1998 JEEP WRANGLER Electrical System Problems

AIRBAG LIGHT COME ON AND SPEEDO AND TACH STOPS WORKING. VEHICLE HAS NOT BEEN IN AN ACCIDENT AND THIS IS OCCURING ON NUMEROUS JEEPS OF THIS YEAR. WHY HAS THERE NOT BEEN A RECALL? IF SOMETHING ISN'T DONE ABOUT THIS I WILL BE GETTING A LOT OF JEEP OWNERS TOGETHER AND FILING A CLASS ACTION LAWSUIT!! IT IS A SERIOUS SAFETY PROBLEM. I JUST PURCHASED THE VEHICLE AND AFTER RESEARCHING THIS ITS HAPPENING TO THE MAJORITY ON THIS YEARS WRANGLERS

TL* THE CONTACT OWNS A 1998 JEEP WRANGLER. WHILE DRIVING AT AN UNKNOWN SPEED, THE SPEEDOMETER FAILED TO DISPLAY THE SPEED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000.

ALL OF A SUDDEN THE SPEEDOMETER AND TACHOMETER GO DEAD, AND THE AIRBAG AND ENGINE LIGHT COME ON. SEEMS TO HAPPEN DURING THE SUMMER MONTHS. I HAVE TO HIT THE DASH A COUPLE OF TIMES AND EVERYTHING STARTS WORKING AGAIN. DOESN'T HAPPEN IN THE WINTER WHEN IT'S COLD. IT'S A LITTLE UNNERVING WHEN THE SPEEDOMETER STOPS WORKING. *TR

I WAS DRIVING AND RUNNING THE HEATER AND NOTICED A BURNING SMELL. I IMMEDIATELY SHUT DOWN THE HVAC UNIT AND SMELL SUBSIDED. I PULLED THE HVAC HEAD UNIT OUT AND HAD A VACUUM LINE AND IT'S INSULATION MELTED. THIS COULD HAVE CAUSED A FIRE. THE HEAT AND AC NOW ONLY WORK ON THE HIGHEST SETTING. *TR

I HAVE HAD NUMEROUS TIMES THAT MY GAUGES JUST STOP WORKING AND THEN ONE DAY I WENT TO DRIVE IT AND I HAD NO TURN SIGNALS OR BRAKE LIGHTS. IT IS IN THE MECHANIC SHOP AS WE SPEAK. THEY HAVE FOUND THE ELECTRICAL CONNECTOR UNDER THE LEFT SIDE OF THE DASH HAS COMPLETELY MELTED AND ALL THE WIRES HAVE FUSED TOGETHER. I WAS VERY LUCKY THAT IT DIDN'T CATCH ON FIRE. NOW THE OTHER PROBLEM IS FINDING THE PART MY MECHANIC HAS TRIED EVERYWHERE TO FIN IT. SO NOW MY JEEP IS JUST SITTING IN THE SHOP GOING ON THREE DAYS NOW UNTIL A PART CAN BE FOUND. WHY IS THERE NO RECALL ON THIS AS I SEE ON HERE AND OTHER SITES THAT IT IS DANGEROUS AND MANY HAVE HAD THE SAME ISSUES?? *TR

PURCHASED MY JEEP NEW IN 1998 AND I ONLY DROVE IT ABOUT 5000 MILES PER YEAR..IN ABOUT 2009 I BEGAN TO HAVE SOME TROUBLE WITH THE GAUGES/SPEEDOMETER..THEY WOULD STOP FUNCTIONING FOR PERIODS OF TIME...IN ABOUT 2010 I THERE WAS AN ODOR COMING FROM THE VENTS WHEN I USED MY HEATER OR AC..EACH TIME I TOOK IT TO THE DEALER WHERE I PURCHASED THE VEHICLE AND THE LAST TIME I HAD IT CHECKED WAS THE END OF SEPTEMBER 2011. ON NOVEMBER 21, 2011 I WAS DRIVING TO THE GROCERY STORE WITH THE HEATER ON AND SMOKE STARTED COMING OUT OF THE VENTS..I TURNED OFF THE HEATER & BLOWER & THEN SAW FIRE COMING OUT FROM UNDER THE DASH ON THE PASSENGER SIDE. I STOPPED & TRIED TO PUT OUT THE FLAMES WITH MY JACKET. A LADY STOPPED TO HELP & CALLED 911. WHILE WAITING FOR THE FIRE DEPARTMENT (JUST A FEW...

AC CONTROLS AND RESISTOR WIRING HARNESS HAS MELTED CANT GET REPLACEMENT PARTS FROM A DEALER OR SALVAGE YARDS WHAT AM I SUPPOSED TO DO . I THINK THE JEEP WRANGLER NEEDS TO ATLEAST MAKE A REPLACEMENT PART OR FIX IT ON A RECALL. *TR

INTERMITTENTLY AIRBAG LIGHT COMES ON RPM AND SPEEDOMETER GAUGES FAIL SOMETIMES ALL GAUGES FAIL.... SOMETIMES WHEN I HONK MY HORN THEY "COME BACK UP"... THIS HAS BEEN GOING ON FOR YEARS... VERY DANGEROUS BECAUSE I DO NOT KNOW HOW FAST I AM GOING... TOOK IT TO THE MECHANIC REPLACED MY IGNITION SWITCH...2 DAYS AGO AND LAST NIGHT THE PROBLEM APPEARED AGAIN.. DOESN'T MATTER WHAT SPEED I AM GOING GAUGES WILL FAIL. *TR

INSTRUMENT CLUSTER GOES OUT - SPEEDOMETER AND TACH, OR ALL OTHER GAUGES GO OUT, AIRBAG LIGHT COMES ON. APPEARS TO BE MANY DOCUMENTED CASES OF THIS SAME FAILURE WITH THE WIRING HARNESS/INSTRUMENT CLUSTER PROBLEM SINCE 1998. NUMEROUS SERVICE BULLETINS BUT NO RECALLS! WHAT CAN BE DONE TO PREVENT THE PROBLEM AND IS THERE A RECALL FOR THIS? *TR

INSTRUMENT CLUSTER/GAUGES INTERMITTENTLY STOP FUNCTIONING WHILE DRIVING AND THE AIRBAG LIGHT ALSO COMES ON. THERE IS NO WARNING, JUST A SHUT DOWN OF ALL GAUGES. I HAVE READ SEVERAL REPORTS OF THIS SAME PROBLEM OCCURRING ON THIS SAME YEAR AND MODEL OF WRANGLER. I HAVE ALSO READ THAT THE AIRBAG WILL NOT FUNCTION WHEN THIS PROBLEM OCCURS. THIS APPEARS TO BE A WIDE SPREAD PROBLEM AND A SERIOUS SAFETY HAZARD. WHAT WOULD BE THE REASON THAT THERE HAS BEEN NO RECALL TO CORRECT THIS? *TR

MY GAUGES ON THE DASHBOARD CONSISTENTLY GO TO "0" WHILE DRIVING MY 1998 JEEP WRANGLER. MY SPEEDOMETER,TACHOMETER, BATTERY STATUS, OIL, AND ENGINE TEMP ALL GO TO THE LEFT AND THE RED AIRBAG LIGHT COMES ON. THIS ESPECIALLY OCCURS WHILE DRIVING OVER BUMPS. IT IS A HUGE SAFETY CONCERN BECAUSE I NEVER KNOW HOW FAST I AM GOING, WHEN I NEED GAS, OR IF MY AIR BAG WILL DEPLOY IN MY FACE OR IF IT WILL DEPLOY IN THE EVENT OF AN ACCIDENT. THERE HAVE BEEN SO MANY OTHER REPORTS CONCERNING THIS SAME ISSUE THAT IT IS INCUMBENT ON THE GOVERNMENT OR JEEP/CHRYSLER TO RECTIFY THIS SITUATION! *NM

WHEN COLD OR DAMP OR RAINING AND WITH LIGHT THROTTLE THE ENGINE STUMBLES/SHUTS OFF. THE TACHOMETER AND SPEEDOMETER REGISTER NOTHING. THIS IS VERY FRIGHTENING WHEN AMIDST HEAVY TRAFFIC AT 55 OR 65 MPH. I SEARCHED THE WEB AND FOUND OTHER INSTANCES OF THE SAME PROBLEM, BUT NO RECALL??? AND NO CURE??? FOR THIS VERY UNSAFE CONDITION. *NM

ELECTRICAL SYSTEM FAILURE. *AK

CONSUMER STATED THE FUEL TANK HAD A CRACKED WHICH CAUSED FLUID TO LEAK OUT. THE DEALER WAS NOTIFIED. *AK THE FUEL TANK HAD LEAKED SINCE THE OWNER PURCHASED THE VEHICLE AT 39K MILES. THE FUEL TANK OVERFLOWED WHEN FILLED IN HOT WEATHER. BOTH THE FUEL TANK NUT REPLACEMENT TANK WERE DIFFICULT TO OBTAIN DUE TO SHORTAGE. THE TACHOMETER AND SPEEDOMETER HAD BECOME INOPERATIVE. THE SERVICE DEALER FOUND A POOR CONNECTION BEHIND THE CLUSTER. THE THROTTLE SENSOR DID NOT HAVE A GOOD SEAL IN WHICH MOISTURE HAD GOTTEN INTO IT. THE FUEL TANK CORRODED BADLY AND THE NEW TANK NUT WAS USELESS. THE CONSUMER REPLACED THE FUEL PUMP, FUEL FILTER, AND THE GAS TANK. THE CONSUMER REQUESTED REIMBURSEMENT. *SCC ALSO THE WATER PUMP SERPENTINE BELT, AND BATTERY WERE REPLACED. *JB

1998 JEEP WRANGLER 4.0L, EXHAUST MANIFOLD CRACK AT 30,000 MILES. JEEP/CHRYSLER REFUSED TO FIX, STATING ONLY CATALYTIC CONVERTER COVERED UNDER WARRANTY. CRACK OCCURRED IN A WELD JOINING THE TWO PIPE, ALMOST 3/4 OF THE WAY AROUND THE PIPE, CAUSING COSIDERABLE NOISE, AND LOSS OF POWER. GUAGES FAIL PERIODICALLY, BUT COME BACK ON THERE OWN, AFTER A FEW MINUTES. AIR CONDITIONER DRAINS ONTO FLOOR INSIDE VEHICLE ON LONG DRIVES AND CAN EVEN SHORT OUT THE RADIO. THE STEERING COLUMN ALSO SQEALS LIKE AN OLD DOOR WHEN ITS COLD OUTSIDE.*AK

AFTER PARKING OUR 1998 WRANGLER AT THE HOSPITAL TO VISIT MY MOTHER MY CAR WAS REPORTED ON FIRE. THE FIREMEN STATED AND WROTE A REPORT IT WAS AN ELECTRICAL FIRE. THE WRANGLER IS TOTALED AND THE INSURANCE COMPANY WILL NOT PAY THE VEHICLE OFF. WE ARE SHORT $3,000 OF THE PAY OFF. MY IMMEDIATE CONCERN IS I WAS GLAD I WAS NOT DRIVING AT THE TIME OF THE FIRE AND DID THIS HAPPEN TO OTHER OWNERS OF A WRANGLER. THIS CAR IS ONLY GOING INTO 5 YEARS OLD AND HAS HAD THE REAR END REPLACED AT OUR EXPENSE AND THE GAUGES GO ON AND OFF AND THIS WAS FIXED ONCE. WHAT CAUSED THIS ELECTRICAL FIRE? I WANT JEEP TO RESPOND TO WHY THIS HAPPENED. *TT

I HAVE HAD NUMEROUS PROBLEMS WITH MY JEEP WRANGLER 1998. THIS IS A PARTIAL LIST I SENT TO CHRYSLER: I BOUGHT MY JEEP WITH JUST 3600 MILES ON IT FROM A DEALER IN 1999. FROM DAY ONE I STARTED EXPERIENCING PROBLEMS. MANY OF THEM I RETURNED TO THE SERVICE DEPARTMENT. SOME THEY WERE ABLE TO FIX, OTHERS, AFTER MANY RETURN TRIPS, THEY WERE 'UNABLE TO DUPLICATE THE PROBLEM'. 1. GAUGES WOULD STOP WORKING WHILE DRIVING - I BROUGHT THE VEHICLE IN 5 TIMES BEFORE THEY WERE ABLE TO DUPLICATE AND FINALLY FIX THE PROBLEM. 2. THIS WAS ALSO TRUE OF THE BLINKERS THAT NOT ALWAYS WORKED - OR WORKED ALL AT THE SAME TIME. 3. MY HAZARDS STILL DO NOT WORK EVERY TIME. 4. THE AIR CONDITIONER GOES OUT WHEN DRIVING,VERY UNCOMFORTABLE WHEN IT IS HOT AND RAINING. 5. THE SOUND BAR HAS NEVER WORKED PROPERLY - FIRST IT WOULD...

ELECTRICAL SYSTEM FAILED. NLM

STARTED VEHICLE AFTER IT HAD SAT FOR 13 HOURS. VEHICLE STARTED WITHOUT A PROBLEM, BUT A POP/CRACKLING SOUND WAS HEARD AT START-UP. THE RADIO WAS TURNED ON AND IT IMMEDIATLEY POWERED DOWN AND CLOCK WENT BLANK. ALL THE GAUGES ON THE INSTRUMENT PANEL READ "0". THE HEADLIGHTS, FOGLIGHTS, INSTRUMENT PANEL LIGHTS WORK. THE INTERIOR LIGHT DOES NOT WORK. ALL FUSES FOR RADIO, INSTRUMENT PANEL AND INTERIOR LIGHT ARE NOT BLOWN. THIS IS THE FIRST INCIDENT OF ANY PROBLEMS WITH THE VEHICLE.

ELECTRICAL SYSTEM AND CRUISE CONTROL.

I HAVE RECENTLY PURCHASED A NEW JEEP WRANGLER SAHARA. SINCE THE 8000 MILE MARK, MY AIRBAG LIGHT CONSTANTLY COMES ON AND ALL MY DASH GAUGES DROP TO 0. THIS HAPPENS WHEN I AM DRIVING ALL THE TIME. I HAVE TAKEN IT IN FOUR TIMES TO GET IT FIXED BUT JEEP HAS FAILED TO FIX THE PROBLEM. I ASKED THEM IF THIS MEANS THAT IF THERE IS AN ACCIDENT, THE AIRBAG WON'T DEPLOY BECAUSE THE COMPUTER ALREADY THINKS IT HAS. THEY WALK AROUND THE SUBJECT SAYING THAT THIS HAS BEEN A COMMONLY REPORTED FAILURE IN THE NEW JEEPS, YET I HAVE SEEN NO RECALL INFORMATION ON IT. THEY TOLD ME THEY RECEIVED A NUMBER OF BAD ELECTRICAL HARNESSES THAT CONTROL THE AIRBAG FROM THEIR MEXICO PLANT AND EVEN THE NEW REPLACEMENT PARTS ARE FAILING. I WORRY THAT MY AIRBAG WILL NOT WORK WHEN THE TIME COMES AND THEY REFUSE TO REPLACE...