2007 TOYOTA 4RUNNER Structurebody Problems

I was having front brakes repaired, and mechanic called me over to lift to see under the car. Extremely rusty, flakes of metal coming off. He advised I do not even try and put it on a lift again, as he does not trust the structural integrity. He advised that it was definitely not normal, and not in keeping with the otherwise excellent and well cared for car.

The frame on my 4-Runner is rusted out to the point of being borderline unsafe, as per the Toyota Dealer. I don't have a scanner otherwise I would upload the pictures. The invoice from the dealer has my contact info. Not sure if you want that info.

The Undercarriage of my 2007Toyota 4runner sport has irregular rusting issue. The truck has 128,000 miles on it and has been well maintained and garaged most of its life. I was under it the other day to check the exhaust system and noticed the frame is rusting like no other car I know of. Even cars that sat in junkyards for decades. I know they had a recall for similar issues with other vehicles within the same year. However, when I spoke with Toyota they were uninterested in helping me and told me it was my problem. Other than the frame rust the truck is in perfect condition. Is this something that you can help me with. I see I am not alone having this issue and that it is well reported. Please let me know what my options are for getting this defect corrected by Toyota. Thanks, [XXX] INFORMATION...

Excessive frame rust on the frame itself and on suspension components including control arms and support brackets. Toyota dealership stated that rust could be an issue with maintenance.

RECENTLY LOOKED AT 2007 TOYOTA 4RUNNER LIMITED V8 FOR SALE TO REPLACE MY 2005 LIMITED THAT HAS SEVERE FRAME CORROSION AND DISCOVERED THAT THIS VEHICLE TOO HAS NEARLY THE EXACT SAME CORROSION ISSUES. THE REAR OF THE FRAME BY THE BUMPER, WHERE THE CONTROL ARMS AND RADIATOR ARE ATTACHED TO THE CHASSIS AND FRAME RAILS ARE SO BADLY CORRODED YOU CAN PUSH YOUR FINGER THROUGH THE METAL. HOW MUCH MORE EVIDENCE DOES NHTSA NEED TO DEMAND TOYOTA RECALL THESE VEHICLES? LOOK AT THE HUNDREDS OF COMPLAINTS TO NHTSA AND THOUSANDS OF OWNERS ONLINE POSTING PICTURES AND VIDEOS OF THEIR VEHICLES RUST ISSUES. THERE IS A MAJOR PROBLEM WITH THESE VEHICLES CORRODING JUST LIKE THE OTHER TOYOTA BODY ON FRAME PRODUCTS THAT WERE RECALLED FOR FRAME REPLACEMENTS. WE OWN TRUCKS 30-40 YEARS OLD AND NOT ONE OF THEM HAS EVER HAD A FRAME RUST THROUGH TO THE POINT YOU CAN LITERALLY...

I HAVE A 2007 4RUNNER WITH CURRENTLY AROUND 180K MILES. WHEN I PURCHASED THE VEHICLE IT HAD SOME RUSTING TO THE FRAME BUT NOTHING DEEMING IT UNSAFE OR DANGEROUS. WITHIN A MATTER OF MONTHS THE FRAME HAD, AND STILL IS, RUSTING AND DETERIORATING AT AN ALARMING RATE. I AM NOT SURE HOW TOYOTA HAS GOT AWAY WITH THIS ISSUE THUS FAR BUT I'M PRUONG

VEHICLE HAS PREMATURE EXCESSIVE RUST OF THE FRAME AND ASSOCIATED COMPONENTS AND SHOULD HAVE BEEN INCLUDED IN THE SAME RECALL MY 05 SEQUOIA (AS WELL AS TACOMAS AND TUNDRAS) OF THE SAME ERA SINCE ALL WERE MANUFACTURED WITH THE SAME PROCESS THAT LACKED ADEQUATE APPLICATION OF RUST PROTECTION/COATING. MANY OTHERS ON HERE AS WELL AS ONLINE ON OTHER SITES ALSO ARE REPORTING THIS GENERATION OF 4RUNNER TO HAVE RUSTING. I HAVE RUSTED MOTOR MOUNTS THAT CAUSE MOTOR VIBRATION, RUSTED BRACKETS HOLDING MY GAS TANK TO THE FRAME, I HAVE HAD TO REPLACE ALL TRANSMISSION LINES DUE TO RUST THAT LEFT ME STRANDED WHILE MOVING ACROSS THE COUNTRY. I HAVE HAD TO DO REPLACE SEVERAL RUSTED PARTS LIKE CV AXELS, WHEEL BARRINGS, AND POSSIBLY RUSTED STEERING BOX LEAK/RACK AND PINION (CONFLICTING INFO FROM2 MECHANICS SO UNDETERMINED). I PURCHASED THIS IN 2014 AND JUST PAID IT OFF AND NEED HELP AS IT...

THE FRAME HAS COMPLETELY RUSTED THROUGH IN MANY PLACES. WE HAVE HAD IT CHECKED AND BEEN ADVISED THE VEHICLE IS NOT SAFE TO DRIVE.THIS IS A KNOWN PROBLEM ON MANY 4 RUNNERS AS WELL AS OTHER TOYOTA VEHICLES IN THE SAME ERA.

VERY WELL TAKEN CARE OF AND FRAME IS RUSTING THRU IN MULTIPLE SPOTS ALREADY

VERY RUSTY FRAME. RADIATOR MOUNT RUSTED OUT AND ALSO CROSSMEMBERS.

MY REAR WINDOW SHATTERED AFTER USING THE DEFROSTER. ONCE I GOT OUT OF MY CAR AFTER PARKING IT IN MY JOB'S GARAGE IT BUSTED ON IT'S OWN. I FOUND OUT THAT THIS HAS HAPPENED TO MANY 4TH GENERATION 4RUNNER OWNERS BUT TOYOTA WON'T RECALL OR EXTEND THE WARRANTY FOR THIS ISSUE ANY LONGER. NOW I HAVE TO EITHER NEVER USE MY REAR DEFROSTER AGAIN WHILE LIVING IN COLORADO OR RISK IT SHATTERING AGAIN AND HURTING PASSENGERS IN MY CAR. I WOULD HAVE NEVER BOUGHT THE VEHICLE IF I HAD KNOWLEDGE OF SUCH A DANGEROUS ISSUE.

I PURCHASED MY 2007 4RUNNER AND FOUND A-LOT OF RUST ON THE UNDER CARRIAGE OF MY FAVORITE VEHICLE. IT SPREADS EVERYWHERE; INCLUDING THE ENGINE BAY. NOT ONLY DOES IT COMPROMISE THE SAFETY OF THE VEHICLE BUT IT SHORTENS THE LIFE ALSO. I WANTED TO BUY A NEW 4RUNNER THIS YEAR BUT AFTER LEARNING OF THE RUST ISSUES I THOUGHT TWICE.

THERE IS LOT OF RUST ON THE FRAME AND TOYOTA IS NOT GOING TO DO ANYTHING ABOUT IT.

NOTICED RUST ON FRAME FEW YEARS AGO BUT THE DEALER SAID TOYOTA WILL NOT DO A ANYTHING. IF TACOMA IS BEING RECALLED, 4 RUNNER SHOULD BE SINCE IT IS BUILD ON THE SAME FRAME. *DT*JB

FRAME IS VERY RUSTY. REPLACING SEVERAL STEERING AND SUSPENSION COMPONENTS. THE METAL IS VERY THIN AND RUSTY RIGHT UNDER THE RADIATOR TO THE POINT WHERE THERE IS NOW A HOLE IN IT AND MAY COLLAPSE IN THE EVENT OF A CRASH.

THE WHOLE AREA OF EXPOSED STEEL HAS BEEN SO CORRODED WITH RUST THAT I ACNNOT EVEN REMOVE BOLTS TO SERVICE SEVERAL OF THE KEY COMPONENTS IN THE ENGINE COMPARTMENT. THE FRAME, CROSS MEMBERS, SUSPENSION ETC. ARE ALSO AFFECTED IN THIS WAY.I'M NO EXPERT BUT IT IS PROGRESSIVELY BECOMING MORE AND MORE UNSAFE TO DRIVE ESPECIALLY IF I LOSE BRAKES OR SOME OTHER NECESSARY FUNCTION. PLEASE HELP, IS THIS A BAD BATCH OF CHEAP STEEL?

VEHICLE FRAME IS EXTREMELY CORRODED TO THE POINT WHERE REPLACING NECESSARY ITEMS SUCH AS SHOCKS/STRUTS/STEERING COMPONENTS IS NOT POSSIBLE WITHOUT IRREPARABLE DAMAGE. FACTORY WELDS AT CRITICAL POINTS OF THE FRAME STRUCTURE ARE STARTING TO FAIL AND CAUSING SAFETY CONCERNS. THIS VEHICLE IS REGULARLY GARAGED AND ONLY HAS 85,000 MILES. THIS IS UNACCEPTABLE, THERE HAVE BEEN PREVIOUS RECALLS AND FOR OTHER MODELS THAT SHARE THIS EXACT SAME FRAME AND SUSPENSION.

I WAS DRIVING WITH MY CHILD IN THE CAR AND LOST CONTROL OF STEERING AND HEARD LOUD NOISE. I HAD NO CONTROL OF STEERING AND THE CAR CROSSED LANES LUCKILY MISSING OTHER VEHICLES. IT STOPPED ON THE SIDE OF THE ROAD AND A BODY SHOP HAPPENED TO WITNESS THE WHOLE THING. HE TRIED TO DRIVE IT INTO HIS SHOP (TWO DRIVEWAYS AWAY) BUT ENDED UP HAVING TO DRAG/TOW IT IN BECAUSE THE FRONT END FRAME HAD RUSTED AND FALLEN FROM THE VEHICLE. THAT BODY SHOP LOOKED AT IT AND I ALSO GOT A SECOND OPINION AND THEY TOLD ME THE SAME THING. THE FRONT END OF THE CAR NEEDS TO BE REPLACED. THE FRONT STEERING RUSTED SO BADLY IT DISCONNECTED COMPLETELY AND FELL OUT FROM THE FRAME. IT IS ALSO SO RUSTED THERE IS NOT ENOUGH METAL TO RE-WELD IT TOO. THE CAR IS TOTALED WHEN THE CAR HAS BEEN...

THE HATCH LATCH HAS MELTED AND PRESENTS PROBLEMS IN UNLATCHING. THE DEALER DENIES THIS IS A PROBLEM. ESPECIALLY IN COOLER WEATHER, I AM OFTEN NOT ABLE TO OPEN THE REAR HATCH. MY RESEARCH INDICATES THAT MANY OWNERS OF THIS MODEL EXPERIENCE THE SAME ISSUES. THERE IS SOME CONCERN THAT THE CAUSE IS FAULTY WIRING THAT OVERHEATS THE MATERIAL. ALSO, THE REPLACEMENT PART IS THE SAME AS THE ORIGINAL; THEREFORE, NOT RESOLVING THIS ISSUE. THIS SHOULD BE A SAFETY CONCERN AND SHOULD BE REMEDIED BY THE MANUFACTURER.

REAR WINDOW DEFROSTER WAS ACCIDENTALLY TURNED ON (RIGHT ADVICE CUP HOLDER) CAUSING REAR WINDOW TO SHATTER WHILE DRIVING. IT WAS STATIONARY AT A LIGHT AT THE TIME. *TR

BACK DOOR LATCH HAS BECOME A STICKY MESS. WHEN OPENING, A TAR LIKE SUBSTANCE GETS ALL OVER YOUR FINGERS.

SEVERE RUST PROBLEM ON THE FRAME/HITCH/REAR HATCH. WE WERE ADVISED NOT TO USE THE REAR HITCH DUE TO THE RUST AND THAT IT COULD COME LOOSE WHEN TOWING..

THE TAILGATE LATCH IS MADE FROM SOME RUBBER COMPONENT. IT HAS MELTED INTO MUSH. THIS MAKES IT DIFFICULT TO OPEN BACK HATCH DOOR. IT ALSO HAS MADE A MESS ON PAINT ON TAIL GATE. *TR

ON THE BACK OF THE TRUCK, IN THE MIDDLE OF THE REAR DOOR, MY CAR BEGAN TO RUST OUT OF NOWHERE. I DO NOT LIVE BY THE OCEAN OR ANY OTHER TYPE OF ENVIRONMENT TO CAUSE RUST AND IN THE WINTER TIME, THE TRUCK IS GARAGE KEPT. AFTER HEARING FROM A NUMBER OF PEOPLE HAVING THE SAME PROBLEM, CALLING TOYOTA TO FIND OUT THAT THEY HAVE NO RECALL, I TOOK THE CAR TO AN AUTO BODY SHOP. THE EXPERT LOOKED AT THE RUST, WENT TO SCRAPE IT, AND THE EXTERIOR CRUMBLED IN CREATING A DECENT HOLE. THE EXPERT SAID THAT THERE WAS NO REASON FOR A TRUCK THIS AGE SHOULD HAVE THIS PROBLEM. HE CALLED TOYOTA TO COMPLAIN SAYING THAT THIS IS A PROBLEM TOYOTA SHOULD FIX, BUT THEY SAID THEY HAD NO RECALL ON THE ISSUE. THE EXPERT TOLD ME THAT THE CAR WAS RUSTING FROM THE INSIDE AND...