2019 MERCEDES-BENZ SPRINTER 3500 Engine Problems

The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA Campaign Number: 22V796000 (POWER TRAIN), and the vehicle was taken to a local dealer, where the vehicle was repaired under recall, and the contact was informed that the knock sensor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 98,000.

At high elevations, at some times soon after a cold start the throttle becomes completely unresponsive. This is not a low power issue due to altitude--even putting the throttle pedal to the floor, the RPMs remain at idle and do not move at all. After I power down and restart, it worked briefly and then again became unresponsive. Once the engine is warm, the problem has not appeared. This put me in an unsafe situation on two occasions: 1) Pulling out of a parking lot onto a 2 lane snow covered highway, the throttle became completely unresponsive while I was sitting across both lanes of traffic, leaving me exposed to a collision. I had to shut off and restart the engine to get moving. Elevation 10,700 feet. 2) In a parking lot, moving to get out of the way of a snowplow. I had to restart the vehicle 5 times...

After MB performed required "Campaign" #2021070027 related to transmission, CDI, VGS and SCR (emissions controls), transmission now shift erratically and sometimes unpredictably, engine in now running a higher RPMs, oil pressure is higher and fuel economy (as measured by manual calculations) has decreased by not less than 15%. Vehicle was originally taken to MB dealer related to a repeated (3 times) intermittent/unexpected power loss and dash warning. Loss of power could lead to loss of control, especially at highway speeds. The vehicle was inspected and above noted campaign was applied. Mileage on the vehicle is currently 15000. Events took place between 12k and 14.5k. Degrade of fuel economy as well as other operations degradations took place after a service visit at 14.5k.

The contact owned a 2019 Mercedes-Benz Sprinter 3500. The contact stated while driving at 50 MPH with his wife in the front passenger seat and six passengers in the rear seats, the vehicle began to stall. There were no warning lights illuminated. The contact heard an abnormal sound coming from the engine and noticed smoke coming out of the hood and inside the cabin of the vehicle. The contact veered to the side of the road and turned off the vehicle. Both the contact and his wife exited the vehicle. The contact stated while he was contacting road side assistance, his wife noticed smoke and flame coming out of the front passenger's side Whewell of the vehicle. All the passengers exited the vehicle. The contact extinguished the fire with a fire extinguisher; however, the fire restarted and increased significantly. The contact stated that the fire burned the front end of...

THE MERCEDES-BENZ DEALERSHIP CAN NOT REPAIR THE PROBLEM ON TEH "ECALL" OR THE "BRAKE PEDAL BOLT" BOTH WHICH ARE LIFE THREATENING THEY DEALERSHIP ADVICED ME ON CONTACTING YOU?