2001 SAAB 9-3 Electrical Systemignitionmodule Problems

BROUGHT MY 2001 SAAB 9-3 FOR CAMPAIGN RECALL 05V399000 IDM TO DIRITO BROTHERS SAAB OF WALNUT CREEK, CALIFORNIA. DEALER STATED NOT REQUIRED TO CHANGE THE IDM. IF MY IDM FAILS AT A LATER DATE, I COULD BE SUSCEPTIBLE TO INJURY OR DEATH. NEED TO KNOW IF DEALER IS REQUIRED TO CHANGE IDM. *TR

TL*THE CONTACT OWNS A 2001 SAAB 9-3. WHILE DRIVING 70 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT DROVE TO THE DEALER AND THEY STATED THAT THE IGNITION CASSETTE FAILED. SHE THEN FOUND A RECALL ON HER VEHICLE FOR THE SAME FAILURE HER VEHICLE WAS EXPERIENCING; HOWEVER, THE DEALER STATED THAT HER VIN WAS NOT INCLUDED. THE CONTACT BELIEVES THAT HER VEHICLE SHOULD BE INCLUDED IN THE RECALL BECAUSE IT IS EXPERIENCING THE SAME FAILURE. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 82,347. UPDATED 05/20/08. *LJ THE DOOR HANDLE WAS REPLACED. UPDATED 05/20/08

TL* - THE CONTACT OWNS A 2001 SAAB 93. THE CONTACT STATED THAT THERE WAS SAFETY RECALL ON THE IGNITION DISCHARGE MODULE. THE FIRST TIME HE TOOK THE VEHICLE TO THE DEALER TO HAVE THE SAFETY RECALL REPAIR WORK DONE WAS 04/17/2006. THE CONTACT DROVE BACK HOME AT 60 MPH FOR APPROXIMATELY 40 MILES, AND DURING THAT TIME AND FOR THE FIRST TIME, THE ENGINE LIGHT TURNED ON. THE CONTACT WENT BACK A SECOND TIME ON 05/11/2006 BECAUSE THE ENGINE LIGHT STAYED ON AND, THERE WERE GAS FUMES IN THE VEHICLE. THE CONTACT WENT BACK TO THE DEALER ON 06/08/2006 BECAUSE THERE WERE OVERWHELMING GAS FUMES IN THE VEHICLE. CURRENTLY THE ENGINE ON LIGHT STAYED ON CONSISTENTLY. THE CONTACT WAS TOLD THAT HE WOULD BE CHARGED FOR REPAIRS. THE FAILURE MILEAGE WAS 15,949 AND THE CURRENT MILEAGE WAS 17,900. *AK THE CONSUMER PROVIDED THE INVOICES FOR REPAIRS AND DOCUMENTS FOR...

2001 9-3 ENGINE LIGHT ILLUMINATED DUE TO A CRACKED CYLINDER. *TS WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP, SHE WAS TOLD THE SERIAL NUMBER ON THE MODULE WAS NOT THE ONE THAT WOULD BE REPLACED. A FEW MONTHS HAD PASSED AND THE SERVICE TECHNICIAN DETERMINED THAT THE PROBLEM WAS FROM THE RECALLED PART WHICH HAD A NOTICEABLE CRACK. WHEN THE CONSUMER CONTACTED THE DEALERSHIP AGAIN, SHE WAS TOLD THAT THE MODULE MAY HAVE SHOWN PROBLEMS IN THE PREVIOUS INSPECTION, BUT THE MODULE WAS NOT COVERED BY THE RECALL BASED ON THE SERIAL NUMBER.*JB

DT*: THE CONTACT STATED THE ENGINE STALLED MULTIPLE TIMES. THE LAST TIME THE ENGINE STALLED WHILE TRAVELING AT A HIGHWAY SPEED OF 65-70 MPH. THE VEHICLE COASTED OFF TO THE SIDE OF THE ROAD WITHOUT INCIDENT. THE VEHICLE WAS TOWED TO THE DEALERSHIP. THERE WERE NO PRIOR WARNING. THE VEHICLE HAS BEEN TO TWO DIFFERENT DEALERSHIPS. NEITHER COULD DUPLICATE THE PROBLEM. THERE IS AN NHTSA RECALL, # 05V399000 REGARDING THE ELECTRICAL SYSTEM: IGNITION: MODULE. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

I WAS TRAVELING IN A ROTARY THAT IS AN ON-RAMP TO 128 IN READING, MA. AND WAS ABOUT TO ACCELERATE UP THE ON-RAMP WHEN THE CAR DIED, BATTERY LIGHT CAME ON, POWER STEERING FAILED. THIS WAS DURING RUSH HOUR AND THERE WAS NO SAFE PLACE TO PULL OVER, LUCKILY A STATE TROOPER PULLED UP WITHIN ABOUT 2 MINUTES AND WAS ABLE TO PUSH THE CAR TO A SAFER LOCATION. ROADSIDE ASSISTANCE WAS CALLED, CAR WAS BROUGHT TO THE DEALER AND DIAGNOSED WITH A DIRECT IGNITION CASSETTE (DIC) FAILURE. *JB

I WAS DRIVING TO WORK ON THE HIGHWAY FROM SYRACUSE TO CORTLAND TO NEW YORK WHEN ABOUT QUARTER WAY THEIR MY CAR SHUT DOWN RIGHT IN THE MIDDLE OF THE HIGHWAY AND I WAS ALMOST INVOLVED IN A TRAFFIC ACCIDENT DUE TO THIS FAILURE. THE FAILURE WAS A BAD DIRECT IGNITION CASSETTE WHICH CAUSED MY CAR TO SHUT DOWN IMMEDIATELY. APPARENTLY THE SAME PART HAS BEEN USED AND FAILING FOR ABOUT 20 YEARS TO THIS DATE. WHEN I BROUGHT THE CAR IN FOR THE DIC REPLACEMENT IT COST ME $500.00 FOR 5 SEC. OF TIME. WHEN I TOLD THE MECHANICS ABOUT THE PROBLEM THEY LAUGHED AND SAID THEY NEW WHAT IT WAS AND THAT IT HAD BEEN FAILING FOR YEARS AND THEY MAKE GOOD MONEY OFF OF THE PART AND THIS IS THE SAME THING I AM HEARING FROM OTHER SAAB 9-3 DRIVERS. I THEN PROCEEDED TO RESPOND TO SAAB...

DIRECT IGNITION CASSETTE FAILED WHILE TRAVELING APPROXIMATELY 45 MPH. CAR LOST POWER, INCLUDING ELECTRICITY AND POWER STEERING. WAS ABLE TO RESTART CAR, BUT SHUT DOWN AGAIN ABOUT 10 MINUTES LATER. *AK

COMPLETE LOSS OF ENGINE POWER WHILE TRAVELING AT 55 MPH ON LIMITED ACCESS HIGHWAY IN LEFT LANE. LOSS OF POWER WAS DUE TO DIRECT IGNITION CASSETTE FAILURE (ELECTRICAL FAILURE IN ENGINE IGNITION SYSTEM). *NM