1994 FORD RANGER Electrical Systemignition Problems

7 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Electrical Systemignition Issues in the 1994 FORD RANGER

7 electrical systemignition complaints have been filed with NHTSA for the 1994 FORD RANGER. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Electrical Systemignition Complaints

#768941 | November 4, 2002

2 YRS AGO TRUCK BEGAN NOT RE-STARTING AFTER ENGINE TURNED OFF FOR APPROX. 20 MINUTES. WOULD EVENTUALLY RE-START, 30 MINUTES TO 1 HR LATER. IN APRIL 2002 TRUCK STARTED DYING ON THE FREEWAY AND IN RUSH HOUR TRAFFIC 10-60 MPH. NOW IT DIES WHETHER HOT OR COLD, MOVING OR AT STOPLIGHT. ON FREEWAY THIS PROBLEM IS VERY SERIOUS AS ONE MUST TRY AND MAKE THEIR WAY TO THE SHOULDER BEFORE VEHICLE QUITS ROLLING. OTHER CARS SWERVE AND BLARE HORNS. RESTARTS IN VARIOUS INTERVALS 20 MINUTES TO 2 HRS. HAMMOND FORD FOUND NO PROBLEM (AT $100 AN HOUR) SWANSON FORD, LOS GATOS, CA FOUND NO PROBLEM AND SAID THERE WERE NO SERVICE OR RECALL NOTES FOR THIS PROBLEM. (ALSO $100 AN HOUR) HAVE REPLACED IGNITION MODULE AND FUEL PUMP RELAY. PROBLEM CONTINUES. SOMETHING WHICH HELPS RESTART SOONER PULL OUT AND COOL DOWN THE FUEL PUMP RELAY, THEN PLUG BACK IN. NOW...

#753714 | November 1, 2001

THE TRUCK WOULD STALL UNEXPECTEDLY DURING COLD WEATHER RUNNING. THE PROBLEM BEGAN APPROXIMATELY TWO YEARS AFTER MY PURCHASE. THE PROBLEM WAS DIAGNOSED AS AN IGNITION MODULE WHICH WAS REPLACED, BUT I WAS NOT CONVINCED THAT WAS THE ENTIRE PROBLEM. THREE MONTHS LATER IT OCCURRED AGIN ON A ROAD TRIP. PRIOR TO THE TRIP FROM SALT LAKE CITY TO CANADA, I WROTE A LETTER TO THE V.P OF CUSTOMER COMMUNICATIONS AND SATISFACTION EXPLAINING THE DANGER OF THE SAME COMPONENT FAILURE IF ONE WERE TRAVELING ON A REMOTE HIGHWAY IN A COLD ENVIRONMENT. I EXPLAINED THAT ONE COULD DIE OF HYPOTHERMIA AND SUGGESTED THEY FIND THE REAL CAUSE OF THE PROBLEM. THEY REFUSED. MY FORESIGHT WAS EXACTLY CORRECT. THE VEHICLE STALLED IN THE MIDDLE OF A BLIZZARD IN MONTANA AND IF I AND MY TRAVELING COMPANION WERE NOT IN GOOD PHYSICAL SHAPE WE BOTH WOULD HAVE DIED. AFTER WAITING IN THE VEHICLE...

#745759 | May 25, 2001

ENGINE SIMPLY QUIT AND IT WILL RESTART LATER. I'VE REPLACED TIMING BELT, IGNITION SYSTEM, FUEL FILTER, FUEL PUMP, DISTRIBUTOR STROBE AND IT CONTINUES TO STALL IN TRAFFIC, WHEN HOT OR COLD

#740047 | February 2, 2001

I HAVE A 1994 FORD RANGER. A JUDGE IN CALIFORNIA HAS ORDERD A RECALL OF A LOT OF FORD VEHICLES FOR STALLING. THE PROBLEM IS WITH THE THICK FILM IGNITION (TFI) WHICH REGULATES CURRENT GOING TO THE SPARK PLUGS. SINCE THE TFI IS MOUNTED ON THE DISTRIBUTOR, IT HEATS UP AND FAILS. THIS IS A VERY DANGEROUS BECAUSE THIS CAUSES STALLS AT ANY SPEED -- EVEN HIGHWAY SPEEDS! THE RECALL WILL BE FOR UP TO '93 RANGERS, BUT I HAVE THE EXACT PROBLEMS STATED IN MANY ARTICLES: - HTTP://WWW.COOLCATS.NET/TFIWARNING.HTML , - HTTP://WWW.ABCNEWS.GO.COM/SECTIONS/US/DAILYNEWS/FORD_RECALL001011. I HAVE TAKEN MY RANGER TO THE DEALER SERVICE AND THEY REPLACED THE ELECTRONIC IGNITION MODULE AND A FUEL PUMP RELAY. I TOLD THEM ABOUT THE TFI DEAL AND THEY INSIST THAT'S NOT THE PROBLEM. - WHAT DO I DO? I FEAR FOR MY LIFE. *AK

#736834 | November 29, 2000

THERE CURRENTLY IS A RECALL FOR FORD RANGERS UP THROUGH 1993'S. MINE IS A 1994 AND HAS THE SAME EXACT PROBLEM. THE RECALL STATES THE ELECTRICAL IGNITION SYSTEM WAS MOUNTED INCORRECTLY NEAR THE ENGINE AND CAUSES THE ENGINE TO STALL. MY RANGER HAS THIS PROBLEM AND I WANT FORD TO INCLUDE THE 1994 RANGER IN THIS RECALL.*AK

#874379 | November 3, 2000

WHILE DRIVING ABOUT 30 MPH WHEEL WILL LOCKUP. THEN, ENGINE WILL STALL WITHOUT A PRIOR WARNING. THIS HAS HAD HAPPENED A COUPLE OF TIMES, AND ALWAYS HAD HAPPENED ON LOW SPEED.*AK

#719282 | February 25, 2000

WHEN IT RAINS, THE DISTRIBUTOR SYSTEM UNDER TRUCK HOOD GETS WETS AND TRUCK WILL NOT START UNTIL IT DRIES OUT. ONE CAN ONLY GUESS THAT THERE IS A DESIGN PROBLEM WITH THE SEAL THAT DOES NOT KEEP RAIN OUT. THIS HAS OCCURRED FOLLOWING MODERATE OVERNIGHT RAIN. *AK

Other 1994 FORD RANGER Problem Areas

← Back to 1994 FORD RANGER overview