2020 SUBARU FORESTER Forward Collision Avoidance Automatic Emergency Braking Problems

While driving on public roads, all dash warning lights illuminated simultaneously. The instrument cluster displayed “EyeSight OFF.” At the same time, the electronic parking brake engaged / the vehicle would not accelerate and required me to stop and shift to Park. The only way to restore drivability was to turn the vehicle off and restart. This has occurred intermittently, including in traffic, creating a serious safety hazard for myself and surrounding drivers.

I, the owner of a 2020 Subaru Forester am writing to you in regards to an issue with my vehicle’s Eyesight program. Over the past month, there have been several instances where the Eyesight program fails and caused the vehicle to suddenly stop without warning. This prevents me from safely moving the vehicle to the side of the road as the car stops. In other words, the car abruptly stops on the spot. This creates an immediate danger to life and health to myself and to other motorists. This issue must be addressed immediately and the necessary steps taken to ensure the safety the driver, passengers and other motorists on the road. Thank you for understanding.

In April 2022 after owning the car for 4 weeks the Eyesight went out. I was told it was due to the thermal control module. That was replaced. I’m n June 2023 the AC went out. They said it was the blower motor. That was replaced. In September 2023 the AC went out again. At that point they found the cause was actually a fully melted fuse box and fuses. They replaced the fusebox and the entire AC system. I have had 3 batteries in the vehicle since March 2022. In December 2024 they found that my car needed an update and the update friend the transmission controls module. Then the starter went out at the same time. After that was fixed a week later all the lights in my dash came on and there were no safety features running in the vehicle. I reach out to Subaru and I...

Eyesight pre-collision braking feature and pre-collision throttle management feature malfunctioned and caused the 2020 Forester to accelerate unexpectedly and lurch forward while I was manually braking and slowing to come to a complete stop behind two other vehicles stopped at a steady red light. See class action lawsuit Weston, et al. v. Subaru of America, Inc., et al. In US District Court Case No. [XXX] which alleges that the vehicle contains certain defects that caused sudden and unintended acceleration without driver input; acceleration while manually braking; and that these defects created a safety risk, because they severely affected the driver's ability to control the car's speed, acceleration, and deceleration, and increase the risk of a collision, which did in fact occur. The defective car was completely totaled and towed to a salvage yard by the police and the insurance company. Defect malfunction caused a collision which resulted in property damage...

I was driving to work and many of my warning lights suddenly came on. This includes my check engine light, my lane assist light, my auto collision braking, my eye sight disabled and my cool engine light keeps going on and off. My cabin heating also isn’t working. There is no reason for this happening other than my thermo control valve failing.

While driving temperature light, check engine light, all ADAS lights came on as inoperable (cameras, warning, ABS, BSD/RCTA), no heat (including defrost) available to defrost or for cabin. Appointment 3/13 replaced thermo control valve assembly , coolant bypass valve, intake gaskets, fuel line, coolant, total charges $2070. Luckily had extended warranty I bought, that I had to make a claim on. Dangerous to drive (no camera based safety features available, no defrost for the snowy weather, no emergency braking or other collision safety features on, this affected the entire 'eyesight' system). The engine also had no thermo control regulation during this time, affecting not just then, but possible future performance and early aging due to disregulation.

On Sunday, [XXX] we were traveling in our 2020 Subaru Forester on a trip from Minnesota to Florida for a vacation. Not long into cross country trip we found ourselves stranded on the side of the highway uncertain about the ability of our vehicle to continue to due to a defective Thermo Control Valve failure. About 200 miles into our trip, while driving at highway speeds south of Rochester, MN the dashboard lit up. The check engine light was on, and other safety features were lit up on the dash as disabled (Eye-sight technology, lane assist, automatic vehicle collision braking). The heat would not work after this incident. We checked the owners manual, and then drove to an Auto-parts store to have a scan done to determine the error code. The code "P26A3 - Engine coolant bypass valve A Range/Performance" was indicated. In checking online we discovered that a Thermo...

Started engine after parking and check engine light came on, eyesight disabled, and flashing “s”. Stopped driving and took vehicle to dealer. Diagnosed as thermo control unit. Told they didn’t have a loaner and was safe to drive for a few days. Has no heat and engine would not warm up. No safety systems. Retained 3 days later to dealer when loaner was available. Repaired under powertrain warranty.

The contact owns a 2020 Subaru Forester. The contact stated while driving 75 MPH, the Forward Collision Avoidance Automatic Emergency Braking system activated and applied the brakes. The contact was able to pull to the shoulder of the roadway, where he smelled a burnt smell in the interior of the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine and brake warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the throttle body. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 35,600.

While accelerating to merge in the freeway the Thermo Control Valve malfunctioned, causing check engine light to come on which turned off all the safety features (lane assist off, precollision off, RAB and eyesight off) of my Subaru 2020 Forester Sport. I’ve researched the internet and shows it is a common issue. I brought it to a subaru dealership and was told it is not safe to drive the vehicle. Since I just passed 60k powertrain warranty (around 62k), it is not covered and had to pay over $3,000.

Check engine light came on, low temp light stays on, Eyesight disabled, lane departure, emergency breaking, etc have all been disabled due to the issue. I took it to the local autobody shop and they found code p0128 | Coolant Thermostat Issue. This has caused all safety features to become disabled as mentioned above. I was told by the local shop that I need to go to the dealership. I have not brought it to the dealership yet however, after looking online I found that this is a common issue with this make and model vehicle however, nothing has been done by Subaru to recall the component. I am going to bring the car to a dealership however, I'm upset that Subaru hasn't acted on the information that they have a faulty component in this vehicle. I am very concerned with cost of repairs since I am being forced to...

While driving, most of the dash errors lights lit up- alerting me that the Eyesight Warning, RAB ( Reverse Auto Braking) and other safety functions were disabled. The Check Engine light was on and a flashing S next to it. Cold Engine light was illuminated as well. Dealer diagnosed with a faulty Thermal Control Valve, which somehow disabled all safety features. This is a common failure of Subarus and a recall is needed.

While I was traveling I stopped at a rest area and when I restarted my car, my panel lit up like a Christmas tree. All my safety assist systems were disabled and my check engine light came on. When I got home I had my mechanic run the codes and it came back to the thermo control valve. This happened on 8-29-2023. I researched the problem and Subaru put out a service bulletin in February 2022 but never notified me. My car is out of warranty now and am forced to drive without my safety systems because, 1- they don’t carry the part in stock and 2- the cost to repair is over $1400.00. Subaru was aware of the problem but kept it quiet. I feel this is a scam and Subaru should recall this part. I was warned that my car could die at any time. I bought it...

Error code (P26A3?)for - Engine Coolant Bypass Valve. Causes the "Check Engine" light to come on and automatically disables ALL of the safety and collision mitigation systems. The Engine Coolant Bypass Valve failure is common and a known issue and Subaru has already updated the part on newer vehicle models. The common failure of the coolant bypass valve should not be disabling the safety features and the collision avoidance systems.

I was driving on a paved two lane rural route and hit a small bump in the road. Immediately, my check engine light came on and all the safety features turned off. Control panel showed multiple safety features off and the Sport mode indicator light blinking. My car only has 17K miles on it and I have had it just over a month. I was able to drive it safely home and when I called the dealership the next morning I was told I could continue to drive it until the service appointment six days later. When I got home, my husband checked it with his CEL reader and got the code for the temperature control valve (an issue known by Subaru). This was confirmed by the dealership and I was told after having driven it for several days that it should not be driven. The repair is being covered...

Was slowly pulling into a parking spot when the "Automatic Emergency Braking" and "Collision Avoidance Systems" engaged. The systems said that there was an "object detected" and slammed the car to a stop. Shut off the car and got out, there was no object. Had to disable the AEB system to pull into the parking space. Vehicle and component have not been inspected for this issue. Vehicle received regular maintenance at a shop (oil change) about 1 month ago and new tires about 1 week ago. Problem has not been confirmed.

Thermo control valve stays open. Needs replacement. Automatic brakes have gone on with no car in front of vehicle. Unsafe.

When I was driving this car one night, every dash light was suddenly activated and remained on -- and as a result all safety features were deactivated. When I was able to do so, I touched the battery cables together to reboot the system. I had to do this 3 times over the course of 4 days. Realizing the problem was chronic, I took the car to the dealership (a 2 hour drive), where a service tech explained the problem 'was caused by a low battery.' This car is only 2 years old. A new car battery should last longer than 2 years. It thus seems to me the battery was defective or the car improperly drained it somehow. More important, there is no warning that a 'low battery' -- one which can easily start a car -- could still deactivate safety features while driving.

This is about a problem of which your agency is already aware. Subaru of America has been aware of a defective Thermo Control Valve for almost a year (Part 21319AA010). The part was redesigned since the initial part was subject to extreme corrosion. The redesigned part has the same part number as the original part. Subaru did not do any recall but instead waited for the parts to fail. When it fails on a car with safety features (called "eyesight"), each and every safety feature is permanently disabled until the redesigned part is installed. In addition, the engine runs too cool and there is little or no cabin heat. My car has been on the lot of my local dealership for 2 months with no end in sight. My car is covered by the original warranty and an extended warranty. Managers at the dealership have told me that they have...

Automatic braking system failed and led to a front end collision immediately a fire broke out under the hood and accelerated into the car with in minutes using a tire iron the passenger door was forced opened Air bags deployed (3) and seat belt held

Driver gets choked while drinking a cold beverage, gets disoriented and loses consciousness momentarily causing the vehicle to veer off the street and strike a tree with extensive front end damage. Airbags did not deploy at all. Driver has injuries from the crash, such as possible fractured wrist, contusions and much pain in the neck, chest and back areas. She was transported by EMS to the hospital. Insurance was notified and an adjuster has already sent a repair appraisal and cut a check for the estimated cost of repairs. The driver does not feel comfortable about the having the car repaired with potentially faulty airbags. We have photos of the car. We have stated our concerns about this to the insurance company and the vehicle manufacturer. They have opened a file with our concerns and we are waiting to learn further from the insurance provider and the car maker. My...

I WAS DRIVING UP AN EMPTY SUBURBAN ROAD AT 25 MPH WHEN THE BRAKES SUDDENLY WENT OFF, CAUSING THE CAR TO SKID TO A STOP. THE DASHBOARD SCREEN SAID THE PRE-COLLISION EMERGENCY BRAKING SYSTEM WAS ACTIVATED. THERE WAS NOTHING IN THE ROAD AND NO REASON FOR THE CAR TO STOP SUDDENLY. THANK GOD I WASN'T ON THE HIGHWAY - THIS IS EXTREMELY DANGEROUS.

2/17/2021 - HONDA ACCORD GOING NORTH ON LYNCHBURG TURNPIKE RAN A STOPLIGHT (GOING ABOUT 30 IN A 25 MPG ZONE) TRYING TO TURN WEST ONTO EAST MAIN ST. IN SALEM, VA ... BOUNCED OPPOSITE CURB, CUT WEST AND SWERVED (OVERSTEER) AND CAME HEAD ON INTO MY STATIONARY 2020 FORESTER. OUR LIGHT HAD JUST TURNED GREEN AND WE WERE ABOUT TO MOVE FORWARD WHEN THE HONDA CAME OUT INTO THE INTERSECTION. MY WIFE WAS DRIVING AND I WAS A PASSENGER. I WAS TAKEN TO ER AND SEEN BY SEVERAL DOCTORS AND AM UNDERGOING PT FOR THE NEXT 5 WEEKS.

DRIVING ON STRAIGHT MULTI-LANE HIGHWAY ~2:00 PM IN THE DAYTIME AT ~55 MPH; CLEAR, DRY WEATHER, DRY ROAD. NO VEHICLES OR OBSTRUCTIONS OF ANY KIND IN FRONT OF VEHICLE, FORTUNATELY NO VEHICLES BEHIND. AUTOMATIC EMERGENCY BRAKING SYSTEM TRIGGERED FULLY WITHOUT ANY WARNING, BRINGING CAR TO SUDDEN STOP IN HIGH SPEED TRAVEL LANE; COULD HAVE CAUSED SEVERE REAR END COLLISION HAD THERE BEEN ANYONE BEHIND. ENGINE CONTINUED TO RUN, VEHICLE WOULD NOT MOVE UNTIL AFTER SHIFTING INTO PARK AND BACK INTO DRIVE. SUBARU COULD FIND NO REASON FOR ERRONEOUS SUDDEN STOP FUNCTION.

12/16/2020 DRIVING. 3:30 PM DAYTIME. CLEAR WEATHER. DIVIDED HIGHWAY. APPROX 50 MPH. NO VEHICLE IN FRONT OF CAR FOR AT LEAST A QUARTER MILE. CAR INITIATED SUDDEN STOP MODE NEARLY CAUSING A SEVERE REAR END COLLISION (AVOIDED BY APPROACHING DRIVER GOING INTO MEDIAN)

I WAS DRIVING HOME IT WAS DARK AND RAINING. SOMETHING HIT MY WINDSHIELD WHEN I WOKE UP ON SATURDAY I SAW A BIG CRACK IN THE WINDSHIELD