDATED 02/19/09. *JB