2022 THOR MOTOR COACH ARIA — Problems, Recalls & Safety Data
N/A
Safety Rating
3
Owner Complaints
0
Recalls
2
Service Bulletins
0
Investigations
Overview of the 2022 THOR MOTOR COACH ARIA
The 2022 THOR MOTOR COACH ARIA has received a total of 3 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). 2 technical service bulletins have been issued by Thor Motor Coach for this model year. The most commonly reported problem area is the Seat Belts (2 complaints).
Recalls for the 2022 THOR MOTOR COACH ARIA
There are no recalls on file with NHTSA for the 2022 THOR MOTOR COACH ARIA. No Active Recalls
Owner Complaints for the 2022 THOR MOTOR COACH ARIA
3 complaints have been filed with NHTSA for the 2022 THOR MOTOR COACH ARIA. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Seat Belts | 2 | 0 | 0 | 0 | 0 |
| Tirespressure Monitoring And Regulating Systems | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
Manufacturing defect renders driver and passenger seat belts non-functioning; fails to meet the minimum safety standards. Owners purchased 22 Thor Motor Coach Aria A Regent from Lazydays RV in Seffner, Florida with an in-service date of 26 May 2022. One driver noticed that the seat belt was too tight, and could not comfortably fasten it. On or around 4 July 2022, another driver and owner was unable to fully fasten the seat belt as it was too tight unless the driver moved the seat back; but with the seat moved back, such driver could not safely reach the pedals or the dash. Seat belt will not extend to allow comfortable use, driving, access to the dash, or safe application of the pedals. Owners contacted Lazydays RV about this issue, and was instructed to simply not wear a seat belt. The Owners, finding this answer unacceptable, persisted. Lazydays RV eventually located seat belt extenders, which were then ordered at a cost to the Owners of $55.88. The seat belt extenders have not been installed as of the date of this complaint, but the Owners find this defect unacceptable.
Driver 5'07" tall weight approximately 245 lbs in seated position comfortable driving the seat belt will not extend to allow release or application of the emergency/parking brake.
Tire pressure monitoring system fails during vehicle operation. The system will report high tire temperatures, high tire pressures and different tire readings will drop out providing no information. The inaccurate reporting informs the driver the vehicle has excessive tire temperatures and low or high tire pressures. The motorhome has been to the Freightliner repair facility twice and the defects are still occurring. This defect has occurred in August 2021, September 2021, October 2021, January 2022
Safety Rating for the 2022 THOR MOTOR COACH ARIA
NHTSA has not yet tested the 2022 THOR MOTOR COACH ARIA in its New Car Assessment Program.
Technical Service Bulletins for the 2022 THOR MOTOR COACH ARIA
Thor Motor Coach has issued 2 technical service bulletins (TSBs) for the 2022 THOR MOTOR COACH ARIA. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
TSB 22-01 — ELECTRICAL SYSTEM
If a customer is experiencing inconsistent inverter readings on the Firefly panel, please utilize the below instructions.
RC000229SADealer — STEERING
On certain Detroit Model 2 and 3 steer axles, the tie rod arm and steering arm bolts used to assemble front axle assemblies have a lengthwise âseamâ defect which increases stress concentration, potentially leading to bolt failure or loss of pre-load This affects the following Thor Motor Coach products: model...
NHTSA Investigations for the 2022 THOR MOTOR COACH ARIA
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the THOR MOTOR COACH ARIA
- 2017 THOR MOTOR COACH ARIA — 3 complaints
- 2018 THOR MOTOR COACH ARIA — 2 complaints
- 2019 THOR MOTOR COACH ARIA — 3 complaints
- 2020 THOR MOTOR COACH ARIA — 2 complaints
- 2021 THOR MOTOR COACH ARIA — 1 complaint
- 2022 THOR MOTOR COACH ARIA (current)
- 2025 THOR MOTOR COACH ARIA — 0 complaints
Other THOR MOTOR COACH Models
- THOR MOTOR COACH HURRICANE — 63 total complaints
- THOR MOTOR COACH PALAZZO — 55 total complaints
- THOR MOTOR COACH WINDSPORT — 55 total complaints
- THOR MOTOR COACH A.C.E. — 50 total complaints
- THOR MOTOR COACH CHALLENGER — 43 total complaints
- THOR MOTOR COACH MIRAMAR — 39 total complaints
- THOR MOTOR COACH OUTLAW — 34 total complaints
- THOR MOTOR COACH FOUR WINDS — 31 total complaints