2006 FORD F-650 SD — Problems, Recalls & Safety Data
N/A
Safety Rating
3
Owner Complaints
0
Recalls
7
Service Bulletins
0
Investigations
Overview of the 2006 FORD F-650 SD
The 2006 FORD F-650 SD has received a total of 3 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). 7 technical service bulletins have been issued by Ford Motor Company for this model year. The most commonly reported problems involve the Engine And Engine Cooling (1 complaint), Fuel System Diesel (1 complaint), and Suspensionfrontwheel Bearing (1 complaint).
Recalls for the 2006 FORD F-650 SD
There are no recalls on file with NHTSA for the 2006 FORD F-650 SD. No Active Recalls
Owner Complaints for the 2006 FORD F-650 SD
3 complaints have been filed with NHTSA for the 2006 FORD F-650 SD. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Engine And Engine Cooling | 1 | 0 | 0 | 0 | 0 |
| Fuel System Diesel | 1 | 0 | 0 | 0 | 0 |
| Suspensionfrontwheel Bearing | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
The contact owns a 2006 Ford F-650 SD. The contact stated that he had noticed a leak coming from the vehicle. Upon inspection, the contact discovered that the fuel injector was leaking. Upon further investigation, the contact linked the failure to NHTSA Campaign Number: 08E042000 (Engine and Engine Cooling) however, the vehicle was not included. The manufacturer had been notified of the failure and the contact was informed that his vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 57,000.
TL*THE CONTACT OWNS A 2006 FORD F-650 SD. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PURCHASED, IT BEGAN MISSTEPPING AND LOST POWER. IN MARCH OF 2007, THE FUEL TANKS FAILED AND HAD TO BE REPLACED. HE LEARNED AT THAT TIME THAT THE FUEL TANKS WERE DETERIORATING AND BURNED THE FUEL TANKS FROM THE INSIDE OUT. THE FUEL TANKS WERE REPLACED. ON AUGUST 23, 2007, THE FUEL TANKS FAILED AGAIN AND THE VEHICLE WAS TOWED TO THE DEALER. THE CONTACT STATED THAT THE FUEL TANKS WERE REPLACED WITH THE SAME DEFECTIVE FUEL TANKS. THE VIN, PURCHASE DATE, AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 80,000.
WE BOUGHT 2- F 650 ROLL BACKS AND THEY BOTH HAVE BEEN IN SHOP 3 TIMES FOR WHEEL BEARINGS TO BE REPLACED, TIRES WEARING BAD SPOTS IN THEM BECAUSE OF THIS, CARRIER BEARING WENT OUT, AND NOW ONE OF THEM THE AXLE BROKE AND IS IN SHOP AND IT ONLY HAS 34000 MILES ON IT. IT HAS HAD A BAD VIBRATION IN THEM SINCE WE BOUGHT THEM, THAT IS WHAT WE TOOK THEM TO SHOP FOR.*JB
Safety Rating for the 2006 FORD F-650 SD
NHTSA has not yet tested the 2006 FORD F-650 SD in its New Car Assessment Program.
Technical Service Bulletins for the 2006 FORD F-650 SD
Ford Motor Company has issued 7 technical service bulletins (TSBs) for the 2006 FORD F-650 SD. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
19375 — ENGINE AND ENGINE COOLING:ENGINE
WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
061811 — ENGINE AND ENGINE COOLING:ENGINE
SERVICE CALIBRATION UPDATE - LOSS OF RPM ON DECELERATION - 6.8L. *KB UPDATED 07-25-07. *KB
061910 — ENGINE AND ENGINE COOLING:ENGINE
CHECK ENGINE LIGHT ON, AND/OR STOP ENGINE LIGHT ON. CUMMINS ENGINES ONLY. *KB
06151 — STEERING: STEERING WHEEL/HANDLE BAR
STEERING WHEEL OSCILLATION. *KB
06239 — ENGINE AND ENGINE COOLING:ENGINE
HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP. *KB
07515 — ENGINE AND ENGINE COOLING:ENGINE
6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
07112 — ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
NHTSA Investigations for the 2006 FORD F-650 SD
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the FORD F-650 SD
- 2004 FORD F-650 SD — 12 complaints
- 2005 FORD F-650 SD — 6 complaints
- 2006 FORD F-650 SD (current)
- 2007 FORD F-650 SD — 5 complaints
- 2008 FORD F-650 SD — 2 complaints
- 2009 FORD F-650 SD — 1 complaint
- 2010 FORD F-650 SD — 0 complaints
- 2011 FORD F-650 SD — 1 complaint
Other FORD Models
- FORD F-150 — 45,660 total complaints
- FORD EXPLORER — 42,140 total complaints
- FORD ESCAPE — 34,654 total complaints
- FORD FOCUS — 29,539 total complaints
- FORD FUSION — 28,243 total complaints
- FORD TAURUS — 23,867 total complaints
- FORD WINDSTAR — 19,456 total complaints
- FORD EDGE — 17,247 total complaints