2001 HONDA GL1800A — Problems, Recalls & Safety Data

TL*THE CONTACT OWNS A 2001 HONDA GL1800A MOTORCYCLE. WHILE DRIVING 40 MPH, HE NOTICED THAT THE SPEEDOMETER WOULD NOT INCREASE BEYOND 40 MPH UNTIL HE TOUCHED THE SCREEN. THE DEALER WAS STATED THAT THEY COULD NOT REPLACE THE PART WITHOUT PERMISSION FROM HONDA. HE CONTACT IS CONCERNED ABOUT THE SAFETY RISK SINCE HE HAD TO USE ONE HAND TO TOUCH THE SPEEDOMETER WHICH COULD POTENTIALLY RESULT IN A CRASH. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,180 AND THE CURRENT MILEAGE WAS 36,442. UPDATED 08/31/10. *LJ THE CONSUMER STATED HE HAD TO TAP ON THE PLASTIC COVER WITH HIS FIST TO GET IT TO MOVE. UPDATED 08/31/10*JB

I HAVE A 2001 HONDA GOLDWING GL1800A MOTORCYCLE. IN JUNE OF 2004 WHILE RIDING IN THE MOUNTAINS I DOWNSHIFTED TO SECOND GEAR, IT WENT IN FINE BUT AS I ACCELERATED OUT OF A CURVE THE BIKE LURCHED FORWARD. WHEN I GOT BACK TO RENO I REPORTED THIS TO THE LOCAL HONDA DEALER. THEY RODE IT AND COULD NOT GET IT TO ACT UP FOR THEM. THIS CONTINUES TO HAPPEN INTERMITTENTLY FOR SEVERAL MONTHS GETTING MORE FREQUENT. FINALLY IT DOES IT FOR THE HONDA SERVICE MANAGER. HE CONTACTS HONDA CORPORATE AND THEY SAY TO BRING IT IN AND OPEN IT UP TO SEE WHAT'S WRONG. THE ENGINE HAS TO COME OUT OF THE BIKE AND THE CASE SPLIT TO GET TO THE TRANSMISSION. THIS IS AT 94,700 MILES. I HAD RIDDEN THE BIKE OVER 12,000 MILES SINCE THE FIRST LURCHING INCIDENT BECAUSE THE HONDA DEALER COULD NOT RECREATE THE PROBLEM RIGHT AWAY AND THEY SAID TO KEEP RIDING IT. THEY FOUND A BENT SHIFTING FORK BETWEEN FIRST AND SECOND GEAR. THEY REPLACED THE SHIFTING DRUM, FORK AND OTHER TRANSMISSION PARTS. HONDA COVERED IT UNDER A "GOOD WILL" WARRANTY. THE BIKE WAS STILL COVER UNDER AN EXTENDED WARRANTY. IN MAY OF 2008 AT 154,313 MILES, THE SAME THING HAPPENS AGAIN, AGAIN I BRING IT TO THE LOCAL HONDA DEALER THEY RIDE IT AND IT WON'T DO IT FOR THEM. FINALLY IT IS RECREATED FOR HONDA IN APPROX. SEPT OF '08. THEY SAY THAT THEY CAN NOT GET TO IT UNTIL DECEMBER OR JANUARY. I BRING IT IN ON JAN 7,2009 AT 164,000 MILES. THEY TEAR IT APART-SAME TRANSMISSION PROBLEM AND THE ENGINE CYLINDERS ARE OUT OF ROUND. I HAVE THE MOTOR AND TRANSMISSION REBUILT AGAIN. HONDA CORP. WILL NOT COVER ANY COSTS. BIKE RUNS FINE NOW BUT I FEAR IT WILL DO IT AGAIN. THANKS YOU.................. *TR

I SUBMITTED AN EARLIER COMPLIANT #10237793. THIS DESCRIBED A FRAME CRACK IS ON THE LEFT SIDE OF THE FRAME. TODAY, I FOUND A SECOND FRAME CRACK IN THE EXACT SAME LOCATION BUT, ON THE OPPOSITE SIDE(RIGHT) OF THE FRAME. THE CRACK ORIGINATES IN A WELD AREA & MIGRATES INTO THE FRAME TUBING. BOTH CRACKS, ON EACH SIDE OF THE FRAME LOOK IDENTICAL. THE FRAME PART THAT IS CRACKED IS KNOWN AS THE SUB-FRAME, WHICH IS THE TRIANGLE PORTION AT THE REAR HALF OF THE FRAME. *TR

I DISCOVERED THE FRAME ON MY 2001 HONDA GL1800A IS CRACKED. ITS LOCATION IS THE LEFT LOWER TUBE THAT IS BELOW THE BATTERY BOX. THIS PARTICULAR CRACK SITUATION HAS BEEN EXPERIENCED BY MANY CQNSUMERS.THIS CRACK WAS NOT DESCRIBED IN THE LAST HONDA MOTORCYCLE FRAME CRACK RECALL.

I DISCOVERED FRAME CRACKS ON MY 2001 HONDA GOLDWING GL 1800, ON 16 APRIL, 2008. THE FRAME CRACKS ARE LOCATED BELOW THE PASSENGER FOOT REST ON BOTH LEFT AND RIGHT SIDE. THE CRACK BEGINS IN A WELD AND DESCENDS INTO THE FRAME. I CONTACTED AMERICAN HONDA ON 16 APRIL TO SEEK GUIDANCE AND WAS INSTRUCTED TO TAKE THE MOTORCYCLE TO MY LOCAL DEALERSHIP. I TOOK THE MOTORCYCLE TO THE HONDA DEALER IN SAVANNAH, GA. ON 19 APRIL, 2008. THE SERVICE MANAGER PERFORMED AN INSPECTION AND SENT PHOTOS TO AMERICAN HONDA AND THE DECISION TO REPLACE THE FRAME WAS MADE. I WAS INFORMED BY THE SERVICE MANAGER ON 17 JUNE, THAT THE FRAME HAS BEEN REPLACED. I WILL PICK UP THE MOTORCYCLE ON 18 JUNE, 2008. HONDA HAS TAKEN FULL RESPONSIBILITY. I JUST WANTED TO ENSURE THAT THIS DOES NOT GO UNNOTICED. MY FRAME IS NOT THE FIRST THAT HAS EXPERIENCED CRACKS IN THE SAME LOCATION. THANK YOU FOR YOUR TIME. *TR