2004 HONDA GL1800A — Problems, Recalls & Safety Data
N/A
Safety Rating
5
Owner Complaints
3
Recalls
2
Service Bulletins
0
Investigations
Overview of the 2004 HONDA GL1800A
The 2004 HONDA GL1800A has received a total of 5 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER, STRUCTURE:FRAME AND MEMBERS, SERVICE BRAKES, HYDRAULIC. 2 technical service bulletins have been issued by Honda (American Honda Motor Co.) for this model year. The most commonly reported problems involve the Electrical System (1 complaint), Electronic Stability Control Esc (1 complaint), and Engine (1 complaint).
Recalls for the 2004 HONDA GL1800A
NHTSA has recorded 3 recalls for the 2004 HONDA GL1800A, potentially affecting up to 216,184 vehicles.
Recall 15V700000 — SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
| 145,219 vehicles affected
Defect: American Honda Motor Co., Inc. (Honda) is recalling certain model year 2001-2010 and 2012-2015 GL1800, 2001-2005 GL1800A and 2013-2015 GL1800B motorcycles. The rear brakes of the affected motorcycles may drag after the brakes are released.
Consequence: A rear brake that drags may increase the risk of a vehicle crash. Additionally, extended riding with the rear brake dragging could generate enough heat to result in a fire.
Remedy: Honda will notify owners, and dealers will replace the secondary brake master cylinder and the rear brake master cylinder, and flush the brake fluid, free of charge. The recall began on December 7, 2015. Owners may contact Honda customer service...
View full details →Recall 05V027000 — STRUCTURE:FRAME AND MEMBERS
| 34,919 vehicles affected
Defect: ON SOME MOTORCYCLES, CERTAIN FRAME WELDS DO NOT MEET MANUFACTURING SPECIFICATIONS. HIGH LOADS CREATED WHEN RIDING ON ROUGH ROAD SURFACES OR THROUGH POTHOLES CAN CAUSE THE AFFECTED WELDS TO CRACK.
Consequence: THE WELDED AREA COULD BREAK, RESULTING IN REAR SUSPENSION COLLAPSE OR LOWER CROSS MEMBER SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REINFORCE THE WELDS ON 2001-2002 MOTORCYCLES FREE OF CHARGE. ON 2003-2004 MOTORCYCLES, THE UNITS WILL BE REPAIRED, NO INSPECTION WILL BE NECESSARY. THE RECALL BEGAN ON FEBRUARY 9, 2005. OWNERS MAY CONTACT HONDA AT...
View full details →Recall 05V010000 — SERVICE BRAKES, HYDRAULIC
| 36,046 vehicles affected
Defect: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
Consequence: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
View full details →Owner Complaints for the 2004 HONDA GL1800A
5 complaints have been filed with NHTSA for the 2004 HONDA GL1800A. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Electrical System | 1 | 0 | 1 | 0 | 0 |
| Electronic Stability Control Esc | 1 | 0 | 1 | 0 | 0 |
| Engine | 1 | 0 | 1 | 0 | 0 |
| Power Trainmanual Transmission | 1 | 0 | 0 | 0 | 0 |
| Suspension | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
I HAVE A 2004 HONDA GOLDWING WITH A CALIFORNIA SIDE CAR KIT. I PURCHASED IT FROM THE SECOND OWNER ABOUT 1.5 YRS AGO. ABOUT A YEAR AGO I WAS RIDING A BACK ROAD WHEN THE STARTER ENGAGED. I HADN'T TOUCHED THE START SWITCH? I TRIED THE KILL SWITCH BOTH POSITIONS AS THIS MODEL HAS AN UP AND DOWN FEATURE. I THEN TURNED THE IGNITION OFF, NO AVAIL. FINALLY IT STOPPED ON IT'S OWN. AFTER RETURNING HOME IT WOULD NOT RESTART, I DID A CHECK AND FOUND THE START RELAY WAS FRIED. A FEW WEEKS LATER IT HAPPENED AGAIN SAME SYMPTOMS AND RESPONSE TO WHAT SHOULD HAVE SHUT A BIKE DOWN SAME RESULTS. I HAD IT TOWED TO THE DEALER IN LAKE CITY, FL. AFTER TRYING TO SELL ME A NEW BIKE PIECE BY PIECE I PAID MY $1K AND LEFT WITH A NEW STARTER AND NEW STARTER RELAY. A COUPLE WEEKS LATER WHEN IT HAPPENED I HAD SEVERAL STARTER RELAYS ONBOARD AND SURE ENOUGH REPLACE THE START RELAY IT STARTED I MADE IT HOME. THIS WEEK WHILE WASHING IT I TURNED THE KEY ON AND BEFORE I COULD MOUNT IT IT STARTED CHUGGING BY THE STARTER THROUGH MY YARD. CHOICE LEAVE IT AND ALLOW IT TO STOP BY RUNNNING IN THE HOUSE OR A CAR TO GET A WRENCH TO TAKE THE NEGATIVE OFF THE BATTERY OR STAY WITH IT AN CHOKE IT DOWN USING THE BRAKES. AGAIN START RELAY AND STARTER. I REALIZE YOU DON'T DEAL WITH WARRANTY ISSUES BUT IMAGINE NOT BEING ABLE TO STOP A MOTORCYCLE WITH THE KEY, THE KILL SWITCH OR BEING ABLE TO CONTROL IT WITH THE CLUTCH SINCE THE STARTER HAS NO CONNECTION. THIS IS A COMMON PROBLEM AND DISCUSSED ON GOLDWING FORUMS. I CAN'T FIND ANYONE AT HONDA TO HELP...CAN YOU BEFORE SOMEONE IS HURT?
I HAVE A 2004 HONDA GOLDWING WITH A CALIFORNIA SIDE CAR KIT. I PURCHASED IT FROM THE SECOND OWNER ABOUT 1.5 YRS AGO. ABOUT A YEAR AGO I WAS RIDING A BACK ROAD WHEN THE STARTER ENGAGED. I HADN'T TOUCHED THE START SWITCH? I TRIED THE KILL SWITCH BOTH POSITIONS AS THIS MODEL HAS AN UP AND DOWN FEATURE. I THEN TURNED THE IGNITION OFF, NO AVAIL. FINALLY IT STOPPED ON IT'S OWN. AFTER RETURNING HOME IT WOULD NOT RESTART, I DID A CHECK AND FOUND THE START RELAY WAS FRIED. A FEW WEEKS LATER IT HAPPENED AGAIN SAME SYMPTOMS AND RESPONSE TO WHAT SHOULD HAVE SHUT A BIKE DOWN SAME RESULTS. I HAD IT TOWED TO THE DEALER IN LAKE CITY, FL. AFTER TRYING TO SELL ME A NEW BIKE PIECE BY PIECE I PAID MY $1K AND LEFT WITH A NEW STARTER AND NEW STARTER RELAY. A COUPLE WEEKS LATER WHEN IT HAPPENED I HAD SEVERAL STARTER RELAYS ONBOARD AND SURE ENOUGH REPLACE THE START RELAY IT STARTED I MADE IT HOME. THIS WEEK WHILE WASHING IT I TURNED THE KEY ON AND BEFORE I COULD MOUNT IT IT STARTED CHUGGING BY THE STARTER THROUGH MY YARD. CHOICE LEAVE IT AND ALLOW IT TO STOP BY RUNNNING IN THE HOUSE OR A CAR TO GET A WRENCH TO TAKE THE NEGATIVE OFF THE BATTERY OR STAY WITH IT AN CHOKE IT DOWN USING THE BRAKES. AGAIN START RELAY AND STARTER. I REALIZE YOU DON'T DEAL WITH WARRANTY ISSUES BUT IMAGINE NOT BEING ABLE TO STOP A MOTORCYCLE WITH THE KEY, THE KILL SWITCH OR BEING ABLE TO CONTROL IT WITH THE CLUTCH SINCE THE STARTER HAS NO CONNECTION. THIS IS A COMMON PROBLEM AND DISCUSSED ON GOLDWING FORUMS. I CAN'T FIND ANYONE AT HONDA TO HELP...CAN YOU BEFORE SOMEONE IS HURT?
I HAVE A 2004 HONDA GOLDWING WITH A CALIFORNIA SIDE CAR KIT. I PURCHASED IT FROM THE SECOND OWNER ABOUT 1.5 YRS AGO. ABOUT A YEAR AGO I WAS RIDING A BACK ROAD WHEN THE STARTER ENGAGED. I HADN'T TOUCHED THE START SWITCH? I TRIED THE KILL SWITCH BOTH POSITIONS AS THIS MODEL HAS AN UP AND DOWN FEATURE. I THEN TURNED THE IGNITION OFF, NO AVAIL. FINALLY IT STOPPED ON IT'S OWN. AFTER RETURNING HOME IT WOULD NOT RESTART, I DID A CHECK AND FOUND THE START RELAY WAS FRIED. A FEW WEEKS LATER IT HAPPENED AGAIN SAME SYMPTOMS AND RESPONSE TO WHAT SHOULD HAVE SHUT A BIKE DOWN SAME RESULTS. I HAD IT TOWED TO THE DEALER IN LAKE CITY, FL. AFTER TRYING TO SELL ME A NEW BIKE PIECE BY PIECE I PAID MY $1K AND LEFT WITH A NEW STARTER AND NEW STARTER RELAY. A COUPLE WEEKS LATER WHEN IT HAPPENED I HAD SEVERAL STARTER RELAYS ONBOARD AND SURE ENOUGH REPLACE THE START RELAY IT STARTED I MADE IT HOME. THIS WEEK WHILE WASHING IT I TURNED THE KEY ON AND BEFORE I COULD MOUNT IT IT STARTED CHUGGING BY THE STARTER THROUGH MY YARD. CHOICE LEAVE IT AND ALLOW IT TO STOP BY RUNNNING IN THE HOUSE OR A CAR TO GET A WRENCH TO TAKE THE NEGATIVE OFF THE BATTERY OR STAY WITH IT AN CHOKE IT DOWN USING THE BRAKES. AGAIN START RELAY AND STARTER. I REALIZE YOU DON'T DEAL WITH WARRANTY ISSUES BUT IMAGINE NOT BEING ABLE TO STOP A MOTORCYCLE WITH THE KEY, THE KILL SWITCH OR BEING ABLE TO CONTROL IT WITH THE CLUTCH SINCE THE STARTER HAS NO CONNECTION. THIS IS A COMMON PROBLEM AND DISCUSSED ON GOLDWING FORUMS. I CAN'T FIND ANYONE AT HONDA TO HELP...CAN YOU BEFORE SOMEONE IS HURT?
ON 2004 HONDA GL1800A MOTORCYCLE TRANSMISSION WOULD JUMP BACK INTO 4TH GEAR FROM OD GEAR. THE TRANSMISSION WOULD ALSO DISENGAGE WHILE IN OD GEAR. *TR
DT: THE CONSUMER STATED THAT WHEN RIDING THE MOTORCYCLE AT 40 MPH AND TAKING BOTH HANDS OFF OF THE HANDLE BARS, THE MOTORCYCLE WOULD SHAKE VIOLENTLY. THE CONSUMER ALSO NOTICED THIS PROBLEM ON JULY 5, 2005. THE CONSUMER SPOKE TO THE DEALER AND THEY WERE GOING TO CHARGE THE CONSUMER FOR INSPECTING THE MOTORCYCLE. THERE WAS NO WARNING OR NOISE BEFORE THE PROBLEM OCCURRED. THIS PROBLEM OCCURRED EACH TIME THE CONSUMER DROVE THE MOTORCYCLE. *AK (12/08/05) *SC
Safety Rating for the 2004 HONDA GL1800A
NHTSA has not yet tested the 2004 HONDA GL1800A in its New Car Assessment Program.
Technical Service Bulletins for the 2004 HONDA GL1800A
Honda (American Honda Motor Co.) has issued 2 technical service bulletins (TSBs) for the 2004 HONDA GL1800A. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
TSB-03V350 — STRUCTURE:FRAME AND MEMBERS
HONDA MOTORCYCLE: FRAME WELD SAFETY RECALL. REQUIRES INSPECTION OR REPAIR OF LOWER CROSS MEMBER FRAME WELDS. THE FRAME WELD APPROVAL AND DOCUMENTATION PROCESS IS BEING CHANGED BY THE MANUFACTURER. *PE
05012005 — ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
PROPORTIONAL CONTROL VALVE (PCV) LEAKAGE RECALL REMINDER. REFER TO BULLETIN GL1800A #16. *TT
NHTSA Investigations for the 2004 HONDA GL1800A
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the HONDA GL1800A
- 2001 HONDA GL1800A — 15 complaints
- 2002 HONDA GL1800A — 8 complaints
- 2003 HONDA GL1800A — 16 complaints
- 2004 HONDA GL1800A (current)
- 2005 HONDA GL1800A — 0 complaints
- 2006 HONDA GL1800A — 0 complaints
- 2008 HONDA GL1800A — 1 complaint
Other HONDA Models
- HONDA ACCORD — 30,831 total complaints
- HONDA CR-V — 20,109 total complaints
- HONDA CIVIC — 19,776 total complaints
- HONDA ODYSSEY — 15,588 total complaints
- HONDA PILOT — 12,071 total complaints
- HONDA FIT — 2,686 total complaints
- HONDA RIDGELINE — 2,527 total complaints
- HONDA HR-V — 2,201 total complaints