2008 FORD F-450 SD Engine And Engine Coolingexhaust System Problems

2008 FORD F-450 BASED TYPE I AMBULANCE. CONTACT ALLEGES THAT IMPROPER MANUFACTURING OF 6.4L POWERSTROKE DIESEL ENGINE CYLINDER NUMBER 8 RESULTED IN REDUCED COMPRESSION AND EXCESSIVE BLOW BY OF COMBUSTION GASES AND PARTICULATE MATTER. REPORTED CONSEQUENCE INCLUDES ENGINE STALL, REDUCED POWER, NO START CONDITION, EXHAUST GAS TEMPERATURE SENSOR CONTAMINATION AND CATASTROPHIC TURBOCHARGER DAMAGE. ENGINE PROBLEMS HAD NEGATIVE IMPACT ON DELIVERY OF AMBULANCE SERVICES.

OVER THE LAST TWO YEARS, OUR 2008 FORD F-450 HAS BEEN INTO FORD SERVICE SEVERAL TIMES RELATED TO THE EMISSIONS CONTROL SYSTEM. SPECIFICALLY THE REGENERATION PROCESS. THE TRUCK GOES INTO THE REGENERATION MODE AND OVER THE LAST WEEK HAS INSTANTANEOUSLY SHUT THE ENGINE, BRAKING, AND STEERING SYSTEMS DOWN WITHOUT SO MUCH AS A 5 SECOND WARNING. THUS, CAUSING IMMEDIATE DANGER TO MYSELF AND MY FAMILIES HEALTH, SAFETY, AND LIFE (ALONG WITH OTHERS ON THE HIGHWAY).WITH THIS VEHICLE, WHEN THIS HAS OCCURRED, WE WERE TOWING AN 15K POUND, 40 FOOT FIFTH WHEEL. PACIFIC FORD, LONG BEACH, CA WAS CONTACTED WITHIN 10 MINUTES OF THIS OCCURRING. THE SERVICE CENTER AT THIS DEALERSHIPS ADVISE TO US WAS TO "BABY" THE TRUCK. WE JUST GOT THE TRUCK BACK AFTER TWO WEEKS AT THE DEALERSHIP FOR THE REGENERATION ISSUE, WHERE THEY COULDN'T IDENTIFY ANYTHING WRONG WITH THE TRUCK. THIS IS EXTREMELY DANGEROUS TO MY FAMILY...

INJECTORS TURBO EXHAUST AND ALOT MORE PROBLEMS, BEEN TOWED 6 TIMES BEEN TO THE DEALER OVER 30 TIMES WENT THROUGH LEMON LAW DIDN'T QUALIFY VEHICLE TO HEAVY. *TR

DRIVING AS NORMAL ON FWY HEARD A LOUD NOISE THOUGHT I GOT A FLAT. STOPPED VEHICLE ON SHOULDER, BRAKING WAS DIFFICULT AND WHITE SMOKE WAS AROUND THE CAR. I GOT OUT AND DID NOT SEE ANY FLAT TIRES BUT I SAW SMOKE BETWEEN THE CAB AND BED OF THE TRUCK. I RAN BACK TO THE DRIVER DOOR AND SAW A SMALL FIRE ON THE FLOOR NEXT TO THE 4X4 SHIFTER FOR THE TRANSFER CASE. I IMMEDIATELY GRABBED MY 3 YEAR OLD DAUGHTER FROM HER CAR SEAT AS THE CAB FILLED WITH SMOKE AND RAN APPROXIMATELY 300 FEET AWAY AND TOLD MY DAUGHTER TO STAY. I JUMPED INTO THE BACK OF THE TRUCK GRABBED A LARGE FIRE EXTINGUISHER AND DISCHARGED IT INTO THE HOLE IN THE FLOORBOARD NEXT TO THE TRANSFER CASE IT WENT OUT AND IMMEDIATELY CAME STARTED UP AGAIN. I THEN CALLED 911. SOME PEOPLE STOPPED AND HELPED ME...

TL*THE CONTACT OWNS A 2008 FORD F-450. THE CONTACT HAS OWNED THE VEHICLE FOR SEVEN MONTHS AND HAS REPLACED THE RADIATOR SEVEN TIMES DUE TO AN OIL LEAK. THE TURBOS FAILED AND THE EXHAUST SYSTEM CRACKED IN HALF. THE VEHICLE FAILS TO ACCELERATE. THE CONTACT TOOK THE VEHICLE TO TWO DIFFERENT DEALERS. ONE STATED THAT A NEW ENGINE WAS NEEDED, BUT THE OTHER DISAGREED. THE VEHICLE IS CURRENTLY PARKED AND UNABLE TO BE DRIVEN. THE CONTACT FILED A COMPLAINT WITH HIS CONSUMER PROTECTION AGENCY REGARDING THE LEMON LAW. HE ALSO CALLED THE MANUFACTURER, BUT THEY REFUSED TO TOUCH THE VEHICLE. THE FAILURE MILEAGE WAS 45,675.