2025 KIA SORENTO HYBRID Engine Problems

Currently at a Kia dealership for the 3rd time since the end of December. While driving the electric refuses to switch to gas after the battery drains, it is a hybrid. Maxes out at 18 mph and then an alarm goes off for Hybrid System error. First two time check engine light also came on. Have had vehicle towed to Kia dealerships all three times. Never the same thing repaired or replaced but problem stops for a few days to two weeks and then happens again. They vehicle has been examined and the issue has been replicated or examined by the Canton Kia dealership in Canton, MI two times. Currently at Taylor Kia Toledo, OH. This is a safety issue due to the lack of speed and acceleration. So far I have been in relatively low speed areas but what if it happened on the expressway or in heavy traffic....

The contact owns a 2025 Kia Sorento Hybrid. The contact stated that while driving approximately 65 MPH, the vehicle went into LIMP Mode, and the vehicle decelerated to 35 MPH. The vehicle was driven to the residence and was later towed to the local dealer. While at the dealer, the cause of the failure was not determined, and the failure had self-corrected. The vehicle was retrieved; however, approximately 1,500 miles late,r the failure reoccurred. The manufacturer was made aware of the failure. The failure mileage was 2,300.

Incident #1: Car suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Car was traveling at 45mph in morning traffic. Pedal was pushed to the floor, but car would only go a maximum of 20mph. Warning dash lights then appeared saying "Hybrid Malfunction/Pull Over Immediately/Turn off car". I was able to pull off road and turn off car and then turn back on. Car ran normally the 2 miles back home. Incident #2: 2 days later, while driving my kids to school the car again, suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Again, warning dash lights: "Check Hybrid System. Stop Safely!". I did so and car ran normally back to my house (distance approx: 2.5 miles). I immediately called KIA of Beaverton and they said to have it...

While driving, have had the engine of my 25 Sorento Hybrid stop working. An emergency notice comes on the screen (see photo) stating to pull over safely. The hybrid system error message has come on 4-5 times in the last month. The vehicle will not drive more than 15-20 miles per hour and has virtually no acceleration making it very dangerous to drive in or around high speed/traffic areas. Took it to a local Kia dealership where I was told nothing was wrong and their only guess was that it was related to the battery and cold weather. The same messaged/incident has happened 2x since bringing it into the dealership. With the most recent being 1/22/26. Problem first arose on 1/9/26. There are dozens of reports of this in online threads over the past few months with Kia hybrid engines

My wife first drove the vehicle and started noticing intense fumes entering the cabin which required rolling down the windows. There were no alerts from the car at this time or engine lights. We checked to see if the exhaust got plugged and it was not. I later drove the car that same day and it would not accelerate when I tried to right turn onto a main road. The check engine light then popped on and loud alerting from the vehicle cause me to have to pull over and shut the vehicle off. We had it towed by the dealer and the last thing we heard was that gas and oil had leaked together and it would take 5 days to get the part to fix it.

Will be driving when it switches to EV mode it will have no power and go into limp mode. Can't go over 30 mph. This is now the second time this has happened. Dealership tried to say it was because of temperature. Come on.

Beginning at approximately 750 miles on a brand-new 2025 Kia Sorento Hybrid EX, the vehicle experienced a flashing Check Engine Light accompanied by severe shaking while driving, rough idling, loss of power, and loud engine/exhaust noise. The vehicle became difficult and unsafe to operate due to the vibration and reduced drivability. These symptoms appeared suddenly on November 22, less than three weeks after purchase. The vehicle was taken to the dealership on November 24. Their technician retrieved diagnostic codes P0300 (Random Misfire) and P0304 (Cylinder #4 Misfire) and identified a failed ignition coil on Cylinder #4. The coil was replaced, and the dealership reported the issue resolved. However, less than 24 hours later, with the vehicle still under 800 miles, the exact same symptoms reoccurred: heavy shaking while driving, vibration while idling, loss of power, and unstable engine operation. This indicates the underlying issue may be more serious than a...

Dad, driving back with Daughter, noticed a brief and unusual delay between shifts, but was able to make it home fine. A few minutes later, Mom left for picking up Son after school. On the way there, she noticed sluggish acceleration, louder engine sounds/effort on acceleration and mild slopes, and there was a lag in acceleration response. After powering off the vehicle and sit in idle to recharge battery, restarted trip home and was unable to get acceleration response up the hills, doing only 20 MPH. Engine was struggling and not getting any acceleration response. No check engine lights were generated as usual. Dad called Service Manager at Kia Temecula and he said to call Kia Roadside Assistance to come tow the car to them. He also said that likely we'll be out of pocket to do any car rentals until they have a car to loan to us.

While driving my 2025 Kia Sorento SX Hybrid on a normal hot day, I experienced a sudden and dangerous loss of power. I had briefly exited the freeway to pick up my children and left the vehicle running. After re-entering the freeway, the car failed to accelerate despite pressing the gas pedal to the floor. It felt stuck in first gear, with the engine revving but no response. The hybrid battery showed nearly empty, and the car would not switch properly between electric and gas modes. A warning appeared instructing me to “park the car and leave the engine on to charge the battery,” which I did. After idling for several minutes, I slowly drove—with hazards on and speed under 25 mph—to the nearest Kia dealer 1.5 miles away. This incident could have been catastrophic if it occurred while merging into traffic. The dealer has been unable to replicate the...

On June 5, 2025, I was driving my 2025 Kia Sorento. I proceeded to get onto the highway from an on ramp. At that moment, the engine stalled. The car would not accelerate. I could not go faster than 20-25 mph. This was a huge safety risk to me, to my passengers, and to others on the highway. Eventually I exited the highway and drove home very slowly, since the car would not accelerate beyond 20-25 mph. I was pressing the gas pedal as far down as it would go. I even tried turning off the car and restarting it. The check engine light was on. The car was towed to a Kia dealer. The Kia mechanics noted that the fault log in the car's computer system noted that the stalling/failure to accelerate event did occur, but that they were unable to reproduce it, even after several attempts driving it...

I pulled out of my subdivision and immediately received an error check engine light warning and initially didn't think much of it. As I pressed the accelerator I noticed there was no engine power at all just electric (this is a Sorento Hybrid SX Prestige) so I immediately pulled over and turned the car off for two minutes. Upon turning it back on the engine did rengage so i decided to proceed. About a mile further the same check engine error occurred with the engine not responsive at all and only electric power available so I made a u-turn and proceed back to my house. Prior to arriving at my house another warning error appeared warning me the electric battery was dangerously low and to stop the vehicle immediately. I believe the error was a Hybrid system error with code P112000. Once again I turned the vehicle off and waited...

Incident #1 ([XXX]) - while driving on [XXX} at 70 MPH in Sarasota I experienced and complete loss of engine power. The car coasted from 70 MPH down to 35 MPH until the EV kicked in. I was very fortunate as were the other driers not be involved in a serious accident. I reported this situation to Kia NA and was assigned this case number [XXX] Kia had the car from [XXX] until [XXX]. They told me the problem was a defective fuel rail pressure sensor . The assured us the car was fixed Incident #2 ([XXX]) [XXX] days later with four passengers in the car we experienced the exact same problem while driving on [XXX], a complete loss if engine power. Kia has the car now and assigned a case number of [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)