2005 LEXUS RX330 Exterior Lighting Problems

PASSENGER SIDE HEADLIGHT FIXTURE LEAKS AND LOW BEAM LIGHT STOPPED WORKING. *TR

LEAKING POWER STEERING RACK ASSEMBLY. SEEMS TO BE A VERY COMMON PROBLEM WITH THESE RX330'S. ADVISED I NEED A NEW RACK & PINION ASSEMBLY. LEXUS NEEDS A RECALL FOR THIS ISSUE, TOO MANY COMPLAINTS! ALSO TOLD NEED TO REPLACE HEADLIGHT BALLIST! *TR

I WILL ADD MY COMPLAINT TO PREVIOUS REPORTER. I HAVE HAD TO REPLACE THE HEADLAMP 2 TIMES DUE TO WATER IN THE ASSEMBLY OF THE HEADLAMP. THE RIGHT SIDE HEADLIGHT FAILED. THERE IS MOISTURE UNDER THE GLASS WHICH SHORTED OUT THE LIGHT. ONLINE I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THIS HAPPENING TO THE SAME MODEL LEXUS. THE REPAIR FOR THIS HEADLIGHT RUNS OVER $1,500. LEXUS CORPORATION REFUSES TO TAKE RESPONSIBILITY FOR AN OBVIOUS DESIGN FLAW. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE RIGHT SIDE HEADLIGHT FAILED. THERE IS MOISTURE UNDER THE GLASS WHICH SHORTED OUT THE LIGHT. ONLINE I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THIS HAPPENING TO THE SAME MODEL LEXUS. THE REPAIR FOR THIS HEADLIGHT RUNS OVER $1,500. LEXUS CORPORATION REFUSES TO TAKE RESPONSIBILITY FOR AN OBVIOUS DESIGN FLAW. *TR

TL* THE CONTACT OWNS A 2005 LEXUS RX330. THE CONTACT STATED THAT THERE WAS CONDENSATION ON THE DRIVER'S SIDE HEADLIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN STATED THAT THE HEADLIGHT WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. ..UPDATED 12-26-13 *BF

DRIVERS SIDE HEADLAMP GOT WATER INSIDE THE HOUSING CAUSING THE HID HEADLIGHT TO SHORT OUT. HOUSING SEEMS TO BE FULLY SEALED.

WATER ROUTINELY COLLECTS INSIDE OF BOTH HEADLIGHTS WHENEVER I WASH THE CAR OR WHEN RAINING. LIGHT FAILURE DUE TO WATER INSIDE OF THE HEADLIGHTS IS REPORTED BY MANY OTHER RX330 OWNERS ON VARIOUS INTERNET FORUMS. I'M VERY AFRAID THAT LIGHTS MIGHT FAIL WHEN DRIVING AT NIGHT. THIS IS A SAFETY ISSUE. LEXUS REFUSES TO RECOGNIZE THE PROBLEM AND TO ISSUE A RECALL SINCE SO MANY CARS ARE AFFECTED. LOCAL DEALER ADMITTED THAT THERE IS A WIDESPREAD PROBLEM. PLEASE HELP. *TT

CONDENSATION BUILDUP HAS FORMED FROM THE INTERIOR OF THE DRIVER/PASSENGER HEADLIGHTS. THIS IS DUE TO A MANUFACTURER DESIGN FLAW OF THE HEADLIGHT SEAL WHICH ALLOWS WATER TO PENETRATE THE HEADLIGHT HOUSING. WATER DAMAGE HAS CAUSED THE LOWBEAM LIGHTS TO FAIL. LEXUS HAS QUOTED OVER $1400 FOR REPLACEMENTS, AND FAILS TO ACKNOWLEDGE THEIR DESIGN FLAW. IMPACTED VISIBILITY WHILE DRIVING WILL LEAD TO AN ACCIDENT. *TR

I OWN A 2005 LEXUS RX 330. I HAVE BEEN HAVING A PROBLEM WITH THE CONDENSATION BUILD UP WITHIN THE HEADLIGHT FOR ABOUT 6 MONTHS. I WENT TO THE LEXUS DEALER TO FIND OUT THE PROBLEM THEY CHARGED A $110.00 SERVICE CHARGE TO TELL ME THAT I NEED TO REPLACE MY HEADLIGHT ASSEMBLY. THE COST TO REPLACE IS ABOUT $2,200. THIS IS A DISGRACE. MY HEADLIGHT DOES NOT WORK AT ALL. I HAVE NOT BEEN ABLE TO DRIVE MY VEHICLE AT NIGHT FOR SOMETIME NOW. I CONTACTED LEXUS CUSTOMER CARE AND EXPLAINED TO THEM THAT THIS SEEMS TO BE A MAJOR PROBLEM AND THEY SHOULD HAVE DONE A RECALL ON THIS VEHICLE. THE RESPONSE FROM LEXUS IS THAT THEY WOULD REVIEW MY CASE AND SOMEONE WOULD CALL ME BACK WITH A DECISION. SOMEONE DID CALL ME BACK OFFERING TO PAY 25% OF THE TOTAL BILL OF 2,200 FROM THE LEXUS...

TL* THE CONTACT OWNS A 2005 LEXUS RX330. THE CONTACT STATED THAT WATER WAS ENTERING INTO THE DRIVER SIDE HEADLIGHT. THE DEALER WAS CONTACTED AND THEY ADVISED HIM THAT THE FAILURE WAS NORMAL AND REFERRED THE CONTACT TO THE OWNERS MANUAL. THE HEADLIGHT EVENTUALLY FAILED COMPLETELY AFTER NOTHING WAS DONE TO REPAIR THE FAILURE. THE VEHICLE WAS INSPECTED A SECOND TIME BY THE DEALER AND THEY ADVISED HIM THAT THE ENTIRE UNIT WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THEY WILL REVIEW THE CASE AND CONTACT HIM AT A LATER DATE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 6,000.

TL* THE CONTACT OWNS A 2005 LEXUS RX330. THE CONTACT STATED THAT THERE WAS AN EXCESSIVE BUILD-UP OF CONDENSATION IN THE PASSENGER HEADLIGHT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWO YEARS AFTER THE CONTACT NOTICED THE FAILURE THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP WHERE THE MECHANIC WAS ABLE TO REMOVE THE MOISTURE FROM THE HEADLIGHT. THE APPROXIMATE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 44,000.

I AM DESCRIBING AN EVENT THAT OCCURS REPEATEDLY AMONG OLDER DRIVERS. THEY PUT THEIR TURN SIGNAL ON, AND IT DOES NOT SWITCH OFF AND THEY DON'T KNOW IT BECAUSE THEIR HEARING ABILITY HAS DIMINISHED. THEY THEN MAKE A TURN TO THE OPPOSITE DIRECTION OF WHAT THEIR TURN SIGNAL INDICATES AND EITHER CAUSE AN ACCIDENT OR HAVE A CLOSE CALL. *TR

2005 LEXUS RX330. THE CONTACT STATED THAT THE RIGHT SIDE FRONT HEADLIGHT FAILED TWICE IN PAST 18 MONTHS DUE TO WATER CONDENSATION IN HEADLIGHT ASSEMBLY AND ECU. 1ST TIME WAS REPLACED UNDER WARRANTY. SECOND FAILURE WAS AFTER WARRANTY PERIOD AND LEXUS CORPORATE STATED IT WAS A DIFFERENT ISSUE AND REFUSED TO REPLACE. ESTIMATE TO REPLACE BY DEALER IS $1,600.00. *TR

CONDENSATION IN THE HEADLIGHTS STARTED EARLY ON AND IS ONLY GETTING WORSE ON MY 2005 RX 330. ALSO, I HAVE ALREADY HAD TO SWITCH THE FRONT BRAKE PADS OUT AND NOW HAVE TO SWITCH THE REAR BRAKE PADS OUT AS WELL AS THEY STARTED TO SQUEAL AND THE ROTORS WERE ALREADY RESURFACED BEFORE. THE CAR DOESN'T FULLY BRAKE UNTIL I PRESS DOWN EXTREMELY HARD ON THE BRAKES AND EVEN THEN IT SLIGHTLY ROLLS FORWARD AND THEN STOPS. ALSO, WHEN I ATTEMPT TO ACCELERATE, THERE IS A DELAYED ACCELERATION. IT TAKES AT LEAST 2 SECONDS BEFORE IT ACTUALLY BEGINS TO ACCELERATE AND EVEN THEN IT IS NOT A INSTANT ACCELERATION BUT A SLOW ONE. *TR

MOISTURE PROBLEM IN BOTH FRONT HEADLIGHTS OF MY 2005 LEXUS RX330. ONE WAS REPLACED 2 YEARS AGO UNDER WARRANTY THE OTHER MARCH 2010 WHICH WAS COVERED UNDER THE GOODWILL WARRANTY. BRING YOUR CAR TO LEXUS FOR SERVICE ALL THE TIME AND YOU GET THE LITTLE PERKS. *TR

HEADLIGHTS BOTH DRIVER/PASSENGER MOISTURE

MOISTURE INVADES SEALED HEADLAMP HOUSING CAUSING LAMP(S) TO FAIL. LEXUS HAS REDESIGNED THE PART. NO VOLUNTARY RECALL EVEN THOUGH LEXUS KNOWS THIS IS A DEFECTIVE PART. OUT OF WARRANTY REPLACEMENT COST IS $1650 FOR ONE HEADLAMP ASSEMBLY PLUS 1HR. LABOR. THAT'S NEARLY $2000 FOR ONE HEADLIGHT!! *TR

THE PASSENGER SIDE HEADLAMP OF THE RX330 CEASED OPERATION DUE TO A BUILDUP OF MOISTURE. CONDENSATION HAS BEEN PRESENT IN THE HEADLAMP FOR SOME TIME, BUT THERE WERE NO INDICATIONS THAT IT WOULD LEAD TO HEADLAMP FAILURE. THE SUV IS MAINTAINED BY THE DEALERSHIP EXCLUSIVELY, AND AT NO POINT DID THEY MENTION THE POSSIBILITY THAT THE CONDENSATION COULD CAUSE FAILURE. THE FAILURE OCCURRED AT NIGHT IN A DARK SECTION OF HIGHWAY AND COULD HAVE LED TO SERIOUS BODILY HARM OR DEATH. LEXUS HAS BEEN AWARE OF THE PROBLEMS WITH THE RX330 HEADLAMPS SINCE 2005 AND HAS FAILED TO REMEDY THE PROBLEM. THE MOISTURE ISSUES COULD POTENTIALLY RESULT IN SERIOUS HARM TO THE DRIVER AND OCCUPANTS OF THE LEXUS OR OTHER MOTORISTS. *TR

CONDENSATION IN HEADLAMP ASSEMBLY CAUSING HEADLIGHT TO BLOW. HEADLAMP ASSEMBLY COSTS $1,900 EA. TO REPLACE. LEXUS RX330. VEHICLE HAS BEEN OFF WARRANTY FOR ALMOST 2 MOS. 62,700 MILES ON VEHICLE. LEXUS CUSTOMER SATISFACTION SAYS THEY ARE NOT RESPONSIBLE FOR REPAIR. LEXUS DEALERSHIP WILL GIVE US A DISCOUNT (FEW HUNDRED DOLLARS). CANNOT DRIVE VEHICLE WITH NO HEADLIGHTS AT NIGHT. RESEARCH SHOWS A NUMBER OF LEXUS RX330 HEADLAMP PROBLEMS. VEHICLE CANNOT BE REPAIRED BY ANYONE OTHER THAN LEXUS AS THIS IS A COMPUTER ASSEMBLY REPLACEMENT. RAIN HEAVY, CONDENSATION BUILDS UP INSIDE ASSEMBLY CAUSING SHORT AND BLOWING OUT HEADLIGHT. *TR

TL*THE CONTACT OWNS A 2005 LEXUS RX330. MASSIVE AMOUNTS OF CONDENSATION IN THE HEADLAMPS CAUSED THE COMPUTER TO FAIL. THE COMPUTER OPERATES THE HEADLIGHTS. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED ABOUT THE TSB. THEY ALSO VOLUNTEERED TO PAY $1,000 TOWARDS THE COST OF THE REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 65,000.

CERTIFIED 2005 LEXUS RX 330 HAS HEADLIGHT CONDENSATION ONE WEEK AFTER I BROUGHT IT HOME. NOTIFIED THE DEALER AND THEY TOLD ME THAT ITS NOT COVERED UNDER THE CERTIFIED WARRANTY. I HAVE THE HID HEADLIGHTS THAT TURN WITH YOU AROUND CORNERS, WHICH WILL COST $1800 TO REPLACE! FROM WHAT THE DEALER TOLD ME, THEY USED TO HONOR THIS DEFECT BUT THERE WERE TOO MANY AND IT GOT TOO COSTLY FOR THEM! A CERTIFIED LEXUS SHOULD NOT HAVE DEFECTIVE HEADLIGHTS. *TR

I HAVE A 2005 LEXUS RX330 IN WHICH WHEN RAINING, HEADLIGHT CONDENSATION OCCURS. I'M SURE AS THE CONDENSATION WORSENS, THE CLEAR LENS WILL START TO YELLOW IMPAIRING VISIBILITY AND ULTIMATELY HID LAMP FAILURE. WHENEVER IT RAINS OR I GET A CAR WASH IT IS MOST OBVIOUS AND ANNOYING. LEXUS OF BAY RIDGE REPLACED ONLY 1 LIGHT AND NOW THE OTHER ONE IS HAVING THE SAME PROBLEM. *TR