2005 KEYSTONE RAPTOR — Problems, Recalls & Safety Data
N/A
Safety Rating
6
Owner Complaints
2
Recalls
0
Service Bulletins
0
Investigations
Overview of the 2005 KEYSTONE RAPTOR
The 2005 KEYSTONE RAPTOR has received a total of 6 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 2 recall campaigns affecting this vehicle, covering issues with EQUIPMENT, EQUIPMENT:RECREATIONAL VEHICLE/TRAILER. The most commonly reported problems involve the Tires (3 complaints), Power Trainaxle Assembly (1 complaint), and Structureframe And Members (1 complaint).
Recalls for the 2005 KEYSTONE RAPTOR
NHTSA has recorded 2 recalls for the 2005 KEYSTONE RAPTOR, potentially affecting up to 1,215,483 vehicles.
Recall 17V755000 — EQUIPMENT
| 1,205,997 vehicles affected
Defect: Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain...
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540,...
View full details →Recall 06V192000 — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
| 9,486 vehicles affected
Defect: ON CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH A 9 VOLT BATTERY OPERATED CARBON MONOXIDE (CO) DETECTOR, IF THE BATTERY IN THE DETECTOR GOES DEAD OR IS REMOVED, THE DETECTOR WILL NOT FUNCTION AND THEREFORE CAN NOT WARN THE OCCUPANTS IF CO REACHES A HARMFUL LEVEL.
Consequence: IF CO REACHES A HARMFUL LEVEL, SERIOUS ILLNESS OR DEATH COULD RESULT TO THE OCCUPANTS.
Remedy: DEALERS WILL INSTALL A HARD WIRED 12 VOLT CO DETECTORS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT KEYSTONE AT 866-425-4369.
View full details →Owner Complaints for the 2005 KEYSTONE RAPTOR
6 complaints have been filed with NHTSA for the 2005 KEYSTONE RAPTOR. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Tires | 3 | 0 | 0 | 0 | 0 |
| Power Trainaxle Assembly | 1 | 1 | 0 | 0 | 0 |
| Structureframe And Members | 1 | 0 | 0 | 0 | 0 |
| Suspensionfrontspringsleaf Spring Assemblyhangerbracket | 1 | 1 | 0 | 0 | 0 |
Most Recent Complaints
TL*THE CONTACT OWNS A 2005 KEYSTONE RAPTOR. THE CONTACT NOTICED THAT THE OUTSIDE WALL WAS SEPARATING FROM THE BOTTOM OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN RV MECHANIC, WHO STATED THAT THE FRAME FAILED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE FAILURE HAS BEEN OCCURRING EVER SINCE THE VEHICLE WAS PURCHASED. THE FAILURE MILEAGE WAS UNKNOWN.
CARLISLE TIRE(225X75X15) ON MIDDLE AXLE ON KEYSTONE RAPTOR SEPARATED, LOOKED AS IF STEEL BELT HAD CUT INTO SIDEWALL AS A DEFECT. TIRE IMMEDIATELY SHREDDED AND DAMAGED THE RIM AND THE TIRES ON BOTH AXLES AROUND IT. ALSO DAMAGED AREA UNDER WHEEL AS WELL AS FENDER. CARLISLE WAS CONTACTED AND DENIED ANY WARRANTY AS TIRES WERE 2 YEARS OLD IN APRIL AND THIS HAPPENED IN JULY. THEY REFUSED TO ACCEPT ANY RESPONSIBILITY FOR HIGH FAILURE RATE OF RV TRAILER TIRES. *JB
TL*THE CONTACT OWNS 2005 KEYSTONE RAPTOR TRAILER WITH MISSION TIRES SIZE ST2257515. WHILE DRIVING 65 MPH SHE EXPERIENCED BLOW OUTS ON THE TWO FRONT AND REAR TIRES. THERE WAS NO SIGN OF WEAR AND TEAR. THE TIRES WERE REPLACED WITH THE SAME BRAND AND SIZE. THE ENGINE SIZE, NUMBER OF CYLINDERS, POWER TRAIN, AND FUEL SYSTEM INFORMATION WAS NOT APPLICABLE. THE FAILURE MILEAGE WAS 2,500.
I HAVE A 2005 KEYSTONE RAPTOR TOY HAULER TRAILER (3612DS) WITH 15" MISSION "D" RATED TIRES ON THEM. I HAVE HAD 4 BLOWOUTS IN THE LAST 6 MONTHS. THE TIRES BLOWOUTS HAVE CAUSED DAMAGE TO THE UNDER-CARRIAGE OF MY TRAILER. TWO OF THE BLOWOUTS OCCURRED ON ONE TRIP WHILE I WAS NOT CARRYING ANY CARGO IN THE REAR AT ALL. THE OTHER TWO TIMES WERE WHILE I WAS CARRYING TWO FULL SIZE QUADS (THUS, THE WEIGHT WAS NOT AN ISSUE). THESE TIRES ARE JUNK AND SHOULD NOT BE ALLOWED ON LARGER RIGS. LARGE RIGS SHOULD BE MANDATED TO HAVE 16" STEEL BELTED, COMMERCIAL TIRES. THESE TIRE BLOWOUTS COULD CAUSE SERIOUS INJURIES OR EVEN DEATH. *JB
THE UNIT I PURCHASED FROM ORANGEWOOD RV IN SURPRISE, AZ. LAST YEAR,WAS DEFECTIVE AND CAUSED CONSIDERABLE DAMAGE TO OUR TOW VEHICLE AND UNIT. THIS WAS CAUSED AS A DIRECT RESULT OF A MANUFACTURER DEFECT IN THE 3 AXLES ON THE RIGHT/PASSENGER SIDE OF OUR RAPTOR-MODEL, WERE INSTALLED, 2 1/2 INCHES OFF-CENTER, WHICH CREATED DAMAGE TO VEHICLE, AS THE REAR END OF THE UNIT WAS OVER THE TRAFFIC LINE, AT TIMES AS MUCH AS 8-12 INCHES, AND SUSTAINED DAMAGE TO THE ROOF AND WAS AN EXCESSIVE STRAIN AND DAMAGE TO THE TOW VEHICLE, THAT IT REQUIRED EXTENSIVE REPAIR AND IMPROVEMENTS, AS THEY FRAUDULENTLY LED ME TO BELIEVE, I COULD TOW THE VEHICLE SAFELY, WITH THE VEHICLE I OWNED, WITHOUT ANY MODIFICATIONS OR IMPROVEMENTS NECESSARY, WHICH WAS NOT TRUE, AS I SOON LEARNED. ALL OF THIS COMBINED, RESULTED IN OVER $25,000.00 IN DAMAGES TO THE UNIT IT'S SELF AND THE TOW VEHICLE. I WONDER HOW MANY OTHER UNITS CAME OUT OF THE FACTORY IN THE SAME DEPLORABLE SHAPE??? R.G. MARKS. *JB
Safety Rating for the 2005 KEYSTONE RAPTOR
NHTSA has not yet tested the 2005 KEYSTONE RAPTOR in its New Car Assessment Program.
Technical Service Bulletins for the 2005 KEYSTONE RAPTOR
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2005 KEYSTONE RAPTOR
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the KEYSTONE RAPTOR
- 2004 KEYSTONE RAPTOR — 0 complaints
- 2005 KEYSTONE RAPTOR (current)
- 2006 KEYSTONE RAPTOR — 5 complaints
- 2007 KEYSTONE RAPTOR — 9 complaints
- 2008 KEYSTONE RAPTOR — 7 complaints
- 2009 KEYSTONE RAPTOR — 7 complaints
- 2010 KEYSTONE RAPTOR — 2 complaints
Other KEYSTONE Models
- KEYSTONE COUGAR — 194 total complaints
- KEYSTONE MONTANA — 186 total complaints
- KEYSTONE SPRINGDALE — 68 total complaints
- KEYSTONE ALPINE — 65 total complaints
- KEYSTONE OUTBACK — 58 total complaints
- KEYSTONE FUZION — 56 total complaints
- KEYSTONE SPRINTER — 56 total complaints
- KEYSTONE LAREDO — 39 total complaints