2008 HARLEY-DAVIDSON FLHX Power Train Problems

WHILE RIDING ON THE FREEWAY AT 65 MPH THE CHECK ENGINE LIGHT CAME ON AND THE BIKE WENT INTO A 'LIMP' MODE ALL OF A SUDDEN AND WOULD NOT GO OVER 15-20 MPH. HAD TO CUT ACROSS TRAFFIC WITHOUT GETTING HIT TO GET TO THE SIDE OF THE ROAD. TURNED OFF BIKE AND IT RESET WAS ABLE TO MAKE IT HOME. RESEARCHED PROBLEM ON LINE AND HAVE SEEMS SIMILAR PROBLEMS WITH THIS YEAR AND IT'S BEING TRACED BAD PINS USED IN SOME OF THE CONNECTORS DURING THIS TIME.

RIDING MY FLHX THE OTHER DAY AND BIKE STARTED MAKING NOISE FROM MY PRIMARY AND I PULLED OVER AND CHECKED NOISE AND COMFIRMED IT WAS COMING FROM THE LEFT SIDE(PRIMARY). MADE IT HOME SAFE; WASN'T FAR FROM HOME. TOOK OFF THE PRIMARY COVER AND CHECKED OVER THE INNER PRIMARY COMPONENTS. THE COMPENSATOR AND ADJUSTER WERE BAD. DID SOME RESEARCH AND FOUND THAT THE AUTO-ADJUSTED CHAIN TENSIONER TIGHTENS SO BAD OVER TIME THAT IT RATCHETS ALL THE SPROKET PARTS DOWN SO BAD THAT IT STARTES TO CREATE WEAR ON COMPONENTS SO BAD THAT PARTS CAN BREAK LOOSE, LOCK UP, AND THE COMPONENTS IN MY YEAR FLHX ARE SEVERLY UNDER RATED. THIS COMPENSATOR WASN'T SUPPOSED TO BE USED FOR ANYTHING BIGGER THAN AN 80 CUBIC INCH MOTOR; MY BIKE CAME STOCK WITH A 96 CUBIC INCH MOTOR. FLHX IS PAST ANY WARRANTY, BUT THIS IS AN INCREASING PROBLEM THAT HARLEY SHOULD BE...

THE COMPENSATOR IS AN ISSUE WITH HARLEY THAT NEEDS TO BE ADDRESSED ON 2007 AND 2008 TWIN CAM BIKES. *TR

WHAT WE HAVE DISCOVERED IS THE COMPENSATOR SPROCKET HAS EITHER WORKED LOOSE OR IS CRACKED, THIS IS WITHIN THE SHAFT ASSEMBLY WHERE THE CLUTCH ASSEMBLY AND PRIMARY FINAL DRIVE IS LOCATED, HARLEY KNOWS THEY HAVE A PROBLEM WITH THIS, AND IT COULD RESULT IN THE DRIVE TRAIN LOCKING UP IF THE ASSEMBLY LOCKS UP OR SOMETHING COMES LOOSE AND CAUSES SUCH AN EVENT IT COULD LOCK UP THE REAR WHEEL AND CAUSE A CRASH I KNOW OF A FEW PEOPLE THAT ARE HAVING THIS SAME ISSUE, AND ALSO JUST FROM RESEARCH ONLINE THERE ARE A LOT OF MOTORCYCLES WITH THE SAME PROBLEM. *TR