2000 MERCEDES BENZ ML430 Electrical System Problems

The contact owned a 2000 Mercedes Benz ML430. The contact stated that while driving approximately 40 mph the ABS light had illuminated and smoke was present coming from the steering column. Moments later flames were present coming from under the hood and the subframe of the vehicle. The driver exited the vehicle and the local fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed and later towed away. A police report was filed at the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not contacted. The failure mileage was 135,000. The VIN was not available.

TL* THE CONTACT OWNS A 2000 MERCEDES-BENZ ML430. THE CONTACT STATED THAT VARIOUS WARNING INDICATORS FLASHED ON THE INSTRUMENT PANEL SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER (BOBBY RAHAL MOTORCAR COMPANY, 10701 PERRY HWY, WEXFORD, PA 15090, (724) 935-9300) WHO WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE WITH THE DTC PRESENT WHEN THE VEHICLE WAS INSPECTED BY THE DEALER'S MECHANIC(S). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE TO DETERMINE IF THEY COULD PROVIDE A TECHNICIAN AND A SOLUTION TO REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 172,000. UPDATED 10/26/17*LJ THE CONSUMER STATED PROBLEMS WITH VAN CONTROL, ABS LIGHT ON, BALL JOINT LIGHT ON, TRANSMISSION, BAS MALFUNCTION, ETS MALFUNCTION, AND TRANSMISSION IN LOW RANGE. *TR

2000 MERCEDES BENZ ML-430. CONSUMER WRITES IN REGARDS TO BRAKE MALFUNCTION WHILE DRIVING VEHICLE. *SMD THE CONSUMER DISCOVERED THERE WAS A RECALL ON THE BRAKES AND HAD THE ISSUE ADDRESSED. HOWEVER, SHE FELT THERE WAS STILL A PROBLEM. THE CONSUMER STATED ABS, SRS, BAS, ESP AND ETS LIGHTS ILLUMINATED ON THE DASHBOARD, AND THE BRAKES LOCKED UP AND THE SHE HAD NO CONTROL OVER THE VEHICLE. SOME OF THE LIGHTS WENT OUT, WHILE SOME HAVE REMAINED ON.

WHILE DRIVING 15 MPH THE DRIVER SUDDENLY HEARD A POP AND THEN THE DRIVER AND PASSENGERS SEAT BELTS BEGAN TO RETRACT INTO THE RETRACTOR. THE CONSUMER ALSO STARTED TO SMELL GAS. *NLM ALL FOUR OF THE VEHICLE OCCUPIED SEAT BELTS BECAME TIGHT AND THE SIRS LIGHT ILLUMINATED. THE DEALER REPLACED THE DRIVER AND FRONT PASSENGER SEAT BELTS ALONG WITH BOTH REAR SEAT BELT ASSEMBLIES. THE SIRS CONTROL MODULE WAS ALSO REPLACED. *CB *NLM