2004 FORD F-350 Engine Problems

While driving at 40-50 MPH the vehicle will lose power and then then stalls while moving leading to loss of power. The loss power of affects the power steering posing a direct threat for an auto collision due to the difficult in steering the moving vehicle into an emergency lane. Avoided several accidents with this truck. Once it is stalled it can take numerous times to restart the vehicle. This issue seems to occur more on slopes going up hill. This does not seem to occur as often going downhill or on areas with no incline. Currently vehicle has 126,931.8 miles on it. Regularly serviced and otherwise running fine.

MY TRUCK HAS MAJOR ENGINE DAMAGE BOUGHT IT AND THREE DAYS LATER THE EGR WENT OUT THEN NEXT THING YOU KNOW I GOT A BLOWN MOTOR

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. ALSO, WHILE IDLING, THE ENGINE RPMS REMAINED VERY HIGH AND THE VEHICLE WOULD ATTEMPT TO SURGE FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE ICP SENSOR AND INJECTOR CONTROL SENSOR, BUT THE FAILURES CONTINUED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER TO A COMPLETE STOP. THE VEHICLE WAS STARTED NORMALLY, BUT STALLED AGAIN THE SAME AFTERNOON. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 05V270000 (ENGINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,307.

TL*THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT OIL WAS LEAKING FROM THE HEAD GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 210,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 37,237.

MY VEHICLE HAS BEEN BUCKING AND JERKING INTERMITTENTLY SINCE WAY BEFORE ABOVE.DATE IT STOPPED RUNNING AT A STOP SIGN THEN BUCKED AND JERKED SO IN 2013 IT GOT SO BAD THAT I FINALLY HAD IT CHECKED OUT. I THOUGHT IT WAS TRANSMISSION, HAD IT CHECKED AND WAS REFERRED TO LOCAL MECHANIC WHO WAS ACQUAINTED WITH THE PROBLEM AND HAS WORKED ON SEVERAL TRUCKS WITH THE 6.0 DIESEL ENGINE. HE SAID FOR $1200 YOU MIGHT REPAIR IT, NO GUARANTEES. HE SAID IT HAD TO DO WITH THE ELECTRONIC ACCELERATOR. I DIDN'T HAVE IT REPAIRED. IN AUGUST 2014 IT STOPPED AND JERKED AT STOPS SIGN MORE THAN ONCE. I TOOK IT TO THE SAME MECHANIC AND HE REPLACED A SENSOR LOCATED UNDER THE TURBO, FOR $600, AND THAT SOLVED THAT PROBLEM. IN OCTOBER 2014 I WAS TOWING A TRAILER AND THE TRUCK WOULD NOT SHIFT INTO 4TH GEAR. I STOPPED AND RESTARTED...

CAM POSITION SENSOR FAILURE, VEHICLE WILL NOT START, FOUND COOLANT IN OIL ON REPAIR. *TR

CRACKED HEAD, RESULTING IN COOLANT IN ENGINE OIL, HARD STARTING OR FAILURE TO START. *TR

VEHICLE HARD STARTING CAUSED BY FAILURE OF HIGH PRESSURE OIL PUMP, REPLACED ICP REGULATOR, REPLACED EGR VALVE AND INTAKE GASKETS. *TR

CHECK ENGINE LIGHT/NO POWER/HARD STARTING- REPLACED EXHAUST BACK PRESSURE SENSOR- VEHICLE FAILURE OF AMBULANCE RESPONDING TO A CALL. *TR

WHILE DRIVING VEHICLE HAS INTERMITTENT LOSS OF POWER, DIAGNOSED AND SERVICED EGR VALVE, REPLACED EGR THROTTLE VALVE AND SEALED THE BOOST INLET TUBE. *TR

VEHICLE WILL NOT START, CRANKS BUT DOES NOT START. DIAGNOSED AND REPLACED CAM POSITION SENSOR. *TR

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE WOULD SUDDENLY HESITATE AND THE SPEED WOULD DECELERATE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE INJECTOR CONTROL PRESSURE SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

FOR UNKNOWN REASONS ON 12/20/13 AT 0030 HRS MY TRUCK CAUGHT ON FIRE AS IT SAT IN MY DRIVEWAY. I DROVE THE TRUCK LAST ON 12/14/13. THE FIRE STARTED IN THE ENGINE COMPARTMENT ON THE DRIVERS SIDE. I HAVE OWNED THE TRUCK FOR ABOUT 8 MONTHS AND IT HAD 105000 MILES ON IT WHEN I PURCHASED IT. THE FIRE DEPARTMENT ADVISED IT COULD BE DUE TO SOME TYPE OF ELECTRICAL ISSUE NEAR THE MASTER CYLINDER. I TOLD THEM THAT I HAVE NOT DONE ANY WORK UNDER THE HOOD IN MONTHS AND THAT WAS OIL/FILTER CHANGE. STILL UNDER INVESTIGATION. *TR

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 65 MPH. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE AN INDEPENDENT MECHANIC PERFORMED A DIAGNOSTIC. THE FAILURE WAS LOCATED AT THE FUEL INJECTION PRESSURE SENSOR. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 85,000.