2011 KIA OPTIMA Fuelpropulsion System Problems

As I would drive the vehicle a rattling noise would occur when every time I accelerate from stopping at a traffic light. Then the engine light appeared on the dash board. When I went to have the engine light checked the results came back about an oil gasket. I then got an oil change soon after. The rattling noise and the same acceleration problem still occurred. Soon after it gotten worst to the point couldn’t go faster then 10 mph and then the car kept shutting off.

While driving our 2011 Kia Optima on I-185 at highway speed, the vehicle suddenly had unresponsive accelerator and had decrease in power. Gauges were all normal range, no warning or indicator lights illuminated. I pulled over to the highway shoulder to clear traffic and placed car in park. Immediately light gray, then black smoke poured out from the hood. My wife and I evacuated the Kia just before the front of the vehicle was engulfed in flames. The engine had been replaced in Sept 2021 due to a previous recall, and up to this incident the Kia performed within normal parameters.

I have been getting a whiff of gas when I would drive it’s but recently it has been worse and my check engine light has showed up and the code for it says that it could be the fuel filter.

I WAS DRIVING MY CAR ON A HIGHWAY AT TRAFFIC TIME WHEN I NOTICED A SMALL GAS ODOR MY BRAKES GOT REALLY HARD AFTER THAT I PULLED TO THE EMERGENCY LANE AND WHEN I PULL THE HANDLE TO OPEN MY HOOD SMOKE AND FLAMES IMMEDIATELY CAME OUT, THE CAR ITS TRASH NOW POLICE TOOK IT TO IMPOUND BECAUSE OF THE FLUIDS THE CAR WAS LEAKING AND SAFETY ISSUES.

WHEN I GO TO FILL UP WITH FUEL IT WON'T ALLOW ME TO PUMP BUT VERY LITTLE FUEL BEFORE IT SPILLS OUT. I HAVE TO PUT VERY LITTLE IN AT A TIME BEFORE THE PUMP CLICKS OFF. I HAVEN'T BEEN ABLE TO COMPLETELY FILL UP MY TANK SINCE MAY WITHOUT IT TAKING 45 MINS OR SO AND IT SPILLING OUT. I WAS PARKED AT THE GAS STATION WHEN THIS HAPPENED, WITH THE CAR OFF.

LO QU PASA ESQ EL CARRO TIRA GASOLINA Y LO EMOS ARREGLADO 4 VESES Y TIRA TODA LA GASOLINA YA ISIMOS UN RECLAMO Y NOS NOS QUIEREN DAR NINGUNA COMPENSACIN LO QUE ASE ES QUE SE LE TIRA LA GASOLINA Y TENGO MIEDO QUE SE YEGUE A QUEMAR PORQUE CADA VEZ QUE LE A PASADO SOLO EMPIEZA A TIRAR GASOLINA NO IMPORTA SI EST PARADO A CONDUCIENDO LA LTIMA VEZ QU PAS LO ESTBAMOS CONDUCIENDO Y ME PERCAT Y ME REGRESE Y LO TENGO EN MI CASA Y YA NO LO EH VUELTO A MOVER PORQUE TENGO MIEDO QUE SE QUEME ESTOY ENVIANDO UNA FOTO DE LA MANGUERA UN VIDEO DE QUE ES LO Q LE PASA TENGO UN VIDEO DE PERO NO LO PUDE ENVIAR .

THE FUEL INJECTOR REQUIRED REPLACEMENT. THE CAR SPUTTERED AND CAME TO A COMPLETE STOP WITHOUT WARNING. IT SPUTTERED WHILE DRIVING ON THE HIGHWAY; IT CAME TO A COMPLETE STOP AT THE MOMENT THAT I MOVED ONTO THE EXIT RAMP. THE DEALERSHIP PERFORMED A FULL DIAGNOSTIC AND REPORTED THAT THE FUEL INJECTOR REQUIRED REPLACEMENT. WHILE REPAIRING THE INJECTOR, THE MECHANIC REPORTED THAT THE CATALYTIC CONVERTER WAS DAMAGED DUE TO THE INJECTOR LEAKING AND CLOGGING THE CONVERTER. NO CODES ALERTED MYSELF, OR THE MECHANIC TO THESE ISSUES. THE MECHANIC REPORTED THAT NEITHER ISSUE WAS COVERED UNDER THE ENGINE RECALL. *TR

MY CAR HAVE LOT OF PROBLEMS IN SIDE

HI MY CAR HAS LOT OF SAFETY ISSUES.. I TOOK MANY TIMES TO KIA DEALER IN JERSEY CITY MY CAR DOOR GETS UNLOCKED WHILE IT'S IN DRIVING MODE WHICH MAKES ME FEEL UNSAFE I TOLD SO MANY TIMES TO THE DEALERS TO FIX IT THEY DO SOME TEMPORARY THINGS IN MY CAR AND THEY LIVE ME BUT AGAIN AFTER SOME DAYS THAT PROBLEM IS ARISING AGAIN... I AM FED UP WITH THIS SITUATION AS I AM THE SECOND OWNER OF THE CAR...

DRIVING ON INTERSTATE, OUT OF NOWHERE ENGINE LIGHT STARTED FLASHING AND ENGINE SEIZED, CAR LOST ALL MOMENTUM, HAD NO "GET UP AND GO" PUSHING ON THE GAS PEDAL DID NOTHING, GOING UP HILL WAS ALMOST IMPOSSIBLE. TOOK CAR TO LOCAL AUTO SHOP, THEY COULD HEAR SOME NOISE BUT WEREN'T SURE WHAT. PER INVOICE 7/26/19: CHECKED CODES: P0011 A CAMSHAFT POSITION TIMING OVER ADVANCED, P00114 B CAMSHAFT POSITION TIMING OVER ADVANCED; P1326 ENGINE DAMAGE ALERT FOR DRIVER. ENGINE WAS NOISEY AND RAN VERY ROUGH, OIL LEVEL WAS LOW AND BLACK (WE SAW NOWHERE THAT IT WAS LEAKING OIL, NO SPOTS ANYWHERE). CHANGED OIL AND ADD LUCAS ENGINE STABILIZER, ENGINE QUIETED AND RUNS MUCH SMOOTHER. CLEAR CODES, TEST DRIVE, WATCH SCAN DATA. NO CODES, POSSIBLE EARLY STAGES OF ENGINE DAMAGE IF CODES RETURN INSPECT TIMING CHAIN AND CONTROL DEVICES. TOOK CAR HOME OVER THE WEEKEND DROVE LESS THAN 50 MILES, SUNDAY 7/28/19...

BOUGHT THE CAR JANUARY OF 2018.28 DAYS OF HAVING THE VEHICLE AND I GOT A FLAT TIRE AND COME TO FIND OUT MY STRUT WAS NEVER PROPERLY INSTALLED AND THATS WHAT POPPED MY TIRE.DAN OBRIEN TRIED TO DENY HAVING A WARRANTY TO FIX THE CAR SAYING IT WAS MY FAULT.IT WAS COVERED UNDER WARRANTY. I HAD TO BUY THE NEW TIRE. WHEN THE RECALL FOR THE ENGINE CAME OUT,I TOOK MY CAR RIGHT IN. THEY PASSED IT. IN SEPTEMBER WHILE DRIVING HOME FROM MY DAUGHTERS 2 MONTH APPOINTMENT THE CAR JUST LOST ALL POWER AND MY ENGINE LIGHT CAME ON & CAR WOULD NOT START DAUGHTER WAS PRESENT.ENGINE HAD LOCKED UP THEY REPLACED THE LONG BLOCK UNDER THE SC147 RECALL 11/30/18 RECALL SC165, ECU UPGRADE. ON 2/11/19 I HAD THE INSPECTION FOR RECALL SC172 CAR PASSED.3/21/19 NO WARNING ENGINE LIGHT CAME ON & STAYED.P1326 ENGINE CODE CAR WENT INTO LIMP...

LEAKING OIL , STRUTS MAKING NOISE.

TAKATA RECALL I WAS DRIVING ABOUT 65MPH ON I-95 SOUTH BACK HOME TO FL FROM VISITING MY FAMILY IN SC WHEN I STARTED TO SMELL GASOLINE FUMES IN MY MOVING VEHICLE. I WOKE MY GIRLFRIEND UP AND ASKED IF SHE SMELT IT AS WELL. SHE STATED 'YEAH, I CAN SMELL GAS A LITTLE BIT.' THEN I ROLLED THE WINDOW DOWN AND THE SMELL BECAME EXTREMELY STRONG. I STARTED TO FEEL LIGHT HEADED AND TOOK THE IMMEDIATE EXIT (EXIT 33). I PULLED INTO AN EXXON STATION AND PARKED MY VEHICLE. I OPENED THE HOOD OF MY 2011 KIA OPTIMA EX AND NOTICED GAS SPRAYING ALL OVER THE ENGINE BAY FROM THE BOTTOM OF THE HIGH-PRESSURE FUEL LINE WHERE THE BOLT CONNECTS. I IMMEDIATELY SHUT MY CAR OFF. I FILLED MY GAS TANK TO FULL BEFORE LEAVING MY BROTHERS APARTMENT AND MY FUEL WAS NOW AT HALF A TANK. I DROVE 57.5...

ENGINE FAILURE..BOUGHT IN 2013 W 14,000 MILES.CURRENTLY HAS 68,000.CHECK ENGINE LIGHT CAME ON LAST YEAR.KIA WOULD ONLY PAY FOR 1 SPARK PLUG.THEN,L PAID TO HAVE A NEW FI SYSTEM PUT IN.L WAS NEVER REIMBURSED.DEC 20,DRIVING DOWN A BUSY HIGHWAY W MY KIDS AND ENGINE SHUTS OFF WITH NO WARNING.THEN,THE CHECK ENGINE LIGHT CAME ON ALONG WITH WEIRD SMELLS OF GAS AND BURNING.TOOK IT TO THE DEALER AND NO ISSUE.TOOK IT BACK AGAIN ON DEC 21,BUT NO TECHS AVAILABLE.DEC 23,L WAS DRIVING MY KID TO WORK,ENGINE SHOOK,CHECK ENGINE LIGHT CAME ON FLASHED AND A BIG BOOM.CAR WAS GOING 5MPH WHILE IT WAS CLICKING.L GOT IT TOWED(AFTER KIA MOTORS HAD THE AUDACITY TO TRY TO MAKE ME PAY FOR A [email protected],BUT L REFUSED)THRU MY INSURANCE CO.AS THE CAR SAT,A BIG CLOUD OF SMOKE CAME FROM THE ENGINE,WE THOUGH THAT IT WAS CATCHING ON FIRE.CALLED KIA MOTORS....OMG,THE WORST.L JUST GOT A RENTAL TODAY...

EVERY TIME I STOP TO PUT GAS IN MY CAR, IT TAKES ABOUT 30 MINUTES OR SO BEFORE IT STARTS AGAIN. WHILE DRIVING, THE CAR HAS A JERKING MOTION. KIA EXCHANGED THE CARBON CANISTER BUT IT DIDN'T FIX THE PROBLEM.

STRONG SMELL OF RAW FUEL NEAR LEFT REAR (DRIVER SIDE) OF VEHICLE WHEN AMBIENT TEMPERATURE OUTSIDE EXCEEDS 100 DEGREES. THE SMELL IS NOTICED WHEN THE VEHICLE IS PARKED AFTER DRIVING. IT WAS FIRST NOTICED WHEN THE VEHICLE HAD ABOUT 50,000 MILES ON IT AND THE VEHICLE WAS TAKEN TO HENDERSON KIA FOR SERVICING. THEY SAID THEY COULD NOT REPRODUCE THE ISSUE.

MOTOR OIL KEEPS DISAPPEARING; I CHANGE THE OIL ON SCHEDULE AND 2-3 WEEKS AFTER IT IS DRY. I'M AFRAID OF ENGINE FAILURE OR LOCK UP DUE TO THIS. RAISING THE HOOD DOES NOT SHOW ANY OIL SPLATTER. ELECTRICAL PROBLEMS; LNTERIOR LIGHTS KEEP GOING OUT OR GO COMPLETELY DIM.

BEGINNING IN SPRING 2017 MY 2011 KIA OPTIMA EX TURBO (I BOUGHT IT BRAND NEW, ONLY OWNER) BEGAN STUTTERING WHILE IN MOTION (AS IF SOMEONE WERE PUMPING THE BRAKES). THE CAR STALLS AND DIES AT RED LIGHTS AND STOP SIGNS AND NEEDS RESTARTED. IT ALSO STALLS AND DIES WHILE IN MOTION, MOST DISTURBING IN HIGH SPEED, HIGH TRAFFIC INTERSECTIONS AND AT 70 MPH HIGHWAY SPEEDS. I WILL BE TRAVELING ON HIGH SPEED INTERSTATES AND THE CAR JUST DIES AND I HAVE TO HOPE I HAVE ENOUGH MOMENTUM TO SAFELY GET OVER TO THE BREAKDOWN LANE WITHOUT CAUSING AN ACCIDENT. THE CHECK ENGINE LIGHT USUALLY GOES ON AND OFF AT LEAST FOUR TIMES IN BETWEEN EACH SERVICE ATTEMPT. IT HAS BEEN ANALYZED AND GIVEN ATTEMPTED REPAIRS BY A KIA DEALERSHIP FOUR TIMES SINCE LATE MAY 2017 (SEE ATTACHED RECORDS), BUT THE STALLING AND STUTTERING PROBLEMS PERSIST. I PICKED UP THE CAR...

CAR CAUGHT FIRE FROM THE ENGINE BAY WHILE DRIVING ON HIGHWAY AND HAS BEEN ENTIRELY BURNED OUT IN 5 MINUTES.

TAKATA RECALL AS SOON AS I TURN THE KEY THE AIRBAG LIGHT SHOWS UP, STEADY. IT IS ON ALL THE TIME, WHETHER I AM STATIONARY OR IN MOTION. I HAVE NO IDEA IF THE AIRBAGS EVEN WORK. THERE ARE ALSO ISSUES WITH THE ELECTRICAL SYSTEM AS THE DOOR OFTEN UNLOCKS ON ITS OWN, ALARM GOES OFF ON IT'S OWN, LIGHTS FLASH INSIDE EVERY TIME I MAKE A TURN, LEFT OR RIGHT AND THE RADIO SPAZZES OUT

I HAVE A CHECK ENGINE LIGHT ON THE CAR. THE FOUND OUT THAT IS RELATED TO ENGINE TIMING ISSUE. WHICH IS STRANGE THAT A CAR WITH ONLY 60K MILES WOULD HAVE ENGINE RELATED ISSUES. I HAVE ALSO HAD SEVERAL ISSUES WITH CHECK ENGINE LIGHTS THIS PAST YEAR. I HAVE ALSO HEARD THAT THE ENGINE IN MY CAR WAS USED IN OTHER HYUNDAI MODELS AND MAY HAVE BEEN RECALLED. PLEASE INVESTIGATE ISSUE AND RESPOND BACK