1999 FORD RANGER Structurebody Problems

When washing the truck I noticed a crack in the left rear frame just aft of the forward leaf spring shackle.Vertical crack approx, 6" long and separating, frame severely rusted while the rest of the body has minimal rust.

MY VEHICLE IS OTHERWISE IN VERY GOOD CONDITION BUT TRY IS FRAME IS VERY WORRISOME. THE RUST MAKES ME AFRAID TO DRIVE THE VEHICLE CONFIDENTLY.

I WAS DRIVING WAS ABOUT 20 MPH AND HIT A SMALL POT HOLE. I HEARD A LOUD POP BANG NOISE AND THE LEFT SIDE OF TRUCK DROPPED ABOUT 2 OR 3 INCHES. I THOUGHT THE FRONT END FELL OFF. THE FRAME IS RUSTED SO BAD YOU CAN PUNCH HOLES IS THE FRAME WITH A SCREW DRIVER, THE DRIVER SIDE TORSION BAR HAS COLLAPSED DUE TO RUST ON THE FRAME THAT HOLDS IT IN PLACE, THE CROSSMEMBER TO TRANSMISSION IS BARLEY HOLDING TRANSMISSION UP, THE SPARE TIRE AREA IS RUSTED IN HALF, ALL MAIN CROSSMEMBERS ARE RUSTED IN HALF AND THE FRAME IS RUSTED IN HALF BEHIND FUEL TANK. TRUCK HAS 127K MILES AND THE BODY BODY HAS LITTLE TO NO RUST, UPPER AND LOWER CONTROL ARMS ARE UNSAFE FROM RUST. I DO NOT UNDERSTAND HOW THE BODY CAN BE SO GOOD BUT FRAME AND SUSPENSION IS COMPLETELY RUSTED TO NO...

I HAVE A 1999 FORD RANGER AND THE FRAME IS SHOT STARTING TO CRACK IT'S SO THIN AND LIKE POST I CAN ALMOST BEND IT WITH MY HANDS .

SPARE TIRE FELL OFF IN STREET, THEN GAS TANK, WHOLE FRAME IS ROTTEN, WAS DRIVING DOWN A ROAD,

THE FRAME IS RUSTING AWAY. BOTH LEAF SPRING SHACKLES RUSTED COMPLETELY THROUGH, MUFFLER HANGERS ALL RUSTED OFF LOST MY MUFFLER ON A ROAD.

FRAME RUST UNDER DRIVERS AND RIDERS DOORS. REST OF TRUCK LOOKS BEAUTIFUL AND I TAKE GREAT CARE OF THE TRUCK!!!

TL* THE CONTACT OWNS A 1999 FORD RANGER. WHILE INSPECTING THE VEHICLE, IT WAS DISCOVERED THAT THE REAR SECTION OF THE SUBFRAME WAS RUSTED AND CORRODED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 192,000.

DRIVERS SIDE FRAME HAS COMPLETELY RUSTED THROUGH. FOUND DURING INSPECTION.

REAR FRAME AND REAR CROSS MEMBER HAVE RUSTED OUT.. THE SPARE TIRE HOLDER IS UNUSABLE. VEHICLE SHOULD BE RECALLED FOR FRAME REPLACEMENT.

FRAME ROT... THE FRAME HAS RUSTED FROM THE INSIDE-OUT IN THE SAME PLACE ON BOTH SIDES OF THE VEHICLE: UNDER THE MOST-FRONT PART OF EACH DOOR (KEEP IN MIND THIS IS THE FRAME I'M TALKING ABOUT, NOT ANY KIND OF DOOR SUPPORT OR FRAMING... THIS IS THE SECTION OF BODY FRAME THAT IS LOCATED UNDERNEATH EACH DOOR ON THE VEHICLE). THE FRAME HAS RUSTED AND BEGUN TO SPLIT HORIZONTALLY (THE LENGTH OF THE VEHICLE) AND VERTICALLY (FROM THE GROUND-UP). WHEN LIFTING THE VEHICLE IN CERTAIN PLACES, THE FRAME CAN BE SEEN BENDING, OBVIOUSLY. BECAUSE OF THIS I CAN ONLY JACK/LIFT THE VEHICLE FROM THE VERY FRONT... ALL OTHER PLACES THAT I'VE TRIED TO LIFT FROM RESULT IN TOO MUCH WEIGHT BEING PUT ON THOSE WEAK POINTS. I AM NOW VERY SERIOUSLY CONSIDERING A NEW FRAME, WHICH IS A LOT OF MONEY... OR, AT THE VERY LEAST, A LOT OF TIME...

MY 1999 FORD RANGER JUST FAILED INSPECTION FOR STRUCTURAL REASONS. TRUCK RUNS PERFECT WITH ONLY 107K MILES ON IT. THE TRUCK IS ROTTING AWAY !! GAS TANK FALLING OFF. REAR BUMPER FALLING OFF. TAIL GATE ROTTED. SIGNIFICANT ROT IN FRAME AND SHOCKS. SPARE TIRE READY TO JUST FALL FROM CHEAP STRAP THAT IS ROTTED. THIS REALLY IS UNSAFE SITUATION. I CALLED FORD AND FILED COMPLAINT BUT WAS TOLD NOTHING THEY CAN DO. I WILL NEVER BUY ANOTHER FORD!! A HAPPY CUSTOMER TELLS 2 PEOPLE,AN UNHAPPY CUSTOMER TELLS 100 PEOPLE. I REALLY CAN NOT BELIEVE THESE VEHICLES WERE NOT RECALLED. VERY UNSAFE.

FRAME RUSTED INTO

TL* THE CONTACT OWNS A 1999 FORD RANGER. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST NEAR THE REAR FRAME CLOSE TO THE LEAF SPRINGS. THERE WAS ALSO EXCESSIVE RUST ON THE REAR PASSENGER SIDE. THE CONTACT FURTHER INSPECTED THE REAR FRAME AND DETERMINED THAT IT FRACTURED DUE TO THE FAILURE. THE VEHICLE HAS REMAINED PARKED IN THE CONTACT'S DRIVEWAY SINCE THE FAILURE WAS IDENTIFIED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 1999 FORD RANGER. WHILE THE VEHICLE WAS BEING INSPECTED, THE MECHANIC NOTICED THAT THE SUBFRAME WAS RUSTED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FRAME FELL OFF. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

THE BED IS RUSTING OFF THE FORD RANGER PT . TO WHERE , THE BED NEEDS TO BE REMOVED FROM THE BACK , AND REDONE !!! THIS VEHICLE WAS NOT MADE WELL FOR CUSUMERS PPL CAN'T ALWAYS AFFORD WHAT THE COMPANY HAS DONE . ITS NOT FAIR TOO PUT A VEHICLE OUT AND WE HAVE TO PAY OUT OF POCKET FOR FORDS POOR WORK WHEN MAKING THIS VEHICLE.

PERFORATED FRAME ON THE LEFT REAR FRAME NEAR THE FRONT OF THE LEAF SPRING, REAR FRAME HORN WHERE BUMPER ATTACHES IS PERFORATED ALSO. SECTIONS OF FRAME WILL HAVE TO BE WELDED IN TO KEEP VEHICLE IN A SAFE CONDITION.

THE FRAME AT THE RIGHT FRONT SUSPENSION POCKET RUSTED OUT. UPPER CONTROL ARM REAR BRACKET IS COMPLETELY DETACHED. DROVE THE TRUCK TO MY DESTINATION WITH NO ISSUES, ON THE RETURN TRIP IT FELT "FLOATY" AS IF IT WAS OUT OF ALIGNMENT WHILE I WAS DRIVING DOWN A TOWN ROAD. THERE WAS NO BUMP OR AUDIBLE NOISE PRIOR TO OR ACCOMPANYING THE ISSUE. BODY HAS VERY MINIMAL RUST, THE REST OF THE FRAME APPEARS SOLID. TRUCK HAS 104,660 MILES.

MY COMPLAINT IS JUST HOW RUSTED AWAY THE FRAME IS ON MY 1999 RANGER, THE BODY OF THE TRUCK IS REAL NICE. BUT THE FRAME IS RUSTING AWAY, THE REAR BUMPER BROKE OFF ON THE DRIVERS SIDE, THE SPARE TIRE CAN NO LONGER BE MOUNTED UNDERNEATH WHERE IT BELONGS, DUE TO THE RUST. THE FRAME RAIL HAS A FOOT LONG RUST HOLE ON THE PASSENGER SIDE AND THE DRIVERS SIDE RAIL IS CRACKED AND RUSTED ALMOST IN TWO PIECES. JUST SEEMS LIKE THE FRAME IS TOTALLY RUSTING AWAY, NEVER HAD A VEHICLE WITH THIS KIND OF RUST PROBLEM. I AFRAID TO DRIVE IT ON THE HIGHWAY.

FRAME AND FRAME SUPPORTS HAVE RUSTED QUICKLY OVER THE LAST FEW YEARS. MORE THAN I WOULD EXPECT.

MY FRAME IS RUSTING OUT! I WAS HAVING PROBLEMS FILLING MY GAS TANK SO I BROUGHT IT IN TO THE SHOP TO FIND THAT WHERE THE GAS TANK SUPPORTS ATTACHED TO THE FRAME HAD RUSTED OUT. MY GAS TANK WAS HANGING ON BY A THREAD. I HAD TO HAVE THE WHOLE THING REMOVED, REPAIRED, AND REPLACED.

MY 1999 FORD RANGER FRAME IS RUSTING IN SEVERAL LOCATION WHICH WILL MAKE IT VERY UNSAFE THE BODY LOOKS BRAND NEW BUT THE FRONT FRAME AND REAR FRAME ARE RUSTING AWAY. THE SHOCKS ON THE FRONT RIGHT SIDE ARE ABOUT THE BREAK THROUGH THE SUPPORT AND THE UPPER CONTROL ARM IS ABOUT THE BREAK OFF.

UPON INSPECTION MECHANIC SAID "SHACKLES , FRAME, LEAFSPRINGS, ALL RUSTED AND TRUCK WILL NOT LAST. MOTOR RUNS GREAT, BODY NO RUST.

I HAVE SEEN MULTIPLE 99 FORD RANGER, AND EVERY ONE I HAVE SEEN IS RUSTED OUT. FRAME, REAR BUMPER & BED. THERE ARE OTHER PLACES RUSTED BUT NOT AS BAD AS THE FRAME, RUSTED IN HALF, REAR BUMPER FELL OFF GOING DOWN THE ROAD, OTHER THINGA THAT BOLT UNDER THE BED FELL OUT. *TR

FOR THE SECOND TIME AS FAR AS I KNOW THE REAR FRAME (REAR SPRING SHACKLES AND SPEAR TIRE HOLDER SPECIFICALLY) HAVE AND ARE BEING REPLACED BECAUSE THEY HAVE RUSTED AND THEY TORE APART. AS I WAS DRIVING I HIT A REGULAR BUMP IN THE ROAD. I WAS DRIVING ABOUT 35 TO 45 MPH ON THE WAY TO WORK. WELL IT SOUNDED LIKE IT HIT PRETTY HARD, AS I WAS DRIVING I NOTICED THE TRUCKS PERFORMANCE WAS LACKING. SO, WENT TO WORK, GOT OUT OF WORK AND ON THE WAY BACK HOME I NOTICED THE SAMETHING WITH THE PERFORMANCE OF THE TRUCK. IT WAS LACKING IN A BIG WAY. AS I WAS PULLING INTO THE DRIVEWAY I HEARD A LARGE CLUNK SOUND. THE NEXT DAY I HAD A PRIOR APPOINTMENT AT MY TRANSMISSION SHOP. AS THE MECHANICS PUT IT ON THE LIFT "THE REAR AXLE DROPPED TO THE FULL EXTENT OF...

I TRIED TO GET MY 99 RANGER INSPECTED WHEN THEY PUT IT ON THE LIFT A BIG CHUNK OF THE FRAME FELL TO THE GROUND .UPON FURTHER INSPECTION THERE WERE HOLES IN THE RIGHT SIDE FRAME NEXT TO THE REAR SPRING SHACKLES AND THE GAS TANK STRAPS WERE RUSTED OUT OF THE FRAME .THE GARAGE OWNER TAPED THE FRAME WITH A BALL PEEN HAMMER AND FOUND MORE HOLES ON THE LEFT SIDE AND THE RIGHT FRONT UNDER THE AIR CONDITIONER .I COULD NOT DRIVE THE TRUCK HOME IT WAS SO UNSAFE I CAN'T BELIEVE THE FRAME DID NOT BRAKE WHEN I WAS DRIVING IT .IF I WAS TO GET INTO AN ACCIDENT WITH THE TRUCK IN THAT CONDITION THE FRAME WOULD HAVE CRUMPLED UP LIKE TIN FOIL .READING THE COMPLAINTS HERE I'M NOT ALONE .THE TRUCK WAS TAKEN CARE OF WASHED ALL THE TIME IF FORD IS GOING TO SELL...

I NOTICED HEAVY RUST SCALE ON GROUND AND INSPECTED TO SEE MY SPARE TIRE WAS MISSING, THERE IS A LARGE HOLE RUSTED ALL THE WAY THRU THE FRAME IN FRONT OF THE LEFT REAR SPRING SHACKLE AND A CRACK IN THE FRAME IN FRONT OF THE FRONT SHACKLE ALMOST ALL THE WAY AROUND THE CHANNEL. FURTHER INVESTIGATION SHOWED ALL CROSS MEMBERS, GAS TANK STRAP AND BED SUPPORTS ARE SEVERELY RUSTED AND THE RIGHT SIDE FRAME RAIL FOLLOWING SUIT WITH THE LEFT FRAME RAIL. THE REMAINDER OF THE TRUCK IS IN VERY GOOD CONDITION THIS SHOULD NOT HAPPEN TO A TRUCK WITH THIS AGE AND MILEAGE. *TR

STRUCTURE, FRAME RUSTED, FRONT BUMPER RUSTED FROM INSIDE. REAR SPRING SUPORT RUSTED. GAS FILLER DOOR RUSTED. *TR

TL* THE CONTACT OWNS A 1999 FORD RANGER. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE INSPECTED, THE TECHNICIAN FOUND RUST ON THE FRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS CONFIRMED THAT THE FRAME WAS SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 158,000. UPDATED 11/13/12 *CN THE CONSUMER STATED THE FRAME ON THE REAR SHACKLE RUSTED AWAY; THE REAR BUMER ON THE LEFT SIDE FELL OFF FRON THE RUST ON THE FRAME. THERE IS NOTHING TO WELD ON THE METAL IS THAT BAD. UPDATED 11/28/2012 *JS

I WAS DRIVING IN THE FREEWAY I-275 NB NOF HOWARD AVENUE TAMPA FLORIDA I HEARD A NOISE TO THE FRONT OF SMALL TRUCK, AFTER THAT I SAW BLACK SMOKE FROM FRONT OF TRUCK I PUT TO CAR A SAFETY PLACE OF THE FREEWAY OF TRUCK IS TURN OFF ITSELF. I HAVE NOT TIME TAKE OFF OF KEYS FROM OF TRUCK OF ONLY TIME IS TOOK MY BAGS ,OPEN THE DOOR AND GET OUT THE TRUCK AND ALL CONTENTS WERE BURNED IN THE FIRE. ADDITIONAL I HAVE THE TRUCK FOR 4 MONTHS AGO ONLY AND I NEED TO HELP, BECAUSE I HAVE INSURANCE BUT ONLY LIABILITY COVERAGE AND NO FULL COVER, IN WHICH I HAVE TO CONTINUE TO PAY TO THE DEALER $6,000 DOLLARS FROM MY POCKET. THANK YOU FOR YOUR ATTENTION FOR MY CASE. BUT THANK YOU SO MUCH TO MY GOD A STILL WITH LIVE AND MY BOYFRIEND. THANK...

1999 FORD RANGER WITH 130,000 MILES. LEAF SPRINGS RUSTED OUT (BOTH SIDES) AND MOUNTING BRACKETS ALSO RUSTED. WENT TO 3 AUTOBODY SHOPS AND NOBODY WOULD TOUCH IT. BUMPER JUST RUSTED OUT ON BOTH SIDES AND SPARE TIRE WELL IS COMPLETELY RUSTED. BUMPER AND SPARE CURRENTLY BEING HELD TOGETHER WITH 2, 1900 LB CHAINS. RANGER RUNS FINE JUST BODY FALLING APART. VERY CONCERNED TIRE, BUMPER MAY BECOME DISLODGED AND CAUSE FURTHER DAMAGE TO MYSELF OR OTHERS. GAS TANK ALSO RUSTED BUT NOT LEAKING SO FAR. *TR

THE SPARE TIRE WAS NOTICED TO BE MISSING AND THE REAR BUMPER WAS FOUND TO HAVE EXTREMELY WEAK MOUNTING. UPON INSPECTION THE ENTIRE REAR SECTION OF THE FRAME HAD SEVERE RUST THRU. THE BELL SHAPED PIECE THAT HOLDS THE SPARE TIRE UNDER THE TRUCK HAD RUSTED AND COLLAPSED. THE SPARE TIRE FELL FROM THE VEHICLE AT AN UNKNOWN DATE AND SPEED. THE CROSS MEMBER HOLDING UP THE FUEL TAKE WAS EXTREMELY RUSTED, AND WOULD HAVE FAILED IN THE NEAR FUTURE. THE FRAME AT THE REAR BUMPER MOUNTING LOCATION WAS RUSTED AND WOULD HAVE CAUSED THE REAR BUMPER TO DETACH FROM VEHICLE IN THE NEAR FUTURE. THE RIGHT SIDE SHOCK MOUNT WAS RUSTED COMPLETELY OFF. THE SPARE TIRE HAD FALLEN, WHICH COULD HAVE CAUSED AN ACCIDENT, AND THE GAS TANK AND REAR BUMPER WERE CLOSE TO FALLING OFF, WHICH WOULD HAVE ALSO CAUSED AN ACCIDENT. *TR

THE FRAME KEEPS CRACKING AT THE PASSENGERS SIDE SHOCK MOUNT AND WORKING ITS WAY TO THE FRONT OF THE TRUCK. I HAVE WELDED IT SEVERAL TIMES IN THE PAST 2 MONTHS AND CRACKING IN DIFFERENT SPOTS. ALOT OF PEOPLE ARE HAVING THE SAME PROBLEMS.MY FRAME IS ABOUT TO SNAP IN HALF. THE TRUCK ONLY HAS 124,000 MILES ON IT. ITS PRETTY MUCH THE SAME AS TOYOTA'S FRAME RECALL. *TT

EXCESSIVE UNDER CARRIAGE/FRAME RUST. SPARE TIRE MOUNT RUSTED COMPLETELY THROUGH AND FELL OFF AT 30,000 MILES. LADDER FRAME CROSS MEMBERS COMPLETELY RUSTED THROUGH AND FELL OFF AFTER 35000, FRONT PART OF LADDER FRAME WHERE ENGINE MOUNTS IS RUSTED 80% THROUGH BY 41,000 MILES. MOST OF FRAME IS HEAVILY DAMAGED BY EXCESSIVE RUST. UPPER BODY LOOKS FINE, NO RUST ON MAIN BODY, ONLY UNDER CARRIAGE AND FRAME. VEHICLE IS ABOUT TO COLLAPSE. *TR

TL* THE CONTACT OWNS A 1999 FORD RANGER. THE CONTACT STATED THAT THE REAR FRAME WAS CORRODING AND THE BUMPER COULD FALL OFF. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSIS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND CURRENT MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

THE FRAME NEAR MY BACK WHEELS IS COMPLETELY RUSTED OUT AND THERE IS NOW A BIG CRACK ON BOTH SIDES OF THE FRAME. THE RUST AMOUNTS ARE EXCESSIVE, AND IN MY OPINION SEEM TO BE A FAILURE IN DESIGN OF THE FRAME. THE TRUCK HAS ONLY 105,000 MILES ON IT AND THE FRAME IN THAT SECTION OF THE CAR HAS SERIOUS RUST WHILE THE REST OF THE CAR LOOKS GOOD. ALL OF THE CONNECTIONS IN THE BACK HAVE A LOT OF RUST, MORE THAN CAN BE ATTRIBUTED TO POOR MAINTENANCE. IF I HADN'T SEEN THIS CRACK DEVELOPING IN THE FRAME A SERIOUS ACCIDENT COULD HAVE RESULTED. I FEEL FORD SHOULD BE HELD ACCOUNTABLE FOR A FAULTY PRODUCT

LEFT SIDE OF FRAME RAIL RUSTED THROUGH TO THE POINT FRAME IS ALMOST BROKE IN HALF ON LEFT REAR PORTION JUST AHEAD OF REAR AXLE. SWAY ARM WAS ALSO CONNECTED TO THIS PART OF FRAME. LARGE PORTION OF FRAME RAIL IS MISSING, (APPROXIMATELY 6X6") WHICH HAS RENDERED TRUCK USELESS & UNSAFE TO DRIVE. LAST YEAR BOTH REAR SPRING SHACKLES HAD TO BE REPLACED OR REAR AXLE WAS GOING TO FALL OUT. UNTIL NOW THIS VEHICLE WAS IN EXCELLENT CONDITION.

I FEEL THAT MY FORD RANGER IS AN UNSAFE VEHICLE. I HAVE HAD MANY PROBLEMS WITH IT SINCE I BOUGHT IT BRAND NEW. EVERYTHING STEMMING FROM HOLES IN THE FLOOR TO A FAULTY TRANSMISSION AND ENGINE AMONG FAULTY POWER WINDOWS AND ELECTRICAL ON MORE THAN ONE OCCASION.. I JUST WONDER WHAT IS NEXT. I AM WORRIED ABOUT THE FUTURE OF THIS VEHICLE ESPECIALLY WITH ITS PAST TRACK RECORD. PLEASE SEND ME ANY INFORMATION THAT MAY BE OF HELP TO GET FORD TO BUY MY VEHICLE BACK. MY EMAIL IS [email protected] OR [email protected].

DASHBOARD FELL OUT. MJS