1998 JEEP WRANGLER Structurebody Problems

JEEP WRANGLER FRAMES RUST FROM INSIDE OUT DUE TO MOISTURE GETTING IN THROUGH UPPER PART OF FRAMES WHERE THEIR ARE HOLES AND SETTLING TO LOWER PART OF FRAME WHERE THEIR ARE NO DRAIN HOLES. THEIR MAY HAVE NOT BEEN AN ISSUE IF JEEP HAD JUST PUT IN DRAIN HOLES IN LOWER PART OF FRAME. IT IS A COMMON PROBLEM IN 1997 THROUGH 2006 JEEP WRANGLERS. I HAVE THIS ISSUE.

I HAVE A 1998 JEEP WRANGLER. I'VE OWNED MY JEEP FOR 15 YEARS. IT HAS BEEN GARAGE KEPT. WE WERE CHANGING THE SHOCKS A FEW WEEKS AGO AND NOTICED SEVERE RUST DAMAGE. THE FRAME IS RUSTING FROM THE INSIDE OUT. IT'S SEVERE. YEARS BEFORE I WAS TRAVELING DOWN A 2 LAND RD AND HAD TO PRESS MY BRAKES HARDER THAN I USUALLY WOULD DUE TO A CAR PULLING OUT IN FRONT OF ME. AT THAT MOMENT I BLEW A BRAKE LINE. I COULD NOT GET MY VEHICLE STOPPED. LUCKILY IT'S A 5 SPEED. I GEARED DOWN AS FAST AS I COULD AND MANAGED TO PULL IT OFF THE MAIN ROAD ONTO A HILL TO GET IT STOPPED. AFTER INSPECTING MY VEHICLE I FOUND SEVERE DAMAGE. THE MOTORS MOUNTS ARE BARELY THERE. THE PART WHERE THE FRAME MOUNTS TO THE BODY IS ACTUALLY MISSING ONE DUE TO RUSTING COMPLETELY OUT. EVERY...

HAD TO REPLACE THE FRAME DUE TO LEFT REAR RUSTED THROUGH THE WHOLE FRAME, JUST A SMALL AMOUNT OF THE FRAME WAS LEFT. OTHER AREAS HAD RUST EATING THREW THE FRAME, AND IN A MATTER OF TIME WOULD HAVE FAILED!!!.

I HAVE AN EXCESSIVE AMOUNT OF FRAME RUST AND MY VEHICLE HAS LESS THAN 150XXX MILES AND THIS IS A SEVERE SAFETY HAZARD. I HAVE READ THAT THERE ARE MANY PEOPLE WHO HAVE EXPERIENCED THIS AND I AM WANTING TO KNOW WHAT YOU GUYS COULD DO TO RESOLVE THIS ISSUE. I BOUGHT THIS VEHICLE AND I DO NOT WANT TO RESALE BECAUSE I DO NOT WANT TO SELL IT IN THIS CONDITION AND I WANT TO KEEP IT BUT I ALSO DO NOT WANT TO DRIVE BECAUSE OF THIS. THERE'S A LOT OF LIFE LEFT IN THIS VEHICLE AND IT ONLY HAS 126XXX MILES SO I NEED HELP

TAKATA RECALL REPORTING THIS IN HOPES OF HAVING THE ISSUE RESOLVED BY NHTSA OR CHRYSLER... I HAVE A 1998 JEEP WRANGLER AND LIKE THOUSANDS OF OTHERS, MINE HAS DEVELOPED MAJOR FRAME RUST. I KNOW THIS ISNT GOING TO BE RESOLVED ANYTIME SOON, BUT I NEED TO GET MINE FIXED NOW. HOPEFULLY IF THERE IS EVER A RECALL I CAN STILL BE APART OF IT EVEN AFTER MINE IS REPAIRED. IM GOING TO BE HAVING IT PATCHED FOR NOW AS A FRAME REPLACEMENT WILL COST WAY TOO MUCH FOR ME AT THE MOMENT. MYSELF, ALONG WITH MANY OTHERS WOULD GREATLY BENIFIT FROM THIS BEING RECALLED. THERE ARE A LOT OF JEEPS OUT THERE DRIVING ON REPAIRED FRAMES. THIS ISSUE SHOULD BE RESOLVED BEING AS THERE ARE SO MANY WITH THE EXACT SAME PROBLEM.

THE RUST IS SO BAD ON THE JEEPS IT'S RIDICULOUS IT'S NOT SAFE YOUR GOING TO KILL SOMEONE WHEN THERE REAR AXLE SHOOTS OUT FROM UNDER THEM THIS IS A ISSUE YOU SHOULD FIX NOT THE CONSUMER I WILL NOT BE BUYING THIS PRODUCT AGAIN IF IT IS MY FIXED. 98 TJ JEEP WRANGLER

DUE TO EXCESSIVE ROT THAT IS COMMON ON THIS VEHICLE, WHILE TRAVELING I HIT A BUMP AND SNAPPED MY DRIVER SIDE CONTROL ARM. THIS CONSEQUENTLY MADE FOR A DANGEROUS RIDE. WHILE ATTEMPTING TO REPAIR IT I NOTICED HOW BAD THE FRAME WAS ROTTED, BUT UNLIKE NORMAL CIRCUMSTANCES WHERE THE OUTSIDE AND INSIDE WOULD HAVE EQUAL CORROSION. THE INSIDE WAS ROTTED MUCH WORSE, AND PARTS OF THE FRAME EASILY CRUMBLED. *TR

THE FRAME AROUND THE CONTROL ARMS ARE RUSTING, THIS COULD BE A SERIOUS PROBLEM THAT NEEDS ADDRESSED AND THERE ARE MORE 97-06 WRANGLERS WITH RUSTED FRAMES THAN NOT. *TR

NOTICED A NOISE WHILE DRIVING HOME THE OTHER DAY THOUGHT IT MAY HAVE BEEN MY EXHAUST RATTLING AROUND, SO I GOT UNDER VEHICLE TO INSPECT THE NOISE, AND WHAT I FOUND WAS THAT THE REAR PART OF THE FRAME HAS RUSTED AWAY AND THE BRACKETS FOR THE REAR TRAILING ARMS HAD DETACHED FROM THE FRAME ALLOWING THE ARMS TO DROP, AND ON THIS PARTICULAR SIDE THE BRAKE LINES ARE ATTACHED TO THIS CONTROL ARM. I KNOW THAT TOYOTA HAD A SIMILAR RECALL ON THE TRUCK FRAMES FOR RUST PERFORATION, AND THAT JEEP HAD ONE ON THE LIBERTY FOR THE REAR LOWER CONTROL ARMS RUSTING AND BREAKING. I AM AN AUTOMOTIVE TECHNICIAN AND MY PERSONAL JEEP IS NOT THE FIRST ONE I HAVE SEEN WITH THIS POTENTIALLY DANGEROUS CONDITION. I ALSO GOOGLED THIS PROBLEM AND FOUND THAT ITS VERY COMMON IN THESE VEHICLES AS WELL. *TR

THE FRAME IS ROTTEN OUT, AND THIS IS A COMMON PROBLEM WITH THE JEEP TJ'S. I HAVE A HOLE ON MY TAIL SECTION OF FRAME AND ON THE REAR CONTROL ARM AREA. *TR

WAS TOLD BY MY MECHANIC FRAME IS RUSTING FROM THE INSIDE OUT, AND THE FRAME WILL FAIL IN THE NEAR FUTURE. I UNDERSTAND THIS IS A ON GOING PROBLEM WITH JEEP WRANGLERS OF MULTIPLE YEARS DUE TO THE FACT THERE WERE NEVER DRAIN HOLES PROVIDING DRAINAGE FOR THE WATER, ALSO LACK OF ANY RUST COATING TO THE INSIDE OF FRAME. IN PENN. YOU CAN NOT SELL A CAR WITH FRAME DAMAGE. I'M NOT SURE WHAT I'M GOING TO DO.I FEEL THAT JEEP SHOULD HELP WITH THE REPAIR OR REPLACEMENT OF THE FRAME. *TR

I AM WRITING TODAY TO COMPLAIN ABOUT MY 1998 JEEP WRANGLER. AFTER MY LAST SERVICE WAS PERFORMED, THE MECHANIC ILLUSTRATED TO ME THAT THE FRAME ON MY JEEP WAS SEVERELY ROTTING AWAY ON THE DRIVERS SIDE. THIS IS NOT AN UNKNOWN CONCERN FOR ME SINCE MY EMPLOYER HAS HAD THE SAME CONCERN REPAIRED ON ONE OF HIS FAMILY MEMBERS JEEP. THIS IS VERY DISHEARTENING TO ME SINCE I HAVE BEEN A JEEP OWNER FOR MANY YEARS. I CONTACTED CHRYSLER CUSTOMER SERVICE AND ACCORDING TO THE OPERATOR THEY ARE NOT FAMILIAR WITH THIS PROBLEM. I FIND THIS UNBELIEVABLE, CONSIDERING THAT I AM NOT THE ONLY ONE WITH THIS CONCERN AND OTHER VEHICLE MANUFACTURES HAVE RECALLED THEIR VEHICLES FOR SIMILAR FRAME ROT PROBLEMS. IE TOYOTA PICKUP TRUCKS, FORD WINDSTAR MINIVANS, AND I AM SURE THERE ARE OTHERS. I AM HAVING THIS JEEP FIXED BUT IT IS GOING TO BE A COSTLY REPAIR,...

THE VEHICLE HAS DEVELOPED AN ODOR ASSOCIATED WITH LEAKING ANITFREEZE. 3 DIFFERENT TRIPS TO MAKE REPAIRS, NO ACTION ON FIRST TRIP, SECOND TRIP, DEALER REPLACED THERMOSTAT HOUSING, THIRD TRIP, DEALER REPLACED RADIATOR. VEHICLE STILL HAS ODOR AT DIFFERENT TIMES. SEAT BELTS HAVE BEEN REPLACED 3 TIMES ON RIGHT HAND SIDE AND ONCE ON LEFT HAND SIDE DUE TO BELTS GETTING PINCHED IN HARDTOP DOORS AND DAMAGING BELTS. BELT ON RIGHT HAND HAS HAD FAILURE OF SEAT BELT INERTIA LOCK DURING HARD STOP. ELECTRICAL SYSTEM: AIRBAG LIGHT ILLUMINATED AT VARIOUS TIMES, AND AT THE SAME TIME THE SPEEDOMETER AND TACHOMETER FAILED MOMENTARILY. FIX WAS TO CLEAN AND GREASE CONNECTORS. SYSTEM IS STARTING TO REPEAT SAME PROBLEM, AND DEALER CANNOT FIND A PROBLEM. STEERING COLUMN LOWER BUSHING HAS DEVELOPED NOISE, AFTER RAIN OR ONSET OF COLD WEATHER. DEALER STATES FIX IS TO LUBE BUSHING, BUT PROBLEM PERSISTS AFTER 4 DEALER VISITS. REAR...

FIRST INCIDENT WAS THE DRIVERS SIDE AREA UNDER THE DASHBOARD FILLING WITH AT LEAST TWO INCHES OF WATER THAT HAD TO BE DRAINED. ALL WINDOWS AND HOODS WERE UP AND SECURE IN BOTH INSTANCES. SECOND COMPLAINT WHILE DRIVING THE AIR BAG LIGHT CAME ON AND ALL GUAGES DROPPED TO ZERO WHILE DRIVING AT 55 MPH.

THE CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH A WATER LEAKAGE. WATER LEAKS FROM THE DASHBOARD ON TO THE FLOORBOARD. THE MANUFACTURER HAS YET TO BE CONTACTED. *AK *ML