2008 TOYOTA COROLLA Fuelpropulsion System Problems

The plastic fuel tank has a heat shield below it that keeps the fuel tank from getting too hot, and from debris hitting it. There is a strap that goes around the fuel tank. The heat shield has this plastic piece that holds on to the strap. On my car, this plastic piece snapped off and the heat shield was rattling loose against the exhaust pipe and exposing the fuel tank. I took my car to a Toyota dealer (Glen Mills, PA) and was told the only way to fix that plastic piece is to replace the whole heat shield and fuel tank strap. Even though this was due to their defective piece. I was told it would be $950 for this repair. I was forced to deny the repair due to the obscene price tag and took it to a dealer for a temporary fix until Toyota can be...

I SMELL GAS AND THE CHECK ENGINE LIGHT COMES ON THE CAR CUTS OUT THEN ACTS LIKE IT GOES INTO A LOW GEAR. THIS HAPPENS WHEN DRIVING. SO FAR NOTHING MAJOR HAS HAPPENED BUT WHO KNOWS WHEN IT COULD CHANGE. THIS STARTED OVER A YEAR AGO. WE HAD IT CHECKED AND IT SHOWED 5 CODES WHICH INDICATED THE CHARCOAL FUEL FILTER CANISTER WAS BAD. WE WAS TOLD THE COST OF THE PART WOULD BE $300.00 AND WAS TOLD BY THE DEALER THEY HAVE HAD A LOT OF THESE PROBLEMS WITH IT AND HAVE REPLACED A LOT IF THEM AT THE OWNERS EXPENSE WHICH IS BETWEEN $300-$500 WITH LABOR COST. TOYOTA HAD RECALLED THIS PART UP TO 2006 BUT NOT BEYOND. WE HAVE CHECKED INTO THIS AND THERE HAVE BEEN THOUSANDS OF PEOPLE HAVING THE SAME PROBLEM. WE HAVE CONTACTED TOYOTA CORP AND HAVE A CASE # 1405291178. WE CONTACTED THEM...

TL* THE CONTACT OWNS A 2008 TOYOTA COROLLA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THERE WAS A LOUD BANGING NOISE OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK STRAPS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 27,455. ...UPDATED 10-24-13 *BF UPDATED 11/1/2013 *JS

WHILE DRIVING, A STRAP ON THE FUEL TANK AND THE CATALYTIC CONVERTER HEAT SHIELD BOTH, SIMULTANEOUSLY, BECAME LOOSE AND BEGAN RATTLING TERRIBLY. I CONTINUED DRIVING THE CAR IN ORDER TO GET HOME, A DISTANCE OF ABOUT 200 MILES, WITH THE LOUD NOISE CONTINUING THROUGHOUT. I THOUGHT THE HEAT SHIELD WAS LOOSE, WHICH IT WAS, BUT I DID NOT REALIZE THE FUEL TANK STRAP HAD FAILED, OR I WOULD NOT HAVE CONTINUED DRIVING BECAUSE OF THE DANGER OF FIRE. I TOOK THE CAR TO THE DEALERSHIP. THEY SHOWED ME THAT THE STRAP AND THE SHIELD WERE BOTH LOOSE BECAUSE BOLTS HOLDING THEM IN PLACE HAD RUSTED THROUGH. THIS CAR IS NOT OLD NOR IS IT DRIVEN VERY MANY MILES. THE DEALER REPLACED THE STRAP AND THE SHIELD AT A COST OF $476. *TR