2013 KIA OPTIMA Electrical System Problems

My car suddenly caught fire in my driveway tonight 2/6/26 roughly around 9:40 PM. Fire department has been dispatched to come out and investigate if the fire has been properly extinguished and it does warrant any further safety hazards until Kia can be notified and resolve this issue.

I received a recall notice for my 2013 Kia Optima, VIN #: [XXX] related to engine issues and an increased risk of fire. After receiving the recall notice, my vehicle began smoking and briefly caught fire while in operation. I immediately shut the vehicle off, and the smoke and fire stopped. For safety reasons, the vehicle was towed by my insurance company to my aunt’s residence, which was the closest safe location at the time. The vehicle was unsafe to drive. No injuries occurred, and the fire department was not called because the fire stopped once the vehicle was turned off. I believe this incident is related to a known safety defect and recall involving Kia Optima engine fires. I have contacted Kia multiple times regarding this issue, and there have been delays in addressing or repairing the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5...

My 2013 Kia Optima caught fire while my [XXX] son and his friends were driving it. The car burnt up. Some truck drivers flagged my son down to let him know the car was on fire. They could have been killed if it wasn’t for the truck drivers warning him that the car was on fire while driving down the highway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The computer modular or engine control module yes, it is available for inspection. I can be at risk because my lights flicker off and, on my turn, signals do not work, and it will not go into drive I have to start my car 30 minutes before I can leave for work at 5:30am in the morning. I had a security update on my car and ever since that took place, I had this issue. I just had the P1326 code come up on my car last November took it to Vero Beach Kia and had that update done on my car for the engine problems that is going on, and they replaced the last recall which was the knock sensor. I had explained to them the issue my car does when starting it they told me it has nothing to do with the update that would cause it. When...

During a drive after startup, vehicle flashed the Hybrid Electric Vehicle (HEV) error and put the car into limp mode. Car will idle fine, but the issue is intermittent upon acceleration. Error code is p1775 Electric Oil Pump Hall IC Sensor Failure. Took it to a mechanic and they had performed a test on the sensor and pump and found no issues after stress testing and checking cabling. Issue occurred at mechanic when they tried to move the vehicle and suggest replacing the electric oil pump and sensor even though they found no issue the parts themselves without tearing down the mechanism. Car is undrivable because of this issue.

While I was driving on this day [XXX] all of a sudden my car started to shut down and I couldn’t give my vehicle any gas really. I got a hybrid system warning, and my red brake light came on, and I got indicator for me to check the brake. My brakes felt like they were grinding and hitting the ground. I managed to get my Kia into the dealership where the service manager, Jose looked at my car briefly. Of a visual inspection he said that the brake pads looked good, but your brakes are hitting the ground. He charged me a diagnosis. I told him to check to see if there are any recalls active, he said I do see a recall, but this doesn’t have anything to do with your car. The next day I heard from the service manager told me I have an update. I...

My Kia has the part number that was recalled for the ABS module. But Kia said it’s not included in the recall because of my vin. Appeared 2 months ago. All lights on & potential risk of fire according to the brake fluid leaking. So I have to park outside. Kia inspected & said it was ABS module that needed replacement. For $2,600. Which I can’t afford. I Have already spent $500 for the other problems they said it was at first. But it didn’t fix the problem. Now I am having to borrow cars to get to work.

My ABS module is failing with no open recall, even though Kia has issued multiple safety recalls (SC197, SC212, SC284) for this exact issue. My car is showing brake system errors (ABS, EPB, traction control, auto hold) and has stored codes like [insert your codes]. I’m concerned this is a serious safety hazard. If brake fluid has leaked into the module, there’s a known risk of electrical fire, even while parked. Kia has not included my VIN, but I believe it should be. Please investigate expanding the recall to include additional VINs. I’m requesting NHTSA to take this report seriously and hold Kia accountable for known safety defects in affected vehicles that are being ignored due to VIN limitations.

My engine locked ,

Car cuts off while driving almost causing a accident. The brakes randomly stop working while driving also. The code says P1777 relating to the transmission/ hybrid system. Kia dealerships are charging customers to diagnosis their vehicles. Eventhough they already know this is a common problem with the hybrid cars. Also the 12v battery and hybrid battery needs to be replaced every 2 years, which is costly. The tech also advised that Hybrids are the worst cars and I should sale my car. This is unfair to customers and a waste of money. Please make this a recall and extend all warranties past 150k. This is a huge safety problem and could cause deaths in the future.

I am leasing the 2013 Kia Optima LX through a 3rd party dealership that apparently stated in their terms and conditions that they are not responsible for doing maintenance on the car before being sold. I was on the road after getting gas when all of the sudden, the car started to slow down and my emergency check oil, engine, battery lights all came on. I was able to safely pull into a parking lot but after that, the car wouldn’t turn on. After trying to jump start the battery with another car, the engine started to smoke. We thought the alternator died. The third party dealership has their own maintenance shop and said it was alternator one day, then said it was engine the next and it manually can’t be turned over. That’s when they said because I didn’t get a software update, I didn’t have a warranty and...

When I turned the ignition on the car wouldn't start. But the ABS light and all other lights flickering when trying to start the car. The alarm kept going off. Passenger side front and rear windows won't function. Smell like something was burning. This is the second incident ([XXX]). Fuses had to be removed to silence the alarms on the first incident on [XXX] because the lights were still flickering on and off when car wasn't on. I had my car serviced at the West Broad Kia Dealership in Richmond, Va. Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased a 2013 Kia Optima EX from an on-line auction [XXX] in Memphis, Tn. After the car was delivered I noticed the vehicle engine had a slight engine knock. When I attempted to test drive the vehicle the engine knock grew louder, and the vehicle shut down in the middle of the road. I was fortunate enough to get the vehicle back to my residence where I was able inspect the engine, and noticed "Metal Dust" on the oil dipstick. Service records showed the vehicle had been serviced at the correct intervals, and the oil had been professionally been changed at correct intervals, and the vehicle appear to be in excellent condition. After doing some research I notice Kia had a recall for the "Theta Engine 2" for a rod bearing recall that was causing engine failure prematurely. I contacted Kia customer services on 11-20-24. I was told the...

The contact owned a 2013 Kia Optima. The contact stated while his husband was driving approximately 70 MPH and depressing the accelerator pedal, the vehicle failed to respond. The check engine warning light was illuminated. The contact stated that as the driver was pulling to the side of the road, several unknown warning lights were illuminated. Additionally, the contact stated that several drivers alerted the driver that the vehicle was on fire, and the driver immediately exited the vehicle. The contact stated that upon opening the hood, the driver saw flames, and the front end of the vehicle became engulfed in fire. The contact stated that the front end of the vehicle burned to the ground, and the front doors and the front windows sustained fire damage. The fire was extinguished by the fire department. The contact was unsure whether a fire department report was filed. A police report was...

Was driving down the highway with no indication of any problems with my car. It just shuts off completely had to coast to the side of the road get someone to tow me home. While on side of the road opened the hood and saw white smoke come from the engine. Just had an oil change and coolant is fine.

In May 2024, I took my 2013 Kia Optima (2.0L T-GDI) to my local dealership to have several recalls completed, including SC284QF (Hydraulic Electronic Control Unit). The dealership completed the recalls and I have a receipt showing all three recalls were completed. On Sep 12 2024 I received a recall notice stating the recall SC284QF had NOT been completed and to contact my dealership to schedule this recall repair. I looked up the Kia Safety Recall Campain instruction, detailing the repair step-by-step. I then went to my vehicle fuse panel (where the recall repair was to be performed) and was able to verify the recall has NOT been completed, despite the Kia dealership claiming (and documenting) the recall as being complete. This recall states that the risk of not competing this recall is potential engine fire while being driven or parked. I park this vehicle inside my garage (attached to...

Ran out of gas ,and added gas for it to start up again only for it to not run after adding fuel .

On 7/31, we had the HECU Fuse recall fixed at the Federico Kia Dealership. In 8/1, one day later, when driving the vehicle all of the car emergency lights came on, the engine started smoking and eventually caught fire. Fire department and police were called. Vehicle was toed to Kia Dealership. The next morning 8/2 we spoke with the service manager at the dealership, who was no help and gave us a 1-800 number to call Kia directly. Since this fire directly pertains to the part they “fixed” the day before during the recall, we believe the dealership did not fix the issue and believe something they “fixed” caused the issue as we have never had any prior issues with the engine.

KIA, in Clay New York, refuses to fix the recall on the bearing that caused my engine to cease, i did not know that my car had a recall because i was never notified! My car broke down as i was driving it, i had it towed to Kia, found out there were recalls, but the dealership will not honor the recall and fix my car.

While driving on the freeway I noticed my car wasnt going as I was pushing the gas and noticed all my dash lights were on like I was in accessory mode. I coasted to the edge of the freeway and decided to pop my hood and see if it was my battery cable that came loose. While waiting for traffic to break I noticed my hood looked alittle hazy like it was hot. When I was able to get out of my car I noticed black smoke coming from under the hood so I backed off and called 911.

The contact owns a 2013 Kia Optima. The contact stated that while her husband was turning off the vehicle, there was an abnormal clicking noise was detected. The window failed to roll down. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact was concerned of the vehicle catching on fire. The manufacturer was made aware of the issue. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The contact owns a 2013 Kia Optima. The contact stated that on several occasions while driving at various speeds or while parked, the electric windows, seats, sunroof, and radio failed to operate as needed. Additionally, when coolant was added to the coolant reservoir, the A/C unit blew warm air for 15 minutes before cooling down. The seat belt warning light was illuminated. The vehicle was taken to a car stereo store where it was diagnosed that the radio needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

The Engine has seized up on me after leaving work on Wed April 24,2024. I have not owned this car not even 2 months. Purchased it through California Motors Direct. I have spoken with the general manager of the dealership and and he said the car has been serviced mulitple times as at Carson KIA. My car does not run at all at the time my car was seized up on me I was driving a with my baby in the car and all of a sudden my car stopped and has not been working since that day. The dealership where I purchased the car refuses to look at it stating it isn’t there problem well there was safety recall and from what I have seen online they were not allowed to sell me a car that a big safety recall on it that has not yet been addressed. My...

Recall since September 2023 and Kia as of this date does not have the part even though recalls states that is urgent

The noted KIA 2013 KIA Optima has had this recall in effect since November 2023. KIA either refuses to say when the recall part is going to be at ANY DEALER, or puts an 'elevator music' soundtrack on the line. I have called numerous dealer's in both Maine, where the KIA is currently registered, and in Ohio / Pennsylvania to find if they know anything. None of the dealer's have any idea when the parts are coming, much less when they can call Owner's to set up a recall appointment. At what point does this end.

Car shutdown while driving

HECU REPLACEMENY UNTIMELY MANNER TO FIX

I have filed a complaint already with 2 agencies and I am continually being transferred from one site to another ! This is my very last complaint, before I file a complaint with my State Senator. ------------------- September 25, 2023 NHTSA CAMPAIGN NUMBER: [XXX] HECU May Cause Engine Compartment Fire An engine compartment fire while parked or driving can increase the risk of injury. NHTSA Campaign Number: [XXX] Manufacturer Kia America, Inc. Components SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected 1,730,192 Summary Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving. Remedy Owners are advised to park outside and away from structures until...

There is a dangerous recall on my vehicle put out by the maker of the vehicle and I called to schedule service for the vehicle . However no one is servicing my vehicle and they have no timeline on when they can remedy the issue . But I find it a serious matter that a symptom of this recall is a fire while driving or a fire while parked randomly . I need this remedied or car replaced asap to avoid damages or injuries !

Burning smell occasionally no warning light...maybe HECU?

My concerns is for the safety of my family as well as myself. I feel this recall is dangerous and it can happen at any given time. I believe that the manufactures of this vehicle had plenty of time to have this issue fixed. I really don't feel safe driving it, especially with my family.

Manufacturer hasn't provided a remedy to recall notice issued in September 2023. For something that has a chance of catching on fire driving or Parked this should've been taken care of along time ago instead of risking peoples lives dragging this out.

Electrical issue then engine leading to car going up in flames

I was driving up the [XXX] north and where [XXX] merges to [XXX] I'm going 65mph on the far left side, and my dash starts beeping and reads WARNING STOP VEHICLE CHECK BRAKES. MY brakes go out, pedal to the floor sounding like grinding gears and doing some major damage, my acceleration stopped working. The [XXX] is merging on the left side so i had to avoid major traffic. I am a driver with skill as i dodge slowed and stopped vehicles, and get to the shoulder before [XXX]. I call for roadside assistance because kia says its free and its not. I was looking around the engine to see what the heck and unplugged the hybrid fuse and battery from back and suddenly it worked again and drive it home and right before I park I made a right turn, and it started beeping again, and this time it...

I am concerned about my 2013 Kia Optima SX smoking at a mechanic shop. Mechanics identified smoke from the ABS Control Module or HECU. This raises serious safety concerns. I urge thorough investigation and prompt resolution. Clear communication is expected throughout the process to ensure vehicle safety and reliability.

the engine stop ruanning i got the code P1B96, P1B74, POA4C

In touch with 2 local dealers, one so far does not have the replacement part to resolve the recall on the hydraulic electronic control unit, one has yet to call me back to schedule for service. I am experiencing a burning/melting smell through my vents when the vehicle is not in motion.

My vehicles check engine light came on and I started feeling a lack of power in my car. Sluggish to accelerate. When the car was plugged in and diagnosed, it came up as the knock sensors. We had those replaced and the car ran fine for a few days but then it died out of nowhere. Check engine light came on again and it came up as knock sensors again. We had those replaced again and also had an oil change. Again… it was fine for a few days than started to knock… as I was driving the vehicle is completely seized on me. I almost went off a bridge because it didn’t allow me to press the breaks or anything. Brough it to the shop and they are saying the knock sensor popped up again but the engine is seized/blown. I was told this was not the first vehicle...

I bought my 2013 Kia optima ex from a private seller about half a year ago. I've had a few problems here and there that we're easily diagnosed and fixed. The radiator, alternator, starter, battery, serpentine belt, headlights, tail lights, licence plate light, tires, cabin air filter, and keyless start key fob have all been replaced. I just recently got my key fob(OEM) programmed by a licensed mechanic. The next day the car was perfectly fine. Ran smoothly and had no problems at all. I parked it and went to bed. Next day I get up early and start the car to warm up before I take my kids to the bus stop for school. It was between 5-7 minutes later and I went outside to the car and smelled an overwhelmingly strong plastic/chemical burning type smell coming from the car. I got in and saw that the air conditioning...

car stopped mid freeway 3 times engine light turned on engine started smoking took too dealer per the recall notice and they took 3 months could not fix and wanted to charge me 600 for changing a battery but car still will not run so they want payment for a car I must tow and has had over 5 recall notices ..at this point the car is unsafe I need remedy

MY 2013 KIA OPTIMA HAS A SAFETY HAZARD RECALL AND I WANT TO KNOW WHY IS KIA DRAGGING ITS FEET ON A POSSIBLE FIRE HAZARD ON A HECU FUSE.....SEEMS LIKE A SIMPLE FIX... BUT I AM [XXX] OLD AND CANNOT DRIVE MY CAR AND MUST PARK IT OUTSIDE IN THIS COLD WEATHER.....PLEASE NTSB LOOK INTO WHAT IS TAKING SO LONG FOR A SIMPLE FUSE REPLACEMENT.....THANK YOU INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On or around Oct.15th 2023, My abs light, engine light, and all these other lights came on. So i got it home i got a recall notice in the mail that day saying to park my car away from structures and other vehicles. So i had it towed to a kia dealer here in town. they had it for a week. they said they performed a diagnostic on it and replaced the recall part to come get it. So i go get it i drive off got a mile down the road and all the lights came on and said pull over and shut car off. So there iam on the side of the road calling a tow truck to tow my car back to the dealer. if they would have drove the car after fixing it they would experianced the all the lights lighting up on my dash. Now...

The car dealership i bought my kia from is fully aware of this safety recall, Should he have sold me the car with out telling me? Can I take this car back and get my money back?

in the middle of october around the 15th 2023 (HECU) hYDRAULIC electrical control unit light, the ABS light, the ENGIN light, and a couple of other unknown lights up and than my car tell me to pull over and shut down. you will have to tow it for inspection upon request due to all the warning light. my car had 117,000 document miles on it when i bought it, it now has 128,000. I paid cash for this car and it was my only means for my daughter and i to get to school work and with her dad in the hospital slowly still not out of the woods recovering throat cancer surgery patient. (ALL DOCUMENTED) on legal true facts statements dated sealed and signed documents for every statement stating true facts of this information that i am representing to you on December 1st 2023 My Neighbors, animals, property and...

NINE RECALLS FROM KIA AND VERY DANGEROUS. RIGHT WHEN I THINK KIA CANT GET ANY MORE DANGEROUS WITH 2013 KIA OPTIMA AND BEING UNLUCKY ENOUGH TO OWN THE WHITE PEARL MODEL WITH PAINT THAT IS DOWN TO THE METAL, LAST RECALL AIRBAGS, SEATBELTS ECT. THIS LETTER TAKES THE CAKE. OUR RECORDS SHOW YOUR VECHICLE IS AFFECTED WITH PART WE DO NOT HAVE YET BUT “ PARK YOUR VECHICLE OUTDOORS AND AWAY FROM STRUCTURS AND OTHER VECHICLES CAR ENGINE CAN CATCH FIRE DRIVING OR PARKED. SHOOT FORGET ABOUT US IT GOES ON TO SAY IF YOU BURNING MELTING SMELL WHILE DRIVING PULL OVER AND REMOVE KEY EXIT CAR TO SAFE LOCATION..WELL KIA THANKS FOR THE HEADS-UP HOPE WE MAKE IT OUT OF CAR AND WOW YOU WILL SEND LETTER WHEN PART COMES IN..TERRIFYING LETTER BUT, LOVE THAT YOU CARE MORE ABOUT PARKING AWAY FROM STRUTURES, OTHER VECHICLES OUTDOORS UNTIL YOU CAN...

My car is a total lost. Car caught fire while I was driving with my 2 Daughters. Brakes went out had to jump out of car.

When going over bumpy roads, turning right or leaning on the driver side door the car thinks it’s open and lights come on

While driving the EPS light comes on and after that the dash board stops working to wear you're not able to see the speed limit anymore. It also declines the car of any speed. And if you put it in park it won't allow you to shift out of that gear. Dealership said its the HECU.

1. Vehicle refuse to start had to have it towed to a shop to have a new battery placed in 2. Replacement of battery caused a short in stereo system resulting in the replacement with a new stereo system 3. Engine began to knock 12/19/22 took car to Car-Mart was given a list of mechanics to call made an appointment with Dominion in Farmington Arkansas for the morning of December 21st 4. Car decelerated and check engine light came on just before Exit 70 on I-49 near Johnson Mill Boulevard pulled over to the side of the interstate was able to move the vehicle forward to Exit 70 at 20 miles per hour to get off the interstate and park at Casey's General Store on Don Tyson Parkway in Springdale 5. Car was towed to Dominion Auto in Farmington Arkansas 6. I was not informed of any recall on my...

I have been having electrical/lighting issues for about a year. It initially started with the inside lights intermittently flashing when opening the door or attempting to use the interior lights; however sometimes the automatic interior lights did not come on at all when set to automatically turn on when a door opened, but now the lights don’t come on at all when opening the door. I have also had some headlight and dashboard lights going on and off while driving. I have experienced this on at least 3 occasions since last June or July. I have done some of my own testing by switching the lights to different functions, on and off, etc. Because it has only happened 3 times I’m not sure exactly what the issue is and scared that at some point, they won’t work at all. This is very concerning and obviously a safety issue. In addition,...