1996 GMC JIMMY — Problems, Recalls & Safety Data

TL* THE CONTACT OWNS A 1996 GMC JIMMY. THE CONTACT STATED THAT THE REAR BRAKES FAILED AND THE ABS WARNING LIGHT WAS CONTINUOUSLY ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE REAR CYLINDERS NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE REMEDY FAILED TO REPAIR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE.

STOPPED AT LOCAL RESTAURANT, IGNITION WOULD NOT TURN OFF AND WE WERE UNABLE TO REMOVE THE KEY. AT THIS TIME, THE VEHICLE IS NOT DRIVEABLE AT ALL. WE ARE UNABLE TO START OR SHUT OFF THE VEHICLE. THE VEHICLE IS NOT RECOGNIZING THAT THE KEY IS IN THE IGNITION. ALL DASH LIGHTS ARE ON, BRAKES DO NOT WORK. THIS IS A SAFEY CONCERN. *TR

TL*THE CONTACT OWNS A 1996 GMC JIMMY. WHILE DRIVING AT 30 MPH, THE CONTACT HAD TO ABRUPTLY DEPRESS THE BRAKE PEDAL. HE THEN HEARD A GRINDING SOUND COMING FROM THE TIRES. THE BRAKES WERE CHANGED BY AN INDEPENDENT MECHANIC, BUT THE NOISE PERSISTED. AFTERWARDS, THE MASTER CYLINDER WAS REPAIRED AND THE BRAKES, ROTORS, AND PADS WERE REPLACED. THERE WAS A SLIGHT IMPROVEMENT; HOWEVER, THE NOISE EVENTUALLY RETURNED PERIODICALLY. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 125,000 AND CURRENT MILEAGE WAS 133,000.

I WAS DRIVING DOWN I-65 GOING TO WORK, 70 MPH. I LOOKED IN MY REAR VIEW MIRROR AND NOTICE A LARGE AMOUNT OF SMOKE COMING FROM MY 1995, GMC JIMMY, 104000 MILES. I LOOKED AT MY GAUGES AND SAW THAT I HAD NO OIL PRESSURE AND THE CHECK ENGINE LIGHT WAS ON. FORTUNATELY I WAS RIGHT AT AN EXIT. I GOT OFF THE INTERSTATE AND STOP AT A GAS STATION. ALL OF THESE EVENTS HAPPEN IN LESS THAN 5 MINUTES. WHEN I GO OUT I NOTICED ENGINE OIL ON THE OUTSIDE OF MY VEHICLE, DRIVER'S SIDE. I OPEN THE HOOD AND CHECKED THE OIL. NO OIL ON THE DIP STICK. LOOK UNDER THE VEHICLE AND NOTICE A LARGE PUDDLE OF OIL ON THE PARKING LOT. I CALL A WRECKER AND HAD MY TRUCK TOWED TO MY MECHANIC'S SHOP $85. MECHANIC TOLD ME THAT ONE OF THE OIL LINES RUNNING TO THE FILTER AND COOLER HAD FAILED WHERE THE FITTING IS CRIMPED TO THE LINE AND THAT MY ENGINE WAS ALMOST DEPLETED OF OIL. MY MECHANIC REPLACED THE LINE AND FILL THE VEHICLE BACK UP WITH OIL. HE SAID IT TOOK OVER FIVE MINUTES FOR THE VALVES TO QUIT RATTLING. THE REPAIR COST $212. WE DEBATED ON WHETHER TO CHANGE THE OTHER SET OF LINES. WE DECIDED TO WAIT A FEW WEEKS TO SEE IF ANY DAMAGE TO THE VEHICLE SHOWS UP. I AM OUT ALMOST $300 TO DATE, WITH ANOTHER $250 REPAIR WAITING OR A ENGINE TRASHED FROM THE FIRST EVENT. MY AFTER THE FACT WEB QUERIES INDICATE THAT THIS IS A COMMON FAILURE MODE OCCURRING IN ALMOST ALL JIMMIES AND BLAZERS. WHY HASN'T THERE BEEN A RECALL ON THIS PROBLEM? COATED THE HIGHWAY AND A PARKING LOT WITH ENGINE OIL. HAD I NOT SEEN THE SMOKE I WAS HEADED FOR A CATASTROPHIC FAILURE AT 70 MPH. I CONSIDER MYSELF EXTREMELY LUCKY TO HAVE SURVIVED THIS INCIDENT. I' WAS VERY UPSET KNOWING THAT THERE MANY VEHICLES ON THE ROAD EVERY DAY THAT WILL HAVE THIS PROBLEM SOMETIME IN THE VEHICLE'S LIFE CYCLE.*AK

RADIATOR SLUDGE/CORROSION. FLUSHED RADIATOR AND REPLACED THERMOSTAT. SLUDGE REAPPEARED AND CORRODED THERMOSTAT AGAIN. REPLACED RADIATOR AND OVER FLOW TANK PLUS ALL HOSES. SLUDGE AND CORROSION REAPPEARING AGAIN. *JB