2000 MAZDA MX-5 MIATA — Problems, Recalls & Safety Data

THE TRUNK SMELLS LIKE GASOLINE. THE CABIN SMELLS LIKE GASOLINE. WHILE RESEARCHING ONLINE, THERE ARE NUMEROUS COMPLAINTS ABOUT A GAS SMELL ON THESE CARS.

ENGINE BEGAN RUNNING BADLY AND CHECK ENGINE LIGHT CAME ON. TOOK TO MAZDA DEALER SHOP AND WAS TOLD A SPARK PLUG WIRE WAS DEFECTIVE AND BURNED UP. IN ACTUALITY, THE IGNITION COIL HAD FAILED AND CAUSED THE PROBLEMS. THE DEALER REPLACED SPARK PLUGS, IGNITION WIRES, AND COIL. TWO MONTHS LATER THE CHECK ENGINE LIGHT CAME ON AGAIN AND THE CATALYTIC CONVERTER WAS CLOGGED AND HAD TO BE REPLACED. THE MECHANIC SAID IT WAS DUE TO THE POOR RUNNING DURING THE TIME WHEN THE IGNITION COIL HAD BEEN MISFIRING. SO THE DEFECTIVE COIL CAUSED A GREAT DEAL OF DAMAGE, AND MAZDA HAS TAKEN NO RESPONSIBILITY FOR THESE DEFECTIVE PARTS OR THE DAMAGE THEY HAVE CAUSED. IF YOU READ COMPLAINTS FOR 1999 MODELS, YOU'LL SEE MANY FAILURES OF THE IGNITION COIL, SOME CAUSING DAMAGE TO OTHER PARTS COSTING A GREAT DEAL OF MONEY. APPARENTLY, SIMILAR COILS WERE USED ON 2000'S WITH SIMILAR FAILURES. BUT NO RECALL AND NO INVESTIGATION.

ENGINE BEGAN RUNNING BADLY AND CHECK ENGINE LIGHT CAME ON. TOOK TO MAZDA DEALER SHOP AND WAS TOLD A SPARK PLUG WIRE WAS DEFECTIVE AND BURNED UP. IN ACTUALITY, THE IGNITION COIL HAD FAILED AND CAUSED THE PROBLEMS. THE DEALER REPLACED SPARK PLUGS, IGNITION WIRES, AND COIL. TWO MONTHS LATER THE CHECK ENGINE LIGHT CAME ON AGAIN AND THE CATALYTIC CONVERTER WAS CLOGGED AND HAD TO BE REPLACED. THE MECHANIC SAID IT WAS DUE TO THE POOR RUNNING DURING THE TIME WHEN THE IGNITION COIL HAD BEEN MISFIRING. SO THE DEFECTIVE COIL CAUSED A GREAT DEAL OF DAMAGE, AND MAZDA HAS TAKEN NO RESPONSIBILITY FOR THESE DEFECTIVE PARTS OR THE DAMAGE THEY HAVE CAUSED. IF YOU READ COMPLAINTS FOR 1999 MODELS, YOU'LL SEE MANY FAILURES OF THE IGNITION COIL, SOME CAUSING DAMAGE TO OTHER PARTS COSTING A GREAT DEAL OF MONEY. APPARENTLY, SIMILAR COILS WERE USED ON 2000'S WITH SIMILAR FAILURES. BUT NO RECALL AND NO INVESTIGATION.

I RECENTLY PURCHASED THIS CAR WITH ONLY 44,000 MILES ON IT. I RECEIVED THE COMPLETE SERVICE RECORD, AND IT HAD BEEN MAINTAINED THROUGH THE DEALERSHIP AND THROUGH A PRIVATE GARAGE AND BODY SHOP ON A REGULAR BASIS AND THOROUGHLY INSPECTED ON EVERY SERVICE AND BEFORE I BOUGHT IT. NO MENTION HAD EVER BEEN MADE OF RUST IN THE FRONT FRAME RAILS. I PULLED THE FRONT WHEELS TO CLEAN UP RUST AND ALL CONNECTIONS AND FOUND PATCHES OF RUST ON BOTH FRAME RAILS BETWEEN THE SWAY BAR BRACKET AND STRUT BRACKETS. I CAN PUNCH A SCREWDRIVER THROUGH THE RUST ON THE DRIVER'S SIDE. I LOOKED INSIDE HOLES AND SAW RUST INSIDE THE FRAME RAILS. I FOUND MANY ONLINE COMPLAINTS CONCERNING SIMILAR RUST ON NB MODELS 1999-2005. THIS RUST WILL WEAKEN THE FRAME RAILS AND COULD CAUSE THEM TO BREAK DURING A FRONT END COLLISION, THUS COMPROMISING CRUMPLE ZONES. IT WILL ALSO COMPROMISE THE BRACKETS HOLDING SWAY BARS, STRUTS, AND OTHER VITAL SUSPENSION COMPONENTS. THIS COULD CAUSE A LOSS OF STEERING CONTROL. THE RUST BEGINS INSIDE FRAME RAILS SO CAN'T BE SEEN IN EARLY PHASES--UNTIL IT APPEARS ON OUTSIDE OF RAILS. SEEMS CLEAR THAT MAZDA KNOWS OF THESE PROBLEMS SINCE IT REDESIGNED THE FRAME IN 2006 AND SELLS REPAIR PARTS THAT DON'T INVOLVE THIN SANDWICHED SHEETS OF METAL WITH MATERIALS IN BETWEEN THAT HOLD MOISTURE, ROAD SALT, AND OTHER CONTAMINANTS. NUMEROUS HOLES IN THE FRAME RAILS ALSO SEEM TO TAKE IN WATER AND CONTAMINANTS. MIATAS ARE MADE TO PERFORM ON CURVES AND HAVE STIFF SUSPENSION, SO A LOT OF STRESS COMES ON THE FRAME AND BRACKETS. I AM NOW AFRAID TO DRIVE MY MIATA LIKE A SPORTS CAR SINCE THAT WILL CAUSE FURTHER FRAME CRACKING. FROM WHAT I'VE SEEN ONLINE, REPAIRS ARE COMPLEX AND EXPENSIVE. DON'T KNOW WHY THIS SAFETY ISSUE HAS NOT BEEN THE SUBJECT OF INVESTIGATIONS AND RECALLS. THE PROBLEMS SEEM TO RESULT FROM POOR QUALITY FRAME MATERIALS AND INADEQUATE ENGINEERING DESIGN.

1999>2000 MAZDA MIATAS ARE KNOWN TO HAVE HAD A BAD BATCH OF COIL PACKS PUT IN THEM, RESULTING IN THE CHECK ENGINE LIGHT COMING ON, (HAS HAPPENED TO ME THREE TIMES), NOT WHILE DRIVING, BUT UPON RESTARTING AFTER A BRIEF STOP, LIKE AT A STORE, WHEREVER. ANYWAY THE CODE SAYS, RANDOM MISS FIRING, WHICH RESULTS IN A VERY LEAN UNBURNED MIXTURE OF FUEL, WITH MANY OWNERS HAVING THEIR CATALYTIC CONVERTERS AND/OR 02 SENSORS GET BURNT OUT AS A RESULT. WHEN THIS OCCURS THE ENGINE RUNS VERY VERY ROUGH, AND COULD STALL. IF THIS HAPPENS IN THE WRONG SITUATION, LIKE ON THE FREEWAY, IT COULD POSSIBLY RESULT IN AN ACCIDENT OR EVEN DEATH. MAZDA KNOWS ABOUT THIS AND HAS A TECHNICAL BULLETIN OUT ON IT, BUT IT IS AROUND A $300 PART (DEALER) AND VERY NEAR THAT EVERYWHERE ELSE (I.E. AUTOZONE $260) AND THEY TOLD ME THAT THERE IS NOT A RECALL ON THIS. IMO SINCE THIS CONDITION CAN AND WILL RUIN THE POLLUTION SYSTEM, THEY OUGHT TO ISSUE A RECALL, AND REFUND ANY MONEY ALREADY SPENT ON THE NEW COIL PACK FOR THOSE THAT HAVE ALREADY HAD IT CHANGED. *TR