1997 FORD F SERIES Engine And Engine Coolingengine Problems

1. LOSS OF COOLANT 2. PRESSURE TEST SHOWED FRONT GASKET LEAKING 3.FRONT GASKET REPLACED AT COST OF $1000.00 , MAY HAVE LOWER INTAKE GASKET LEAK NOW, ALL COMMON SERVICE ISSUE , NEEDS TO BE RECALLED. *JB

I DIDN'T REALLY NOTICE ANYTHING JUST ONE DAY MY ENGINE STARTED MAKING LOUD KNOCKING SOUND TOOK IT IN FOR SERVICING AND FOUND OUT I SPUN A ROD I REPLACED THE ENGINE. *JB

CONSUMER REQUEST A RESPONSE TO A QUESTION HE SUBMITTED TO NHTSA RE THE 4.6 LITER ENGINE EXPLODING IN HIS 1997 FORD F-SERIES PICKUP TRUCK. *MR THE VEHICLE'S ENGINE EXPLODED AS THE CONSUMER TURNED THE KEY IN THE IGNITION. *NM

97 F150 BEGAN TO HAVE AN UNPREDICTABLE COOLANT LEAK, NEVER GOING BELOW MINIMUM COOLANT LEVEL. WITHIN THE WEEK NOTICED WATER IN THE OIL AND WENT TO TAKE THE VEHICLE TO A SERVICE STATION. WHEN I STARTED THE TRUCK THERE WAS A LOUD KNOCKING, PROVING TO BE A DAMAGED ROD. LATER RESEARCH SHOWED THAT THIS IS COMMON IN THE 4.2 LITER V-6 ENGINE DUE TO FAULTY GASKET. FORD RAN A "CAMPAIGN," BUT I NEVER RECEIVED ANY NOTIFICATION AS TO THE PROBLEM. *JB

FIRE STARTED IN ENGINE AREA AFTER BEING PARKED FOR APPROXIMATELY 2 HOURS. VEHICLE AT A COMPLETE LOSS. FIREFIGHTERS COULD NOT DETERMINE CAUSE OF FIRE OTHER THAN IT ORIGINATING IN MIDDLE OF ENGINE COMPARTMENT. *NLM

ENGINE FAILURE AT 73000 MILES, FOLLOWED ALL FORDS RECOMMENDED MAINTENANCE. *JB