2002 NISSAN PATHFINDER Fuelpropulsion System Problems

My complaint relates to Campaign Number 07V435000 We are the original and only owner of this vehicle. While driving the vehicle I started to notice a fuel smell, after several attempts to locate the source, one day I added fuel, I noticed a small puddle in my driveway the following morning. I removed the wheel and the fender well cover to find the fuel filler neck had rotted through and fuel had wet both the tire and the brakes. The above campaign number has a recall the ends in the prior manufacturing year even though the part in question was used by the manufacturer through the 2004 model year. I repaired the vehicle and am now dealing with a constant check engine light due to a manufacturing defect that creates a large vacuum leak at the fuel cap. The part arrived with a notice that the leak is common and...

FUEL FILLER NECK CORROSION RESULTS IN LEAK IN FUEL, EVAPORATIVE, AND EMISSIONS SYSTEMS. FUEL WILL LEAK AFTER FILLING GAS TANK, CREATING SERIOUS FIRE HAZARD WHILE DRIVING. RECALL WAS ISSUED FOR 1997-2001 PATHFINDERS, BUT SHOULD LIKELY BE EXPANDED TO INCLUDE PATHFINDERS THROUGH 2004, WHICH USE SAME DESIGN.

TL* THE CONTACT OWNS A 2002 NISSAN PATHFINDER. THE CONTACT NOTICED A FUEL ODOR NEAR THE FUEL TANK, BUT DID NOT OBSERVE ANY FUEL LEAKING FROM THE VEHICLE. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 127,700.

THE FIRST TIME WHILE DRIVING THE PATHFINDER IN REGULAR DRIVING CONDITIONS, THE ENGINE STALLED AT APPROXIMATELY 30 MPH. TO RESTART THE ENGINE I HAD TO PUT THE TRANSMISSION IN NEUTRAL AND TURN THE KEY ALL THE WAY OFF AND THEN RESTART THE VEHICLE.THE SECOND TIME THIS HAPPENED I WAS DRIVING AGAIN THE SAME DAY, CRUISING ALONG AT ABOUT 50 MPH IN TRAFFIC, AND THE ENGINE DIED AGAIN WITH NO WARNING. THE INSTRUMENT CLUSTER SHOWED ALL THE TYPICAL "DUMMY LIGHTS" AFTER THE ENGINE FAILED THE FIRST TWO TIMES. WHEN WE PARKED THE PATHFINDER WE COULD SMELL GAS AT THE REAR PASSENGER DOOR ON THE DRIVERS SIDE. WE TOOK THE PATHFINDER TO THE SHOP FOR REPAIR. FUEL SMELL WAS CORRECTED BY INSTALLING A FUEL PUMP SEAL AND THE FUEL PUMP SYSTEM WAS RESEATED, AND REINSTALLED AFTER AN INCORRECT INSTALLATION BY A PREVIOUS MECHANIC. AFTER RECEIVING THE PATHFINDER BACK FRO OUR SHOP, THE...

TL* THE CONTACT OWNS A 2002 NISSAN PATHFINDER. THE CONTACT STATED THAT AFTER REFUELING, FUEL WOULD SPEW BACK OUT OF THE FUEL FILLER TUBE DUE TO CORROSION. THE CONTACT WAS MADE AWARE OF RECALL NHTSA CAMPAIGN NUMBER: 07V435000 (FUEL SYSTEM, GASOLINE). THE DEALER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2002 NISSAN PATHFINDER.THE CONTACT STATED THAT THERE WAS A FUEL LEAK UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL FILLER LINE WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 181,000 AND THE CURRENT MILEAGE WAS 181,500.

TL* THE CONTACT OWNS A 2002 NISSAN PATHFINDER. THE CONTACT STATED WHILE REFUELING THE VEHICLE, FUEL STARTED TO LEAK. AFTER INSPECTING THE VEHICLE HE NOTICED THAT THE FILLER NECK WAS COMPLETELY CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 152,000.

I RECENTLY BROUGHT UP TO THE ATTENTION OF NISSAN A PROBLEM I'VE BEEN EXPERIENCING WITH MY CAR. THE "CHECK ENGINE SERVICE" LIGHT IS ON AND IT JUST DOESN'T TURN OFF. LET ME EXPLAIN. WHEN I FIRST NOTICE THE PROBLEM, AROUND 6 MONTHS AGO, I TOOK THE CAR TO A DEALER. HOWEVER, JUST TO HOOK UP THE CAR TO THE COMPUTER OF THE DEALERSHIP IS OVER $100. NOT TO GET FIXED, JUST TO HOOK UP. I THINK THAT'S OUTRAGEOUS. SO I TOOK IT TO 2 DIFFERENT PLACES, A LOCAL MECHANIC AND AUTOZONE, BOTH EQUIPPED WITH COMPUTER HOOK UPS, CAPABLE OF "READING" NISSAN CODES. AT FIRST, THE CODE INDICATED A PROBLEM WITH THE "R" VALVE TIMING SOLENOID, WHICH I PROCEEDED TO CHANGE. HOWEVER, THE LIGHT CONTINUED ON. I TOOK IT BACK, AND NOW IT WAS THE "L" SIDE, WHICH I ALSO CHANGED. THESE TWO CHANGES COST ME $500. BUT THE LIGHT CONTINUES...