1999 JEEP WRANGLER Electrical System Problems

FUEL- JEEP HARD TO FILL WITH FUEL OR MUST FILL FUEL AT VERY SLOW RATE. NOZZLE DOES NOT LOCK OR FILL PROPERLY. (STATIONARY) ELECTRICAL- HAZARD LIGHTS(IN REAR) RANDOMLY TURN ON BY THEMSELVES WHILE DRIVING. (ANY MPH, CITY STREETS AND HIGHWAYS)

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 50 MPH OVER A BUMP IN THE ROAD, THE BLOWER MOTOR FAILED TO FUNCTION. THE INSTRUMENT PANEL WARNING INDICATORS ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING VARIOUS SPEEDS, THE ODOMETER BACK LIGHT SEIZED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE OCCURRED PREVIOUSLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 99V117000 (UNKNOWN OR OTHER). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING OVER A BUMP AT 35 MPH, THE INSTRUMENT CLUSTER FAILED TO FUNCTION. THE CONTACT HAD TO HIT THE CONSOLE BEFORE THE CLUSTER ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT UPON INITIAL START-UP, THE INSTRUMENT PANEL FAILED AND WOULD NOT ILLUMINATE. THE FAILURE WAS RECURRING. THE CONTACT WOULD TURN THE ENGINE OFF AND ONCE RESTARTED, THE FAILURE WOULD SPORADICALLY RESET. ADDITIONALLY, THE VEHICLE STALLED MORE THAN FIVE TIMES WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED BY AN AUTHORIZED DEALER. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 99V117000 (INSTRUMENT PANEL SCREWS) BUT HAD EXPERIENCED THE FAILURE MULTIPLE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

I WAS DRIVING AN OLD WASHED OUT AND BUMPY MOUNTAIN ROAD. DUE TO THE BUMPS, I COULD NOT GO MUCH FASTER THAN 15MPH. THE ROAD/GROUND WAS WET AND SLIPPERY SO I WAS IN 4HI. AFTER GOING DOWN THE ROAD FOR ABOUT 30 MINUTES AND GOING AROUND A TURN, THE AIRBAG LIGHT CAME ON. AS I TURNED THE WHEEL IN THE OPPOSITE DIRECTION, TO GO AROUND A LARGE DOWNED TREE, IT MOMENTARILY SHUT OFF, THEN RETURNED TO ON. I IMMEDIATELY TURNED THE JEEP OFF AND CHECKED THE AIRBAG FUSES. BOTH ARE GOOD. PUZZLED AND RATHER NERVOUS THAT THE AIRBAG MIGHT GO OFF IN MY FACE, I TURNED AROUND TO GO BACK TO THE MAIN ROAD. AFTER NERVOUSLY DRIVING A FEW MILES DOWN THE ROAD, I RETURNED THE JEEP TO THE SPEED LIMIT AND ATTEMPTED TO ENGAGE MY CRUISE CONTROL BUT, THE LIGHT WOULDN'T TURN ON. I TRIED ALL THE CRUISE CONTROL...

EVER SINCE I PURCHASED THE JEEP, IT HAS BEEN A RELIABLE VEHICLE. THE OTHER DAY, I WENT TO START IT AND THE INSTRUMENT CLUSTER WAS UNRESPONSIVE AND THE AIRBAG LIGHT WAS ON. I TRIED REPLACING THE FUSE AND FOUND IT TO BE GOOD, RECEIVING POWER. I STARTED TO CHECK WEBSITES FOR SIMILAR PROBLEMS AND FOUND A RECALL FOR THE EXACT PROBLEM I WAS HAVING. THIS RECALL DESCRIBED EXACTLY WHAT WAS HAPPENING TO MY JEEP. THE RECALL IS FOUND HERE RECALL 99V117000: INSTRUMENT PANEL GROUND SCREWS LOOSE THE LEFT SIDE AND RIGHT SIDE INSTRUMENT PANEL WIRING GROUND ATTACHMENT SCREWS COULD LOOSEN OVER TIME. IF THE LEFT SIDE SCREW LOOSENS, THE INSTRUMENT PANEL GAUGES MAY NOT FUNCTION WHEN THE HEADLAMPS ARE TURNED ON. IF THE RIGHT SIDE SCREW LOOSENS, THE DEFROSTER BLOWER MOTOR MAY NOT FUNCTION. WELL, I TOOK A COPY OF THE RECALL TO MY LOCAL JEEP DEALERSHIP, BLUEBONNET JEEP IN...

MY JEEP LOST ALL POWER TO THE CONSOLE/DASH DURING NIGHT DRIVING AND I COULD NOT MEASURE MY SPEED, RPMS, FUEL OR ANY OTHER GAUGES. THIS INCLUDED BOTH THE ANALOG (NEEDLE) AND DIGITAL (LED) GAUGES. MY 5-SPEED DROVE FINE THOUGH, NO SWEAT. SO THERE I WAS, DRIVING DOWN THE ROAD, AND I HAD NO WAY TO ASCERTAIN MY VELOCITY. THERE WAS NO WAY TO TELL IF I WAS GOING 20 MPH OR 120 MPH. IT WAS JUST ME, MY JEEP AND MY GUT INSTINCTS. SO, I PULLED A FONZIE AND SMACKED THE DASH, AND GAVE IT MY BEST "HEYYYYYYYY" AND YOU GUESSED IT - AFTER THAT ALL WAS WELL. THE LIGHTS CAME BACK AND I WAS DOING A COOL 60. BECAUSE I CAN'T DRIVE 55. AFTER A LITTLE INTERNET WIZARDRY ON MY FAVORITE SEARCH ENGINE, APPARENTLY THIS IS SIMPLY A LOOSE CONNECTION FROM THE DASH GROUND. BEING A JEEP OWNER, I...

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED, ALL OF THE GAUGES ON THE INSTRUMENT PANEL WOULD DECREASE TO ZERO AND THE CHECK ENGINE WARNING LIGHT WOULD ILLUMINATE INTERMITTENTLY. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE HAD NOT BEEN INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 116,251 AND THE APPROXIMATE FAILURE MILEAGE WAS 114,000. UPDATED 11/02/2011 *LN *TR

AIRBAG CONTROL MODULE FAILS. CAUSES GAUGES IN DASHBOARD NOT TO WORK PROPERLY. GAUGES WILL NOT READ OIL PRESSURE, SPEED, ETC. AIRBAG LIGHT COMES ON. *KB

A WHILE AGO I HAD THE CLIMATE CONTROLS GO OUT IN MY 1999 JEEP WRANGLER. UPON INVESTIGATION, I FOUND THAT THE WIRING HARNESS CONNECTOR AND THE CLIMATE CONTROLS HAD MELTED DUE TO THE HEAT GENERATED FROM THE ELECTRICAL CONNECTION. I REPLACED THE CLIMATE CONTROLS IN MY JEEP, HOWEVER, THE ELECTRICAL WIRING STILL GETS VERY HOT. I DID SOME CHECKING IN JEEP FORUMS AND APPARENTLY, THIS IS A COMMON OCCURRENCE IN THE "TJ" JEEP MODEL. I AM ENCLOSING A LINK TO AN ARTICLE THAT ADDRESSES THIS ISSUE, IN IT THE AUTHORS DETERMINED THAT THE UNCORRECTED WIRING CAN REACH 122 DEGREES. HTTP://WWW.JPMAGAZINE.COM/TECHARTICLES/ELECTRICAL/154_0710_JEEP_FIRE_PREVENTION/INDEX.HTML. *TR

TL*THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE TRAVELING 50 MPH, THE CONTACT NOTICED WHEN DRIVING OVER A BUMP, ALL WARNING LIGHTS WOULD APPEAR ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 99V117000 (UNKNOWN OR OTHER). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 128,000. UPDATED 12/30/10. *LJ THE CONSUMER ALSO STATED THE AIR BAG LIGHT ILLUMINATED. UPDATED 01/04/11.*JB

SINCE I HAVE OWNED MY 99 WRANGLER, ABOUT EVERY TWO YEARS. THE FAN MOTOR OR SELECTOR SWITCHES HAVE BURNED OUT. THE LAST TIME IT HAPPENED IT METED DOWN THE WIRING HARNESS AS WELL. IT IS MY FEELING THAT THIS IS A SERIOUS PROBLEM THAT JEEP IS AWARE OF. SINCE THEY HAVE A SPECIAL BULLETIN THAT ALLOWS YOU TO BUY THE SWITCHES INDIVIDUALLY, INSTEAD OF THE ENTIRE HEATING COOLING HEAD UNIT. *TR

1ST ISSUE: THE DASH GAUGES WILL GO OFF AND ON INTERMITTENTLY. I HAVE FOUGHT WITH THIS PROBLEM FOR YEARS NOW. THE DEALER OF COURSE DOESN'T KNOW WHAT I'M TALKING ABOUT. NEVER HEARD OF IT. I HAVE COMPLETELY REMOVED THE DASH LOOKING FOR PROBLEMS. BAD GROUNDS? I CAN'T TELL WHERE. I SUSPECT THE PLUGS THE CLUSTER SLIPS INTO. I'VE TRIED TO PULL THE MOUNTS CLOSER FOR A BETTER CONNECTION. IT SEAMED TO WORK FOR A WHILE. THEN IT COMES BACK. A GOOD SOUND BEATING ON THE DASH BRINGS THEM BACK ON. AMAZING WHAT THAT PLASTIC WILL TAKE. ALL THIS STARTED AFTER THE WARRANTY EXPIRED. I REFUSE TO TAKE IT IN AND POUR MONEY AT IT TILL THEY FIGURE IT OUT. ALL I WANT IS TO KNOW HOW TO FIX THE GAUGES. I'M ABOUT READY TO CUT THE WIRES AND SOLDER THEM DIRECTLY ON. 2ND ISSUE: I BEGAN SMELLING PLASTIC BURNING OR...

TL*THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT THE SPEEDOMETER, FUEL GAUGE, ODOMETER, TEMPERATURE GAUGE, AND OIL GAUGES WERE INOPERABLE. ALSO, THE HEAT AND AIR CONDITIONING WORKED INTERMITTENTLY ON THE HIGH SETTING. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V117000 (UNKNOWN OR OTHER). THE CURRENT MILEAGE WAS 121,000 AND FAILURE MILEAGE WAS 76,000.

1999 JEEP WRANGLER WITH GROUND WIRE PROBLEMS **ANSWERED BY RIC WILLARD** CC THE RECALL WAS 99V117000. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL. AFTER THE REPAIRS THE PROBLEM PERSISTED. THE CONSUMER REACHED BEHIND THE CLUSTER AND WHEN HE PUSHED ON ONE OF THE PLUGS THEY MOVED ABOUT AN EIGHTH OF AN INCH. THE CONSUMER THEN HEARD THE LATCHED SNAP INTO POSITION AND HE HASN'T HAD A PROBLEM SINCE. THE HEATER ALSO HAD A PROBLEM THAT THE CONSUMER THOUGHT WOULD BE CORRECTED BY RECALL BUT WAS NOT. THE SYSTEM CHANGES THE LOCATION OF THE AIR FLOW ON IT'S OWN. *NM

DT*: THE CONTACT STATED WHILE DRIVING 65 MPH SMOKE ERUPTED FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THE WIRING HARNESS NEEDED TO BE REPLACED.

1999 JEEP WRANGLER HAD MULTIPLE REAR DIFFERENTIAL FAILURES BEFORE 70K MILES. *TS *** NO ANSWER REQUIRED*** THE ORIGINAL DRIVE TRAIN WAS REBUILT USING ORIGINAL MOPAR PARTS. THE DRIVE TRAIN FAILED FOR THE SECOND TIME AT 69000 MILE AFTER ONLY 11000 MILES OF USE. THIS TIME THE DEALER REFUSES TO PROVIDE ANY FINANCIAL ASSISTANCE. THE VEHICLE HAD OTHER FAILURES WHICH INCLUDE WATER LEAKS, DRIVE TRAIN SEALS FAILURE, ELECTRICAL FAILURES, MULTIPLE ABS FAILURES, AIR BAG AND SEAT BELT PROBLEMS, AND THE PAINT WAS PEELING OFF THE VEHICLE. *NM

INTERMITTENTLY THE GAUGES ON THE DASH GO TO ZERO. THE AIR BAG LIGHT COMES ON. THE ODOMETER DOES NOT WORK. THE VEHICLE HAS NOT BEEN SERVICED, HOWEVER THE MANUFACTURER SENT THE CONSUMER A BODY CONTROL MODULE. *JB THE CONSUMER STATED THAT HER PREVIOUS VEHICLE OF THE SAME MAKE AN MODEL HAD THE SAME PROBLEM. *TC

CAR HAS 30,000 MILES, HAS NOT BEEN "OFF ROAD" OR MISUSED. PROBLEM(S) STARTED AT ABOUT 27,000. . INTERMITTENTLY WHILE DRIVING, INSTRUMENT PANEL AND RADIO LOSE POWER. IF MOTOR IS STOPPED AND RESTARTED, POWER COMES ON AGAIN. *AK 2. INTERMITTENTLY, HEADLIGHTS GO OUT WHEN SIGNALING FOR A RIGHT OR LEFT TURN, THEN TURN ON AGAIN WHEN TURN SIGNAL IS OFF. 3. AIR CONDITIONER INTERMITTENTLY FAILED TO COOL ASSOCIATED WITH AN ELECTRICAL SMELL BEFORE FINALLY FAILING TO COOL ALTOGETHER. 4. CHECK ENGINE LIGHT AND AIRBAG LIGHT INTERMITTENTLY GO ON AND OFF. NO CONSEQUENCES TO DATE OTHER THAN THE STRESS OF HAVING AN UNDEPENDABLE AND HOT VEHICLE IN MIAMI. MECHANICS UNABLE TO FIND THE PROBLEM WITH THE INSTRUMENT PANEL. I AM TOLD THAT I NEED A NEW AIR CONDITIONER BUT CANNOT AFFORD TO REPLACE IT AT THIS TIME.

CONSUMER COMPLAINED ABOUT ELECTRICAL PROBLEMS, WHICH INCLUDED MISREADING ON THE SPEEDOMETER AND GAUGES ON THE DASHBOARD. THIS VEHICLE WAS SERVICED 7 TIMES FOR THIS PROBLEM. HOWEVER, THERE WAS NO REMEDY AND THE PROBLEM RECURRED. CONSUMER TRIED TO CONTACT THE MANUFACTURER BUT WAS UNABLE TO TALK TO ANYONE OTHER THAN CUSTOM REPRESENTATIVE WHO ANSWERED THE PHONE. *AK *NM

MY 1999 JEEP WRANGLER IS DOING EXACTLY WHAT THE RECALL SAYS, BUT FOR SOME REASON MY VIN IS NOT IN THE RECALL SYSTEM AS PER THE JEEP DEALER! PLEASE HELP... THIS IS NOT FAIR THAT THE RECALL IS NOT ON MY JEEP WHEN IT'S DOING EXACTLY WHAT THE RECALL SAYS! THANKS. *AK

THE DASH GAUGES WORKED INTERMITTENTLY. WHEN THE DASH LIGHTS WERE OFF THE AIRBAG LIGHT ILLUMINATED. WHEN THE DASH LIGHT WERE ON THE AIRBAG LIGHT WENT OFF. THE CONSUMER WAS CONCERNED THE AIRBAG MAY NOT WORK PROPERLY. *TT THE CONSUMER STATED THE DASH GAUGES WORKED OFF AND ON. PH *JB

THE DASH BOARD INSTRUMENT PANEL FAILED INTERMITTENTLY. *JB *NLM

AT 35-40 MPH THE HEADLIGHTS AND INSTRUMENT PANEL WENT DARK. VEHICLE HAS NOT BEEN INSPECTED BY DEALER. PLEASE PROVIDE ADDITIONAL INFORMATION. TS

WHILE DRIVING, THE INSURED WAS INFORMED THAT HIS HEADLIGHTS WERE ON AND THAT THE VEHICLE WAS SMOKING, THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND CONSUMER WAS INFORMED THAT THERE WAS A SHORT IN THE DIMMER SWITCH, AND THE A/C CONTROL HEAD. CLAIM#04-1236-643 *YH

WHILE DRIVING, THE INSURED WAS INFORMED THAT HIS HEADLIGHTS WERE ON AND THAT THE VEHICLE WAS SMOKING, THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND CONSUMER WAS INFORMED THAT THERE WAS A SHORT IN THE DIMMER SWITCH, AND THE A/C CONTROL HEAD. CLAIM#04-1236-643 *YH