2009 SUBARU IMPREZA Power Train Problems

The contact owns a 2009 Subaru Impreza. The contact stated while driving 40 MPH, the transmission failed to properly shift. There was no warning light illuminated. The contact was able to pull over on the side of the road and shut off the vehicle. Once the contact restarted the vehicle, the vehicle started operating normally; however, the vehicle stalled. The vehicle was taken to the dealer and the contact was informed that the clutch pedal bracket had fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was under recall however, the recall had expired. The contact was advised to contact the NHTSA Hotline for assistance. The failure mileage was 54,000.

THE FIREWALL PREVENTS THE VEHICLE FROM ENGAGING IN GEARS WHILE DRIVING

09 WRX HATCH, WHEN THE CLUTCH IS DEPRESSED IT WILL MAKE A CREAKING NOISE. UPON FURTHER INSPECTION, THE FIREWALL FLEXES A LOT WHILE THE CLUTCH IS PRESSED IN. IT IS GETTING LOUDER AND IS STARTING TO AFFECT THE BRAKE PEDAL BY MOVING IT EVERYTIME THE CLUTCH IS DEPRESSED.

SUBARU OF AMERICA INC. SHOULD RECALL 2008-2014 IMPREZA, IMPREZA WRX, AND IMPREZA WRX STI. THESE VEHICLES JUST ABOVE THE DRIVERS FEET, USE 6 SPOTS WELDS TO HOLD A MOUNTING BRACKET FOR THE PEDAL ASSEMBLY TO THE INSIDE OF THE FIREWALL.THIS DESIGN FLAW, WHERE THE PEDAL MOUNTING BOX IS SPOT-WELDED TO THE FIREWALL USING ONLY A HANDFUL OF TINY SPOT WELDS IS DANGEROUS. THE FIREWALL ITSELF IS OF A WEAK DESIGN AND INHERENTLY HAS QUITE A BIT OF FLEX AND OVER TIME AND NORMAL USE THESE SPOT WELDS FAIL FROM TOO MUCH STRESS AND THE PEDALS WILL BEGIN TO SQUEAK, CREAK, POP AND EVENTUALLY THE PEDALS WILL MOVE AWAY FROM THE FIREWALL WHEN DEPRESSED. ONCE THIS HAPPENS THE CLUTCH AND OTHER PEDALS WILL NO LONGER PROPERLY ENGAGE OR DISENGAGE AND THE CAR WILL NO LONGER BE DRIVABLE. IN THE EVENT OF THIS FAILURE AT HIGHWAY SPEEDS POTENTIALLY CATASTROPHIC LOSS OF LIFE...

MOTOR WENT OUT WITH 72000 MILES WHILE ON THE HIGHWAY DRIVING. TRANSFER CASE BEARINGS SHOT. POWER STEERING RACK DONE AND FIREWALL HAS CRACKED FOR A 2ND TIME. SUBARU ARE PROBABLY THE MOST UNSAFE VEHICLES ON THE ROAD.

DURING NORMAL USE OF THE CLUTCH ON THE STREET , THE FIREWALL WELDS BRAKE OFF CAUSING THE FIREWALL TO BEND. ALSO EFFECTS THE CLUTCH PEDAL MAKING IT 'CLICK' IF NOT FIXED CAN CAUSE MORE DAMAGE.

CHASSIS FATIGUE AND CRACKING RESULTING IN DAMAGE/POTENTIAL COMPROMISE OF DRIVER CONTROLS. CLUTCH PEDAL ASSEMBLY BROKE AND WILL NO LONGER DISSENGAGE THE CLUTCH(DRIVETRAIN SYSTEM). THIS HAPPENED WHILE DRIVING ON A LOCAL HIGHWAY AT A SPEED OF APPROXIMATELY 45MPH. I WAS FORCED TO DRIVE THE VEHICLE OFF OF THE ROAD TO AVOID A POTENTIAL COLLISION WITH ANOTHER VEHICLE. THE WHOLE ASSEMBLY IS COMPRISED OF BOTH THE CLUTCH AND THE BRAKE PEDALS. DUE TO THE ASSEMBLY FAILURE THE BRAKE PEDAL HAS SIGNIFICANT PLAY IN IT AS WELL AND DOESNT FUNCTION PROPERLY. UPON INSPECTION I FOUND THAT STRUCTURAL WELDS ON THE FIREWALL, WHERE THE ASSEMBLY IS MOUNTED, HAVE FAILED. I CALLED SUBARUOFAMERICA ABOUT THE ISSUE ON 08 MAY 2018. I REFERENCED TWO DIFFERENT TSB'S REGARDING THIS ISSUE ON MY YEAR RANGE OF VEHICLE. 1) NHTSA ID: 10090413 TSB ID: WE 2) NHTSA ID: 10090409 TSB ID: 12-184-15 I WAS TOLD THAT THE EXTENSION TO...

DUE TO THE FIREWALL FLEXING EVERY TIME THE CLUTCH PEDAL IS DEPRESSED, OVER TIME THE SPOT WELDS CONNECTING THE CLUTCH PEDAL MOUNTING BRACKET TO THE FIREWALL FAIL. THIS ALLOWS FOR PLAY IN THE ENTIRE CLUTCH/BRAKE PEDAL ASSEMBLY. GIVEN ENOUGH OF THE WELDS BREAK, THE VEHICLE CAN NO LONGER BY PUT INTO GEAR. I BECAME UNABLE TO PUT THE CAR INTO REVERSE OR FIRST GEAR FROM A DEAD STOP. IT TOOK ABOUT 5 MINUTES OF TRYING TO GET IT INTO 1ST TO GET HOME. LUCKILY THIS DID NOT OCCUR WHILE AT SPEED.

THE CLUTCH PEDAL ON MY 2009 WRX CONSTANTLY REQUIRES ADJUSTMENT TO ENABLE THE RELEASE OF THE CLAMP PRESSURE ON THE DRIVEN PLATE OF THE CLUTCH ASSEMBLY WHEN THE CLUTCH FOOT PEDAL IS DEPRESSED. UPON INVESTIGATING A CREAKING NOISE, I NOTICED THAT THE ENTIRE CLUTCH PEDAL BRACKET ASSEMBLY (ATTACHED TO THE FORWARD FIREWALL) SHIFTS APPROX 1/4 INCH TO THE LEFT AND DOWN EACH TIME THE CLUTCH PEDAL IS ACTIVATED. THIS CLUTCH PEDAL BRACKET ASSEMBLY HAS THREE BROKEN SPOT WELDS SECURING THE CLUTCH PEDAL BRACKET TO THE FORWARD FIREWALL. FROM THE OUTSIDE OF THE FIREWALL, UNDERNEATH THE DRIVER'S SIDE WINDSHIELD WIPER, I CONFIRMED THE MANUFACTURER'S SPOT WELDS ARE PULLING AWAY FROM THE FIREWALL EACH TIME THE CLUTCH PEDAL IS DEPRESSED. THIS WELD DEFECT STEMMING FROM THE MANUFACTURER ALLOWS THE ENTIRE CLUTCH PEDAL BRACKET ASSEMBLY TO MOVE UNSECURED, ULTIMATELY PREVENTING THE TRANSMISSION TO ENGAGE THE VEHICLE INTO 1ST, 2ND, OR REVERSE GEAR. I...

WHEN I PUSH CLUTCH IN ITS POPPING AND FLEXING. I FOUND THAT THE WHOLE PEDAL ASSEMBLY IS MOVING BACK AND FORTH CAUSING FIREWALL TO FLEX AT SPOT WELDS.ITS CAUSING CLUTCH ENGAGEMENT DIFFICULT.

I BOUGHT MY 2009 SUBARU IMPREZA WRX HATCHBACK A LITTLE OVER A YEAR AGO BECAUSE IT IS SUPPOSEDLY A RELIABLE VEHICLE. I HAVE ALWAYS NOTICED A SLIGHT SHIFT IN THE BRAKE PEDAL WHEN ENGAGING THE CLUTCH. WE WERE TOLD BY MANY SUBARU OWNERS THAT THAT IS NORMAL. ABOUT A MONTH AGO IT BECAME VERY HARD TO PUT THE CAR INTO REVERSE. IT IS NOW ALMOST IMPOSSIBLE TO PUT MY CAR IN REVERSE AS WELL AS SHIFT BETWEEN GEARS. WE WERE GOING TO REPLACE THE CLUTCH BUT AFTER LOOKING ONLINE NOTICED THE HUNDREDS OF COMPLAINTS ABOUT THE SAME EXACT THING. THE CLUTCH WILL NOT ENGAGE BECAUSE THE FIREWALL IS CRACKING WHERE THE MASTER BRAKE CYLINDER MOUNTS FOR IT ARE. APPARENTLY SUBARU IS AWARE OF THIS DEFECT BUT HAS NOT DONE ANYTHING TO REMEDY THE SITUATION.

CAR USED AS DAILY DRIVER TO COMMUTE LESS THAN 14 MILES ROUND TRIP FOR WORK. CLUTCH BEGAN TO DEVELOP A POP NOISE WHICH THEN TURNED INTO A LOUD SQUEAK FOLLOWED BY MORE THAN A 1/2" OF MOVEMENT TO THE LEFT THAT THE BRAKE PEDAL WOULD START TO MOVE WHEN THE CLUTCH WOULD BE DEPRESSED. AFTER FURTHER INVESTIGATION OF READING LOCAL OWNERS THREADS AND ASKING AROUND I HAVE FOUND THAT THE WELDS THAT HOLD MY BRAKE AND CLUTCH TOGETHER HAVE BROKEN AND ARE CONTINUING TO BREAK WHICH COULD LEAD TO MY CLUTCH PEDAL ASSEMBLY FALLING DOWN TO THE FLOOR BOARD WHICH COULD POTENTIALLY RENDER ME FROM USING MY BRAKE PEDAL. THIS IS A COMMON ISSUE WITH ALL SUBARU IMPREZA WRX AND STI OWNERS WHICH CAN BE FOUND ON MULTIPLE LOCAL OWNERS CLUB WEBSITES AND COULD AFFECT BODILY HARM TO DRIVERS OF THE CARS AND OTHER DRIVERS ON THE ROAD! SUBARU REFUSES...

STARTING TO HAVE PROBLEMS SHIFTING INTO GEAR ESPECIALLY GETTING INTO REVERSE. I TOOK MY VEHICLE TO A LOCAL AUTO REPAIR SHOP. THE TECH WANTED TO REPLACE THE ENTIRE BOX PEDAL CLUTCH ASSEMBLY. AFTER THE PEDAL BOX WAS RECEIVED THEY NOTICED IT WASN'T THE BOX AT ALL, BUT THE FIREWALL WELDS HOLDING THE CLUTCH/BREAK PEDAL BOX WERE BROKEN ON THE FIREWALL. BECAUSE THE WELDS SNAPPED THE CLUTCH/BRAKE CAGE MOVES AND IT CAN'T LET THE CLUTCH TRAVEL FAR ENOUGH TO PROPERLY ENGAGE CAUSING THE CLUTCH TO WORK PROPERLY AND ALSO THE BREAKS CANT BE PRESSED CORRECTLY TO STOP THE CAR. THE MECHANIC TOLD US NOT TO DRIVE THE CAR FOR SAFETY SAKE TILL THE WELDS WERE REPAIRED OR WE COULD HAVE AN ACCIDENT. *TR

WAS STARTING TO HAVE PROBLEMS SHIFTING INTO GEAR ESPECIALLY GETTING INTO REVERSE. TOOK MY VEHICLE TO A SUBARU DEALERSHIP FOR A CAUSE. THE TECH WANTED TO REPLACE THE ENTIRE CLUTCH ASSEMBLY FOR 1800 BUCKS. I TOOK MY VEHICLE TO ANOTHER SHOP FOR A SECOND ANSWER, IMMEDIATELY WAS TOLD IT WAS THE FIREWALL.THE WELDS HAVE SNAPPED. BECAUSE THE WELDS HAVE SNAPPED THE CLUTCH CAN'T ENGAGE PROPERLY CAUSING ONE TO HAVE EITHER TERRIBLE SHIFTS OR POSSIBLY GRINDING OF GEARS! *TR

WHEN ATTEMPTING TO FUEL THE VEHICLE (THE TANK WAS LESS THAN ONE-QUARTER FULL), THE GAS SPLASHED BACK OUT OF THE VEHICLE ON ME AND ALLOVER THE GROUND. I TRIED SEVERAL TIMES TO FUEL, BUT THE TANK WILL NOT ACCEPT GAS. THIS ISSUE CAN CAUSE INJURIES FROM THE GASOLINE SPLASH, AND IT CAN CAUSE STRANDED DRIVERS BECAUSE THE VEHICLE CANNOT BE REFUELED. IT MUST BE INVESTIGATED. THERE ARE PLENTY OF FORUMS ONLINE WHERE PEOPLE COMPLAIN OF THE SAME ISSUE IN THEIR 2009 IMPREZAS... THERE MUST BE A KNOWN DEFECTIVE PART, BUT SUBARU IS NOT RECALLING IT? PLEASE INVESTIGATE. *TR

STARTED HAVING ISSUES GETTING THE CAR INTO GEAR. THOUGHT IT MIGHT BE THE CLUTCH BROUGHT IT INTO A SHOP TO GET THE CLUTCH DISC REPLACED. THEY DETERMINED THAT THE ISSUE WAS FROM A BROKEN WELD ON THE FIREWALL. *TR

WELDS ATTACHING THE CLUTCH PEDAL TO THE FIREWALL BROKE. THE CLUTCH IS NOW NEARLY IMPOSSIBLE TO ENGAGE AND THE BRAKE PEDAL MOVES 3/4 OF AN INCH WHEN THE CLUTCH PEDAL IS DEPRESSED. ACCORDING TO THE MECHANIC, THE CAR IS NOW AT RISK OF LOSING ABILITY TO BRAKE IF THE WELDS COMPLETELY DETACH FROM THE FIREWALL. THE WELDS HOLD THE ENTIRE PEDAL ASSEMBLY IN PLACE. *TR

2009 SUBARU IMPREZA WRX - CLUTCH PEDAL STARTED TO MALFUNCTION, BEGAN MAKING A CREAKING NOISE WHEN DEPRESSED, AND WOULDN'T SHIFT CLEANLY INTO MOST GEARS. WE ORIGINALLY THOUGHT IT WAS SOMETHING THAT NEEDED TO BE LUBRICATED OR ADJUSTED BUT THIS WAS NOT THE CASE. OVER A SHORT TIME, THIS CREAKING NOISE TURNED INTO A CLICKING NOISE WHEN THE CLUTCH WAS DEPRESSED. WE TOOK THE VEHICLE TO THE DEALERSHIP WHERE IT WAS PURCHASED 8 MONTHS PRIOR - THE DEALERSHIP SERVICE FOREMAN AND SERVICE MANAGER BOTH ADVISED US THAT SOME OF THE SPOT WELDS THAT HOLD THE PEDAL ASSEMBLY TO THE FORWARD FIREWALL HAVE BROKEN. BOTH MEN INSISTED THAT THEY HAD NEVER SEEN ANYTHING LIKE THIS BEFORE (NOT COMFORTING COMING FROM TRAINED SUBARU SERVICE SPECIALISTS) AND HAD NO INDICATION AS TO HOW IT HAD HAPPENED (OTHER THAN BEING IN A SERIOUS ACCIDENT SINCE WE PURCHASED IT, WHICH IS NOT THE CASE AND THERE...

I NOTICED A CONSISTENT SQUEAK WHEN THE CLUTCH PEDAL WAS DEPRESSED, AT ALL SPEEDS, AT ALL TIMES, EVEN WHEN THE CAR WAS OFF. I TRIED TO LUBRICATE IT, BUT THE NOISE DID NOT GO AWAY. I TOOK IT TO THE DEALER AND THEY ALSO TRIED TO LUBRICATE IT, BUT THE NOISE DID NOT GO AWAY. THE DEALER ASKED TO KEEP THE VEHICLE FOR A DAY SO THE CLUTCH COULD BE DISASSEMBLED TO DETERMINE THE CAUSE. I HAD PURCHASED A NEW CLUTCH FROM THE DEALER FOR $1600 IN SEPTEMBER, 2012 WHICH WAS STILL UNDER WARRANTY. THE DEALER DETERMINED THE CAUSE WAS BROKEN WELDS BETWEEN THE CLUTCH ASSEMBLY AND FIREWALL. THE DEALER AND I BOTH CALLED SUBARU OF AMERICA TO FIND A RESOLUTION. MY CASE NUMBER WAS SR #:[XXX]. I TOLD THE SUBARU REP THAT THIS WAS A COMMON AND WIDESPREAD PROBLEM WITH THIS MODEL OF SUBARU BASED ON MY OWN INTERNET...

MY 2009 SUBARU WRX HAS A BROKEN CLUTCH PEDAL BRACKET, THIS HAS LED TO EXTREMELY HARD SHIFTING. I TOOK MY CAR TO A CLUTCH SHOP AND THEY DID NOT WANT TO TOUCH IT, THEY SUGGESTED I TAKE IT TO THE DEALER. THEY CALLED THE DEALER FOR ME AND ASKED IF THERE WERE ANY RECALLS, TO WHICH THE DEALER SAID NO. I BELIEVE SUBARU IS BEING DISHONEST AS I HAVE FOUND MANY CONSUMERS ON ONLINE FORUMS EXPERIENCING THE SAME PROBLEM I AM. *TR

THE CLUTCH PEDAL ON MY 2009 WRX MAKES A LOUD CREAKING NOISE EVERY TIME IT'S DEPRESSED. WHEN I INVESTIGATED THE NOISE, I NOTICED THAT THE ENTIRE CLUTCH PEDAL BRACKET ASSEMBLY (ATTACHED TO THE FORWARD FIREWALL) SHIFTS APPROX 1/4 INCH EVERY TIME THE CLUTCH PEDAL IS DEPRESSED. I FOUND THAT THE THREE SPOT WELDS SECURING THE CLUTCH PEDAL BRACKET TO THE FORWARD FIREWALL WERE BROKEN. FROM THE OUTSIDE OF THE FIREWALL, JUST UNDER THE WINDSHIELD WIPERS, I SAW THE SPOT WELDS PULLING AWAY FROM THE FIREWALL EVERY TIME THE CLUTCH PEDAL WAS DEPRESSED. THIS ALLOWS THE ENTIRE CLUTCH PEDAL BRACKET ASSEMBLY TO MOVE, CAUSING THE CREAKING NOISE. IF THE BRACKET COMPLETELY SEPARATES FROM THE FIREWALL, THE CLUTCH MAY BECOME COMPLETELY INOPERATIVE - ESPECIALLY DANGEROUS WHILE DRIVING. REFERENCE LINKS: HTTP://CARPROBLEMZOO.COM/SUBARU/IMPR...S-PROBLEMS.PHP HTTP://WWW.FAQS.ORG/CAR/SUBARU-IMPRE...POWER-TRAIN/#B HTTP://WWW.WRXFORUMS.COM/FORUMS/84-D...ON-NEEDED.HTML HTTP://WWW.WRXFORUMS.COM/FORUMS/37-C...INKAGE-45.HTML HTTP://WWW.WRXFORUMS.COM/FORUMS/84-D...EWALL-FIX.HTML HTTP://WWW.WRXFORUMS.COM/FORUMS/37-C...BLY-ISSUE.HTML HTTP://WWW.WRXFORUMS.COM/FORUMS/84-D...S-STORY-2.HTML HTTP://WWW.WRXFORUMS.COM/FORUMS/84-D...L-PROBLEM.HTML HTTP://WWW.WRXFORUMS.COM/FORUMS/84-D...OLT-STYLE.HTML HTTP://FORUMS.NASIOC.COM/FORUMS/SHOW....PHP?T=2128617 HTTP://FORUMS.NASIOC.COM/FORUMS/SHOW....PHP?T=2184210 HTTP://FORUMS.NASIOC.COM/FORUMS/SHOW....PHP?T=2305937. *TR

I HAVE A HORRIBLE SQUEAK COMING FROM MY CLUTCH PEDAL. FOR SEVERAL MONTHS NOW, WHEN I DEPRESS AND RELEASE THE CLUTCH A LOUD SQUEAK SQUEAKING NOISE IS PRODUCED. THIS WEEK THE CLUTCH PEDAL BEGAN TO SQUEAK CONSTANTLY WHILE DRIVING AS IF WERE LOOSE. I HAVE TO BRACE THE CLUTCH PEDAL WITH MY LEFT FOOT IN ORDER TO STOP THE NOISE WHICH IS CONSTANT AT MOST SPEEDS AND ESPECIALLY OVER BUMPS. A CLOSER LOOK REVEALED THAT IT APPEARS THE WELDS ON THE CLUTCH PEDAL ARE BEGINNING TO FAIL WHERE IT ATTACHES TO THE VEHICLE'S FIREWALL. THIS WOULD EVENTUALLY LEAD TO THE PEDAL BREAKING OFF DURING DRIVING AND THE POTENTIAL OF A CRASH. *TR

THE BRACKET THAT ATTACHES THE CLUTCH AND BRAKE PEDALS TO THE INSIDE FIREWALL HAS SEPARATED FROM ITS SPOT WELDS AND IS CAUSING A LOUD CREAKING NOISE, AS WELL AS DIFFICULTY WITH SHIFTING GEARS, AND DECREASED BRAKING ABILITY. VERY DANGEROUS SITUATION AS IT AFFECTS YOUR ABILITY TO CONTROL THE VEHICLE PROPERLY. *TR

THE CLUTCH PEDAL MAKES A LOUD CREAKING NOISE EVERY TIME IT'S DEPRESSED. WHEN I INVESTIGATED THE NOISE, I FOUND THAT THE ENTIRE CLUTCH PEDAL BRACKET ASSEMBLY (ATTACHED TO THE FORWARD FIREWALL) SHIFTS APPROX 1/4 INCH WHEN THE CLUTCH PEDAL IS PRESSED. I NOTICED THAT THE THREE SPOT WELDS SECURING THE CLUTCH PEDAL BRACKET TO THE FORWARD FIREWALL ARE BROKEN. FROM THE OUTSIDE OF THE FIREWALL, JUST UNDER THE WINDSHIELD WIPERS, I SAW THE SPOT WELDS PULLING AWAY FROM THE FIREWALL EVER TIME THE CLUTCH PEDAL WAS DEPRESSED. THIS ALLOWS THE ENTIRE CLUTCH PEDAL BRACKET ASSEMBLY TO MOVE, CAUSING THE CREAKING NOISE. IF THE BRACKET COMPLETELY SEPARATES FROM THE FIREWALL, THE CLUTCH MAY BECOME COMPLETELY INOPERATIVE - ESPECIALLY DANGEROUS WHILE DRIVING. *TR

MY CLUTCH STARTED SQUEAKING WHILE DRIVING ON THE HIGHWAY. WHEN DEPRESSING THE CLUTCH, THE BRAKE PEDAL MOVES TOWARD THE DRIVERS SIDE AND DOWN. UPON FURTHER INSPECTION, I NOTICED THE SPOT WELDS THAT HOLD THE CLUTCH AND BRAKE ASSEMBLY TO CAR WERE BROKEN AND STARTING TO SEPARATE FROM THE FIREWALL. EVENTUALLY, THE WELDS WILL FAIL AND COMPLETELY REMOVE THE ASSEMBLY FROM THE FIREWALL. THUS, CLUTCH AND BRAKING ABILITIES WILL BE GONE AND CAUSE AN ACCIDENT. *TR

THE SPOT WELDS HOLDING THE CLUTCH, BRAKE AND GAS PEDAL ASSEMBLY TO THE FIREWALL FAILED ENTIRELY, ALLOWING THE PEDAL ASSEMBLY TO BECOME DETACHED FROM THE VEHICLE AND MOVE TOWARD THE FIREWALL WITH ANY PEDAL ACTION. I WAS NO LONGER ABLE TO DISENGAGE THE CLUTCH AND THE BRAKES DELIVERED INCONSISTENT PERFORMANCE. *TR

MY SUBARU'S CLUTCH PEDAL IS BREAKING THE SPOT WELDS. PRETTY SOON THE CLUTCH PEDAL WILL FALL OFF. SUBARU WONT REPLACE IT ALTHOUGH IT IS CLEARLY A MANUFACTURER DEFECT BECAUSE THE CAR IS OUT OF WARRANTY. GOD FORBID I AM COMING OFF THE HIGHWAY AND THIS CLUTCH PEDAL FINISHES FALLING OFF AND I CAN NOT DISENGAGE THE CAR OUT OF GEAR. THIS IS NOW HAPPENING TO THE 2008 AND 2009 WRX BUT NOT THE STI BECAUSE THEY HAVE A PULL TYPE CLUTCH AND THE PEDAL ENGAGES DIFFERENTLY. *TR

TOTAL ENGINE FAILURE DUE TO ROD KNOCK / SPUN BEARING DUE TO MANUFACTURE TO INCORRECT TOLERANCES. *TR