2020 KIA STINGER Electrical System Problems

The vehicle will shut off without reason from time to time. I'll be sitting at a light, stop sign, or intersection, and the car just shuts off. All electronics inside the car turn off, the engine turns off, and it's as if I've shut the car off to get out. Usually, I'm able to restart the car after a few moments and go about my day, but in doing some research on this issue, there have been others that have had the same issue. When others take their car in to have it investigated, the dealership is unable to locate the issue as it's extremely difficult to replicate. A person's safety is definitely in question considering if the car shuts off while driving, it could lock the steering wheel as a few others have seen. The only symptom that I have experienced is the music from the radio goes weird...

I was sitting at a red light with my foot on the brake. When I took my foot off the brake when the light turned green, my car would not drive forward!! I checked to make sure my car was not in Park. All of the lights on the dash were on and the engine was no longer running. Not to mention something similar happened November 18, 2023 where I was driving and the engine suddenly lost power And cut off, and it would not crank back up for longer than 3 secs w/o losing power. my car could no longer run. I ended up having to get it towed to a local Kia dealership On Covington Pike in Memphis, TN (the location on Mt Moriah informed me that if I took it to to their location, I would be charged $175 plus tax for them to run diagnostic on...

1st safety related incident discovered December 27th, 2021, rear window defroster stopped working. Checked rear fuse block as the owner's manual had listed that the fuse would be located there. Visual observation of fuse block showed rear heater fuse had blown and the area around the fuse discolored and melted. Remedy was dealership replacing rear fuse block and given back with no explanation why the fuse heated up to cause fuse and fuse block to start to melt. 2nd same safety related incident discovered June 18th, 2023, when checking rear fuse block to see if the previous repair fixed the possible electrical fire related concern. It was noticed again that the same fuse had similar discoloration and plastic melting around the fuse. Fuse was removed and alternate dealership contacted about this concern. Vehicle was left at dealership on July 28th, 2023 and loaner vehicle was given to use until remedy...

I PURCHASED THIS CAR BRAND NEW IN JULY AND HAVE HAD THE SAME ELECTRICAL SYSTEM PROBLEM AT LEAST 7 TIMES NOW. THE ISSUE IS THAT SOMETIMES, WHEN I GIVE A RIGHT HAND TURN SIGNAL, THE VEHICLE'S ENTIRE ELECTRICAL SYSTEM SHUTS DOWN. IT HAS DONE IT ON A SLOW TURN, ON A MERGE GOING 35MPH, AND ON A A HIGHWAY EXIT RAMP GOING 60MPH. THIS IS DANGEROUS AND ONLY A MATTER OF TIME UNTIL ME, OR SOMEONE ELSE, DIES AS A RESULT OF THIS FAILURE. I HAVE BEEN DEALING WITH THIS PROBLEM OFF AND ON FOR 6 MONTHS AND I'M TIRED OF IT.

FUEL LINE CONNECTION WITHIN THE ENGINE COMPARTMENT HAD A LOCK/COVER THAT WAS NOT SEATED/ATTACHED. ISSUE WAS DISCOVERED AFTER DOING A THOROUGH LOOK OVER OF A NEWLY PURCHASED VEHICLE IN WHICH A LOOSE NUT WAS FOUND IN THE TRUNK. UPON REMOVAL OF THE PLASTIC ENGINE COVER NEXT TO THE NON LOCKED FUEL LINE TWO MISSING BOLTS WERE FOUND FOR A WIRE HARNESS ON TOP OF THE ENGINE. OWNER CONNECTED FUEL LINE LOCK, DEALER INSTALLED TWO BOLTS TO THE WIRE HARNESS. NO RECEIPT WAS GIVEN SINCE NOTHING WAS BILLED.