2001 HONDA CR-V Engine And Engine Coolingengine Problems

TL*THE CONTACT OWNS A 2001 HONDA CR-V. HE STATED THAT INTERMITTENTLY WHILE DRIVING THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL THEN THE ENGINE MISFIRED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY. THE MECHANIC CONCLUDED THAT THE ENGINE VALVES BURNED AND THE ENGINE NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED, AND A REPRESENTATIVE CONCLUDED THAT THEY WERE AWARE OF THE PROBLEM; HOWEVER, SINCE THE WARRANTY EXPIRED THEY WOULD NOT PROVIDE ANY ASSISTANCE. NO REPAIRS HAVE BEEN MADE. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 55000. THE CURRENT MILEAGE WAS 135000.

CHECK ENGINE LIGHT CAME ON TO MY 2001 HONDA CR-V. IDENTIFIED AS A MISFIRE IN CYL #1, AND LOW COMPRESSION IN THAT CYLINDER. THE HEAD WAS REMOVED, AND ONE OF THE EXHAUST VALVES IN THE #1 CYLINDER WAS BURNED. THE VALVE CLEARANCE ON THAT CYLINDER WAS ZERO. A "VALVE JOB" WAS DONE AND THE ENGINE WAS REASSEMBLED. COST WAS $1450. *TR

2001 HONDA CRV STARTED TO HAVE A ROUGH IDLE FOLLOWED BY THE CHECK ENGINE LIGHT TURNING ON APPROXIMATELY ONE YEAR AGO. TOOK THE VEHICLE IN FOR A TUNE UP AT A LOCAL DEALER AND PROBLEM TEMPORARILY WENT AWAY. RECENTLY THE PROBLEM GOT WORSE AND THE CHECK ENGINE LIGHT CAME BACK ON. THE HONDA DEALER EVALUATED THE CHECK ENGINE LIGHT REPORTED THAT THERE WAS A PROBLEM WITH THE VALVES. I HAD THE DEALER CONDUCT A VALVE ADJUSTMENT AND THEY REPORTED THAT COMPRESSION ON THE #3 CYLINDER ONLY REPORTED 45 PSI AND RECOMMENDED REPLACING THE CYLINDER HEAD AT A COST OF $4500 DOLLARS. THE SERVICE REPRESENTATIVE THE HONDA DEALERSHIP WAS AWARE OF PROBLEMS WITH THE HONDA CRV AND HONDA HAS NOT TAKEN ANY RESPONSIBILITY FOR THE PROBLEM NOR OFFERED TO REPAIR THE PROBLEM. I BELIEVE HONDA HAS BEEN AWARE OF PROBLEMS WITH THE 2001 HONDA CRV. REQUEST THE NHTSB CONDUCT AN INVESTIGATION....

2001 HONDA CR-V SE CHECK ENGINE LIGHT WENT ON, IDLE BECAME EXTREMELY ROUGH AND STALLING WHILE DRIVING. NOTHING UNUSUAL PRECEDED THIS INCIDENT. TOOK THE CAR INTO TO BE DIAGNOSED AND WAS TOLD THE 4TH CYLINDER WAS ONLY HOLDING 15-20% OF REQUIRED PRESSURE, IT HAD GONE SOFT. RESEARCHED ISSUE AND FOUND HONDA HAS ISSUED A TECHNICAL SERVICE BULLETIN #03038 REGARDING THIS PROBLEM. IT IS A KNOWN DEFECT IN THE HONDA CR-V AS THE HONDA MAINTENANCE GUIDE DOES NOT RECOMMEND ANY VALVE MAINTENANCE UNTIL 105,000 MILES. HOWEVER, IT HAS BEEN FOUND THAT THE ENGINE'S HIGH COMPRESSION RATE CAUSES THE VALVES TO WARP AND BECOME SOFT UNLESS THEY ARE ADJUSTED EVERY 30,000-35,000 MILES. HAVE BEEN IN CONTACT WITH HONDA AND ALL THEY ARE WILLING TO DO IS SPLIT THE COST 50/50 OF THIS MAJOR REPAIR, OVER $3,000. THEY ARE MANY DOCUMENTED CASES OF THIS OCCURRING WITH THE 1999-2001 HONDA CR-VS THAT USE THE...

TL*THE CONTACT OWNS A 2001 HONDA CR-V. THE CONTACT ATTEMPTED TO START THE VEHICLE AND IT STALLED. SHE DEPRESSED THE ACCELERATOR PEDAL ALL THE WAY DOWN TO THE FLOOR TO RESTART THE VEHICLE. THE VEHICLE RESTARTED AFTER TWO TO THREE ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADJUSTED THE HEADS IN THE ENGINE. THE CONTACT STATED THAT SHE WAS NOT NOTIFIED OF THE TECHNICAL SERVICE BULLETIN REGARDING THE ENGINE. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 109,000 AND FAILURE MILEAGE WAS 96,000.

EVENTS LEADING UP TO FAILURE: ENGINE RUNNING POOR FAILURE: BURNT VALVES, LOST 1 CYLINDER, 2 VALVES CORRECTION: REBUILT HEAD AND DO VALVE ADJUSTMENTS SOONER THAN MAINTENANCE RECORDS REQUIRE AND $1,500 IN REPAIRS PLUS RENTAL CAR COSTS. *NM

ROUGH IDLE, ENGINE WOULD STUMBLE BUT RECOVER SEVERAL TIMES WHEN IDLING BEFORE FULLY WARMED UP, POOR FUEL MILEAGE. NO MIL (CHECK ENGINE LIGHT), AND NO CODES OR PENDING CODES DETECTED. DEALER TESTED AND STRONGLY RECOMMENDED VALVE ADJUSTMENT. ONLY 63K MILES ON IT AND VALVES WERE NOT NOISY. OWNER'S MANUAL STATES, "ADJUST VALVES AT 105, 000 MILES OR IF NOISY". NEITHER WERE TRUE. I RESEARCHED CR-V MESSAGE BOARDS AND FOUND LOTS OF "1ST GEN." CR-V'S (MAINLY FROM '99 TO '01) WERE HAVING PROBLEM WHEREBY SOME VALVE SEATS WERE RECEDING INTO CYLINDER HEAD CAUSING NEED FOR PREMATURE VALVE ADJUSTMENTS, BURNT EXHAUST VALVES, OR SOME EVEN NEEDING TO REPLACE CYLINDER HEAD. MOST PEOPLE WHO HAD THE MORE SEVERE PROBLEMS ALSO EXPERIENCED MIL LIGHTING UP & CODE INDICATING ENGINE MISFIRE. I CALLED AMERICAN HONDA CORP SEVERAL TIMES. THE 1ST TIME WAS LIKE PULLING TEETH TO GET THEM TO ADMIT THEY KNEW ABOUT THIS ISSUE,...

DT*: THE CONTACT STATED THE ENGINE IDLED ERRATICALLY INTERMITTENTLY WHILE SLOWING DOWN AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE THE VALVE WAS REPLACED AT 99,000 MILES. AT 134,000 MILES THE CHECK ENGINE LIGHT ILLUMINATED UPON INITIAL ACCELERATION. THE VEHICLE WAS RETURNED TO THE MECHANIC, WHO DETERMINED THERE WAS A PROBLEM WITH THE ENGINE HEAD. THE VALVE MELTED INTO THE NUMBER 3 CYLINDER. THE ENGINE HEAD NEEDS TO BE REPLACED. THERE IS A NHTSA ACTION NUMBER 10008524 FOR THE ENGINE.

MY 2001 HONDA CRV HAD TO HAVE THE CYLINDER HEAD REPLACED AFTER A FLASHING ENGINE LIGHT CAME ON. A HONDA DEALER STATED THERE WAS LOW COMPRESSION IN THE #3 CYLINDER. THE REPAIR WAS TO REPLACE THE CYLINDER HEAD (AT >3200$). I FOUND THAT THIS IS A COMMON PROBLEM WITH 1999-2001 HONDA CRVS. I NOW HAVE AT LEAST 5 SUBSTANTIATED CASES (MY OWN, A COLLEAGUE WHO OWNS A 1999 CRV AND, THE COMPLAINT NUMBERS ON YOUR SITE 10062616, 10124224, 10143720). THERE ARE ALSO MANY UNSUBSTANTIATED BUT IDENTICAL CLAIMS ON MULTIPLE WEBSITES THAT IMPLY A FAIRLY WIDESPREAD MANUFACTURERS DEFECT LEADING TO THIS PROBLEM. THE SYMPTOMS ARE THE SAME. HONDA APPEARS TO KNOW OF THIS DEFECT AS EVIDENCED BY THEIR OWN TSB #03-038 THAT STATES THE PROBLEM AND REPAIR. I ASKED HONDA FOR A GOODWILL WARRANTY (THERE IS SOME PRECEDENCE FOR THIS BY HONDA). I WAS TOLD I WOULD NEED COMPLETE SERVICE RECORDS...

2001 HONDA CR-V. CAR STALLS WHILE IDLING. RISK OF BEING REAR-ENDED WHEN IT OCCURS AT A SIGNAL AND THE LIGHT TURNS GREEN, OR IF I AM IN THE #1 LANE WAITING TO MAKE A LEFT-TURN. HONDA CORP. IS AWARE THAT THEIR 99-01 CR-V MODELS HAVE CYLINDER HEAD PROBLEMS THAT CAUSE THIS, BUT THEY ARE NOT OFFERING TO COVER THE $3000 NEEDED TO REPLACE THE CYLINDER HEAD.

HONDA CRV 2001, AIR CONDITIONER PROBLEMS . *BF DURING AN OIL CHANGE, THE CONSUMER WAS INFORMED THAT THE ENGINE OIL DIP STICK CONTAINER HAD DETACHED FROM THE MOTOR AND BROKEN AT THE ENGINE BLOCK. THE CONSUMER WAS TOLD THE OIL DIP STICK HAD BEEN TAMPERED WITH AND WAS NOT COVERED UNDER WARRANTY. *JB

I'VE HAD TWO VALVE JOBS DONE ON MY 2001 CRV, ONCE AT AROUND 45,000 MILES AND THAN AGAIN AT 95,000 BOTH TIMES IT WAS THE NUMBER 3 VALVE THAT HAD TO BE REPLACED. THE OWNER'S MANUAL I HAVE INDICATES THAT THE VALVES NEED TO BE ADJUSTED AT 105,000 MILES BUT ACCORDING TO THE DEALER WHERE I HAD THE WORK DONE IT NEEDS TO BE DONE EVERY 15,000 MILES. I FIND THAT THIS TYPE OF MAINTENANCE ON A NON-PERFORMANCE CAR RIDICULOUS NOT TO MENTION EXPENSIVE AND TIME CONSUMING. *AK