2001 KIA RIO Suspensionfrontwheel Bearing Problems

TL* THE CONTACT OWNS A 2001 KIA RIO. THE CONTACT STATED WAS DRIVING APPROXIMATELY 60 MPH AND ATTEMPTING TO SWITCH LANES WHEN SHE HEARD AN UNUSUAL NOISE SIMILAR TO RUMBLING METAL, FOLLOWED BY A LOUD CLUNK. THE CONTACT WAS BARELY ABLE TO MAINTAIN CONTROL OF THE VEHICLE YET WAS ABLE TO MANEUVER THE VEHICLE OFF THE ROADWAY. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE SHE WAS ADVISED THAT THE WHEEL BEARING SPACER WOULD NEED REPLACING. THE DEALER MADE REPAIRS TO THE VEHICLE YET THE FAILURE RECURRED WITHIN SIX MONTHS. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED EIGHT TIMES FOR THE FAILURE SINCE PURCHASE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 81,000.

DRIVING IN TRAFFIC, MADE RIGHT TURN INTO DRIVEWAY AT 30 MPH AND THE ENGINE DIED, STEERING WAS NOW UNASSISTED. I ROLLED THE CAR INTO A PARKING SPOT. THE CAR STARTED UPON MY RETURN TO THE CAR. THIS HAS HAPPENED AT LEAST 6 OTHER TIMES SINCE I'VE OWNED THE VEHICLE. THE CAR HAS LESS THAN 60, 000 MILES AND HAS AMASSED NUMEROUS REPAIR ISSUES: FAILURE OF AUTOMATIC TRANSMISSION; REAR WHEEL BEARING REPLACEMENT; DEFECTIVE SIDE MIRROR THAT SCREAMS AT HIGH SPEEDS/FREEWAY DRIVING W/WINDY CONDITIONS; SUN VISORS WHICH DO NOT ADHERE TO PLACEMENT; AND WINDSHIELD WASHER PUMP FAILURE. UPON ACQUIRING THE VEHICLE THIS WAS THE FIRST PROBLEM I TOOK THE CAR IN FOR REPAIR. AND ON SUBSEQUENT VISITS, IT HAS BEEN AN ISSUE, BUT THE PROBLEM PERSISTS. *NM

DT*: THE CONTACT STATED WHILE THE TIRES WERE BEING ROTATED AT AN INDEPENDENT REPAIR SHOP, IT WAS DETERMINED THE FRONT WHEEL BEARINGS WERE LOOSE. THE REPAIR SHOP TIGHTENED THE FRONT WHEEL BEARINGS. AFTER THE INITIAL FRONT WHEEL BEARING TIGHTENING, DURING NORMAL MAINTENANCE, THE LEFT REAR WHEEL BEARING WAS LOOSE AS WELL. THE REAR WHEEL BEARING WAS TIGHTENED BY AN INDEPENDENT REPAIR SHOP. THERE WERE NO PREVIOUS WARNING INDICATORS FOR THE WHEEL BEARING LOOSENESS. THE MANUFACTURER WAS NOTIFIED.

PURCHASED CAR, 2001 KIA RIO, IN OCTOBER OF 2000. WITHIN A FEW DAYS AIRBAG LIGHT CAME ON. THIS OCCURRED SEVERAL TIMES OVER A ONE YEAR PERIOD AND HAD TO BE TAKEN BACK TO DEALER FOR REPAIR AT LEAST FOUR TIMES. RECALL WAS RECEIVED FOR FUEL SYSTEM. THIS WAS REPLACED WITHOUT PROBLEM. NEXT PROBLEM OCCURRED WITH WHEELS, WHICH WAS ALSO A RECALL. I HAD TO ORDER THE WHEELS WHICH TOOK AT LEAST A MONTH TO COME IN LEAVING ME TO DRIVE TO AND FROM WORK, 65 MILES EACH WAY, ON VIOLENTLY VIBRATING WHEELS. WHEELS WERE FINALLY REPLACED. PROBLEM OCCURRED IN WINTER 2005 WITH DOOR LATCH. DRIVER SIDE DOOR WOULD LOCK AND STAY LOCKED. VEHICLE WAS TAKEN TO ORIGINAL DEALER FOR REPAIR ONLY TO HAVE OLD PART REPAIRED WHILE BEING CHARGED FOR NEW PART AND LABOR. WITHIN A FEW DAYS, DOOR LATCH FAILED AGAIN. TOOK VEHICLE TO ANOTHER DEALER WHO ORDERED NEW...

DEFICIENT WHEEL BEARING ON KIA RIO. *BF RECURRING PROBLEMS WITH THE WHEEL BEARINGS. THE CURRENT WHEEL BEARING PROBLEM WAS DIAGNOSED AS THE TIRES. THE NOISE STILL EXISTS. THE CONSUMER REQUESTED REIMBURSEMENT. *SC *JB

WHILE DRIVING AT HIGHWAY SPEEDS, ENGINE STALLS OUT. DEALER SAID IT WAS CAUSED BY CORRODED WIRING UNDER THE HOOD. *AK THE CONSUMER STATES THAT TWO WEEKS AFTER PURCHASING THE VEHICLE, THE VEHICLE DIED AND WOULD NOT START WHEN TRAVELING ON THE HIGHWAY. A WEEK LATER THE VEHICLE WOULDN'T GO IN REVERSE, CONSUMER WAS TOLD THAT VEHICLE NEEDED A NEW TRANSMISSION. THE VEHICLES AIRBAG AND ENGINE LIGHT WOULD STAY ON. REPLACED/REPAIRED THE FOLLOWING; REPLACED INPUT SPEED SENSOR, REPAIRED THE OPEN CIRCUIT/DRIVERSIDE AIRBAG, REPLACED LEFT FRONT HUB BEARINGS,INNER/OUTER SEALS, FRONT BRAKES REPLACED, AND THE ROTORS MACHINED. *SCC

VEHICLE WAS MAKING A LOT NOISE. TOOK VEHICLE TO DEALER ,AND THEY STATED THAT CHUNKS OF METAL FROM WHEEL BEARING WERE IN BRAKE DRUM. CONSUMER STATED WHEEL BEARING HAD BEEN REPLACED. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

WHEEL BEARINGS HAVE FAILED 3 TIMES IN 6 WEEKS...TWICE RT REAR, ONCE LT REAR...BRAKES HAVE BEEN MAKING NOISE SINCE CAR WAS NEARLY NEW, HAVE BEEN ADJUSTED NUMEROUS TIMES