2003 FORD FOCUS Structure Problems

2003 FORD FOCUS. CONSUMER WRITES IN REGARDS TO INADEQUATE STRUCTURAL STEEL. *LD THE CONSUMER STATED THE STEEL ON THE CONTROL ARMS WERE POORLY MANUFACTURED. WHILE DRIVING THE VEHICLE, IT SUDDENLY DEAD STOPPED, TURNED RIGHT, MAKING A CRACKING NOISE. THE CONTROL ARM HAD SNAPPED AND DUG INTO THE TAR, BRAKING THE TIE ROD AND CREASING THE BREAKLINE. *JS

IN MARCH 2013 I TOOK MY FORD FOCUS IN TO REPLACE MOTOR MOUNTS, RETURNED IN APRIL FOR THE SAME AWFUL VIBRATION WHILE HEATER WAS ON AND WHILE IDLING. THE MECHANIC CHECKED AND FOUND THAT ONE OF THE MOTOR MOUNTS WAS FAULTY AND HE REPLACED. I AM TAKING MY FOCUS BACK FOR THE THIRD TIME BECAUSE IT IS STILL VIBRATING WHILE IN IDLE WHILE THE AC IS ON. THE FIRST FEW TIMES AFTER HE REPLACED THE FAULTY MOTOR MOUNT IT DID THE SAME THING AND THE MECHANIC TOLD ME THAT IT'LL JUST RUN LIKE THAT AND THAT HE RAN A DIAGNOSTIC AND THE TRANSMISSION, ALL MOUNTS LOOK GOOD. AND MY SOMETIMES MY STEERING IS OFF AT 35 MILES PER HOUR. I ONLY USE MY FOCUS FOR IN TOWN I DON'T USE TO TRAVEL OUT OF CITY OR STATE. I AM NOT A MECHANIC BUT I AM DISABLED AND I NEED MY...

THIS VEHICLE IS A TOTAL LEMON.AT 4,900 MILES 5 DISC CD PLAYER HAD TO BE REPLACED. AT 15,000 MILES THE VEHICLE BEGAN LEAKING COOLANT AND HAD TO HAVE THE RADIATOR REPLACED, LUCKILY IT WAS STILL UNDER WARRANTY. AT 22,000 THE VEHICLE NEEDED A NEW ALTERNATOR BECAUSE IT WOULD NOT CRANK. AT 24,000 MILES THE KEY BECAME STUCK IN THE IGNITION AND WOULD NOT EVEN TURN OVER SO THE IGNITION WAS REPLACED. 26,000 THE CENTER CONSOLE BROKE OF HINGES. 27,356 MILES THE CAR WOULD NOT TURN OVER THE STARTER HAD TO BE REPLACED.32,000 MILES THE AIR CONDITIONER WENT OUT. 36,000 MILES ALTERNATOR WENT OUT AGAIN AND HAD TO BE REPLACED.38,000 MILES COMPLICATIONS WITH THE AIR CONDITIONER AGAIN. HAD NO PROBLEMS UNTIL 54,000 THEN EVERYTHING SPIRALED OUT OF CONTROL. THE WATER PUMP WENT OUT, THE PUMP HOUSING WAS LEAKING. THE STARTER COIL WAS BAD A FEW FUSES HAD BLOWN THAT I HADN'T...

I HAVE BEEN IN THE WRECKER BUSINESS FOR 20 YEARS, THIS BEING THE SECOND FORD FOCUS INVOLVED IN AN ACCIDENT THIS YEAR. I HAVE NOTICED THAT THIS VEHICLE DOES NOT PERFORM ADEQUATELY WHEN INVOLVED IN A CRASH, THEREFORE PUTTING THE PASSENGERS AT RISK OF SEVERE INJURY OR DEATH. THE DRIVER OF THE VEHICLE MENTIONED ABOVE LOST CONTROL, AND SLID SIDEWAYS INTO ONCOMING TRAFFIC RESULTING IN AN IMPACT TO THE PASSENGER DOOR AND RESULTED IN A FATALITY OF THE DRIVER..THE AREA OF PROTECTION SURROUNDING THE PASSENGER COMPARTMENT IS INADEQUATE IN THAT IT DOES NOT PROVIDE SAFETY UPON IMPACT. THIS BEING THE SECOND FOCUS TOWED RECENTLY, IT HAS BECOME APARENT TO ME THAT THESE LIGHT WEIGNT VEHICLES PROPOSE A SAFETY HAZARD TO THE PUBLIC AND SHOULD BE RE-EXAMINED. *TR

WHEN ACCELERATING AT LOW SPEEDS, TURNING AND DRIVING SPEED BUMPS A HORRIBLE RATTLING, VIBRATION, METAL ON METAL SOUND IS HEARD INSIDE THE CARE ON THE PASSENGER SIDE BEHIND GLOVE BOX. CONTINUES TO GET WORSE AND 2 AAA APPROVED MECHANICS COULD NOT FIND IT. *TR

THE CAR HAS BEEN HAVING ISSUES WITH THE LOCKS FOR A WHILE NOW. WE CAN NOT PUT THE KEY INTO THE DOOR TO UNLOCK IT BECAUSE IT WONT ALWAYS WORK. THE HANDLE ON THE FRONT DRIVER SIDE DOOR HAS BROKE ONCE AND WAS REPLACED. NOW THE KEY FOR THE IGNITION WILL NOT TURN TO START THE CAR. THE STEERING WHEEL HAS LOCKED AND WILL NOT ALLOW THE KEY TO TURN TO START THE CAR. *TR

I BOUGHT FORD FOCUS 2003 AT 38,000 (CERTIFIED PRE-OWNED) FROM PREMIER FORD INC IN BROOKLYN, NY IN 5/04, HAD MASSIVE LEAKING OF WATER DURING AND AFTER RAIN A MONTH LATER IN 6/04. THIS WAS REPAIRED BY DEALERSHIP BECAUSE IT WAS UNDER 90 DAY WARRANTY. IT WAS FINE UNTIL THIS MONTH 12/05 AND IS NOW AGAIN SOAKING MY PASSENGER FLOOR WHEN IT RAINS OR SNOWS. I TOOK TO DEALERSHIP, THEY SAID THEY CANNOT REPAIR IT - TAKE IT DOWN THE STREET WHERE THEY "ALWAYS TAKE IT FOR THIS PROBLEM ANYWAY". I CALLED FORD, THEY SAID IT MAY BE COVERED UNDER MY EXTENDED WARRANTY, BUT THE DEALERSHIP NEEDS TO DIAGNOSE THE PROBLEM. APPARENTLY, THIS IS A VERY COMMON PROBLEM WITH FORD FOCUS' ACCORDING TO THE DEALERSHIP AND FROM MANY POSTINGS ONLINE I HAVE FOUND. IT SEEMS TO BE A STRUCTURAL DESIGN DEFECT IN THE DASH CAUSING MASSIVE FLOODING INTO THE CAR AND...

ON ANY RAINY DAYS THE FLOOR ON THE FRONT PASSENGER'S SIDE LEAKS WATER. DEALERSIP WAS NOTIFIED. *AK

THE SUN'S REFLECTION ON THE DIAL SYSTEM MADE IT HARD TO SEE THE SPEEDOMETER. THE CONSUMER CONSIDERED THIS TO BE A SAFETY CONCERN. *AK *SCC *JB