2019 FORD FIESTA Engine Problems

The contact owns a 2019 Ford Fiesta. The contact stated that after refueling the vehicle, the contact attempted to start the vehicle, but the vehicle jerked and was difficult to start. The check engine warning light was illuminated. The contact stated that the failure had occurred on several occasions but was moderate whenever a lower amount of fuel was added to the vehicle. The vehicle was taken to an independent mechanic who was unable to determine the cause of the failure. The vehicle was taken to another independent mechanic, where the check engine warning light was turned off, but the failure persisted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.

•Make: Ford •Model: Fiesta ST •Model Year: 2019 •Engine: 1.6L EcoBoost •Mileage at Incident: 95000 Component Affected: Engine / Cooling System Summary of Problem: Coolant is leaking into the combustion chamber of my 1.6L EcoBoost engine due to a suspected internal engine defect. This issue caused noticeable white smoke from the exhaust, engine misfires, and a loss of power while driving. The coolant loss was not visible externally, indicating internal leakage. After diagnostic testing at a Ford dealership, I was informed the engine block or cylinder head is compromised, allowing coolant intrusion into the cylinders. The dealer quoted approximately $12,000 for a full engine replacement and confirmed that this is a known issue with Ford EcoBoost engines. Safety Concerns: The vehicle became unreliable and unsafe to drive, especially at highway speeds, due to the misfiring and sudden power loss. If this failure had occurred during certain driving conditions, it could...

The incident happened on November 1, 2023, and the complaint is on a 2019 Ford Fiesta with approximately 22,700 miles and still covered under the power train warranty. A family member and I were driving and I started to feel nauseous, and had difficulty thinking clearly. This improved once exiting the vehicle. My family member experienced the same symptoms of nausea and difficulty thinking when driving, and additionally had a headache. This was improved by rolling down the windows. The vehicle was taken to Pearson Ford in Zionsville, Indiana and was found to have a cracked exhaust manifold with exhaust fumes leaking into the cabin. This was deemed a premature part failure of the exhaust manifold, as there was no damage done to the vehicle and the vehicle having low miles, approximately 22,700. The dealer agreed to replace the exhaust manifold under warranty, but had to order the part. Repair...

The contact owns a 2019 Ford Fiesta. The contact stated while at a complete stop at the traffic light, the vehicle inadvertently lunged forward and crashed into the rear of another occupied vehicle. There was no warning light illuminated. The air bags did not deploy. There were no injuries sustained. A police report was filed. The contact was able to continue driving. An unknown dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

Catastrophic Engine Failure due to the manufacturer's recommendation and use of conventional motor oils in the form of Synthetic Blend Motor Oil or Super Premium Motor Oil, a specification WSS-M2C945-B1 , from the 2019 Ford Fiesta Owner Manual. It leaves the driver and occupants stranded in the middle of the road with an inoperable vehicle. Being a small 4 cylinder engine the engine is high revving and produces sludge. Whereas if the manufacturer recommended Full Synthetic oil as the car parts store do as part of the oils usable for that specific model. There would have been no engine failure as occurred with my vehicle on 11/22/2022. No sludge would form in the engine. Because synthetic oil is proven not produce any sludge in an engine. I believe a recall should result in the manufacturer recommending full synthetic in the owner manual and engine oil be replaced by dealer service...

In SEP-2021, the engine overheating warning light came on. We stopped the car and realized that the coolant level in the overflow reservoir was very low. There was no obvious leak on the ground or on the engine. We purchased coolant and topped off the coolant reservoir to the appropriate level. A couple of weeks later, we noticed again that the coolant level had gone down significantly while there was no sign of coolant whatsoever on the floor of the garage. We dropped off the car at our local Ford dealer on 20-OCT-2022 for a diagnosis. On OCT-22, the service department confirmed that the engine had overheated and that the head gasket had blown and informed us they would contact Ford to discuss the repair. Further feedback from the dealership was that they would need to tear down the engine at Ford's request for further investigation. We received a loaner...

Purge valve canister failed on my 2019 Ford Fiesta. I only mention this, because 2012-2018 Ford Focus models had a recall that was similar, and my Purge Valve Canister went out after 1 year and approximately 60,000 miles.

TL* THE CONTACT OWNS A 2019 FORD FIESTA. WHILE DRIVING 20 MPH, THE VEHICLE FAILED TO DECELERATE WHEN THE ACCELERATOR PEDAL WAS RELEASED. THE CONTACT STATED THAT THE ENGINE RPMS WERE AT 1,100. WHEN THE BRAKE PEDAL WAS DEPRESSED, THERE WAS A DELAY, THE VEHICLE CONTINUED TO MOVE FORWARD, AND THE RPMS DROPPED TO 750. THE VEHICLE WAS TAKEN TO DAVE SMITH FORD (LOCATED AT 4045 TRANSIT RD, WILLIAMSVILLE, NY 14221, (716) 634-2000) WHERE IT WAS DIAGNOSED THAT THERE WAS COMPUTER FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 5,100. *BF *AS