2002 SUBARU IMPREZA Fuelpropulsion System Problems

STRONG SMELL OF FUEL UPON START-UP WHEN IN SUB-FREEZING CONDITIONS. IT HAS OCCURRED TWICE IN 2019, WHICH ARE THE ONLY RECENT TIMES IT HAS BEEN EXPOSED TO THOSE CONDITIONS. THE FIRST OCCURRENCE WAS IN FEBRUARY, 2019. THE SECOND WAS IN NOVEMBER, 2019. RECALL 09V468000 APPLIES TO MY MODEL VEHICLE, BUT ONLY IN CERTAIN STATES. THE RECALL, THEREFORE, DOES NOT APPLY TO MY VIN, ALTHOUGH THE DESCRIPTION OF THE RECALL NOTICE APPEARS TO MATCH THE SYMPTOMS OF MY CAR. AFTER SPEAKING WITH SUBARU, THEY INDICATED THEY ARE NOT WILLING TO DO ANYTHING ABOUT IT BECAUSE MY VIN IS NOT COVERED IN THE RECALL.

IN COLD TEMPERATURES THE FUEL LEAKS FROM RUBBER FUEL LINES ONTO THE FUEL RAIL AND MANIFOLD RESULTING IN A VERY STRONG FUEL ODOR COMING INTO THE VEHICLES CABIN. WHEN AT A STOP WITH THE VEHICLE IDILING THE SMELL IS OVERWHELMING. NOT NEARLY AS BAD WHILE DRIVING.

VERY STRONG SMELL OF RAW GASOLINE IN THE ENGINE COMPARTMENT AND CABIN THAT WOULD BE CONSISTENT WITH SPILLED FUEL BUT THERE WASN'T ANY SPILLED IN EITHER LOCATION. THE SMELL IS STRONGEST WHILE DRIVING WITH HEAT OR A/C ON TO THE POINT THAT WINDOWS HAD TO BE OPENED BECAUSE THE FUMES WERE IRRITATING THE EYES. AFTER SPEAKING WITH A MECHANIC, WAS TOLD THAT A COMMON PROBLEM IS THE RUBBER FUEL LINES THAT RUN ALONG THE TOP OF THE ENGINE DRY ROT AND BREAK CAUSING RAW GASOLINE TO SPILL ONTO THE HOT ENGINE AND TURBOCHARGER POTENTIALLY CAUSING A FIRE. THIS HAS BEEN AN ISSUE THE ENTIRE TIME I HAVE OWNED THE VEHICLE.

TL* THE CONTACT OWNS A 2002 SUBARU IMPREZA. THE CONTACT STATED THAT THE VEHICLE EMITTED AN ABNORMAL FUEL ODOR WITHOUT WARNING. SUBARU OF WINCHESTER (3019 VALLEY AVE, WINCHESTER, VA) DIAGNOSED THAT THE FUEL LINE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT A MANAGER WOULD CALL THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 151,000.

I WAS DENIED THE FUEL LINE RECALL DUE TO I LIVE IN OHIO AND OHIO IS NOT ON THE LIST OF "COLD STATES." I AM FORCED TO BREATH GASOLINE FUMES AND MY ENGINE SMOKES BURNING OFF THOSE GASOLINE FUMES. JUST WAITING FOR THE CAR TO BLOW UP. THANK YOU, SUBARU *TR

FOR THE LAST 5 YEARS NOW, WHEN THE CAR IS COLD, SITTING IN THE GARAGE, THEN YOU START IT UP AND YOUR VENTS ARE OPEN TO THE OUTSIDE AIR, THE INTERIOR SMELLS OF GASOLINE. I LIVE IN HAWAII AND THE RECALL DOES NOT COVER OUR STATE. THE ONLY WAY TO NOT LET THE SMELL IN THE INSIDE COMPARTMENT IS TO CLOSE THE VENTS.

TL* THE CONTACT OWNS A 2002 SUBARU IMPREZA. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE FRONT PASSENGER SIDE LOWER CONTROL ARM SUDDENLY FAILED CAUSING THE PASSENGER SIDE OF THE VEHICLE TO LOWER. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE LOWER CONTROL ARM HAD FRACTURED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 11V464000 (SUSPENSION) BUT THE FAILURE PERSISTED. THE CONTACT ALSO INDICATED THAT THERE WAS A FUEL ODOR PRESENT WHILE OPERATING THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OF REPAIRED. THE FAILURE MILEAGE WAS 135,000.

WHEN THE TEMPERATURE DROPS 35 DEGREASE AND BELOW THE FUEL LINE TENDS TO LEAK FUEL/VAPOR AND THE SMELL INSIDE OF THE VEHICLE IS UNBEARABLE, AND I'M SURE THAT IT'S NOT SAFE NOR ENVIRONMENTALLY FRIENDLY ETHER.