2022 FORD F-350 SD Electrical System Problems

The contact owns a 2022 Ford F-350 SD. While driving at an undisclosed speed and hauling a trailer, there was a delay with the trailer brakes before the trailer brakes engaged, causing the braking distance to be extended. Occasionally, the trailer brakes failed to engage, causing the electric brakes to activate and stop the vehicle. The contact became aware of NHTSA Campaign Number: 25V132000 (Electrical System) on the NHTSA.GOV website, which referenced a similar failure. The dealer was made aware of the failure. The dealer informed the contact that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall. The manufacturer opened a case for the failure; however, no assistance was provided. The failure mileage was approximately 94,000.

Synce 4 infotainment center with loose connection to phone causing phone to connect and disconnect and become statickey while driving. Ford dealerships when contacted do not have a fix and two dealers have said its a very common issue but no fix for it. safety risk is that while you think your hands free on the phone when it goes in and out of connection can cause a major distraction while driving. I have had two dealers provide feedback that this is an issue but not one that has a fix that they can do. It has not been inspected by police or insurance agent there is no warning lamps that have gone off

The contact owns a 2022 Ford F-350. The contact stated that while stopped at a traffic signal with his foot on the brake pedal, the vehicle suddenly accelerated as if he had applied the accelerator. The contact stated that his vehicle front end crashed into the rear end of the vehicle. The contact stated that he turned the vehicle off to stop it from continuing to gain forward momentum. The contact stated that he was able to restart the vehicle and pulled over. The contact stated that his lower front bumper was dented and had scratches. The contact stated that the vehicle he had crashed into had damage to the tail gate and rear bumper. The contact stated that no one was injured and both vehicles were able to drive away. The police were not called. The contact stated that prior to the crash the vehicle was having multiple electrical...

Loss of power to trailer brakes. Lights work, brakes get no power. Tested at plug on truck, no brake power, fuses checked, all still good. No messages for disconnected trailer.

My truck is only 3 years old. However about 3 months ago I noticed my rear view camera quit working. I only get a black or blue screen. Every other camera still works. I know there are over 1 million ford vehicles with this exact same issue that are under a recall. I would like to know why mine is not. I do not think it is fair I have to pay to repair an issue that’s covered by over 1 million other Ford vehicles.

1 month ago my vehicle intermittently would not shut off. You could hit the Start/Stop button and from all dash board appearances the truck was off, but the truck was still running. I resorted to pulling a circuit breaker to get the truck off. I found NHTSA 10226938 and replaced the Battery Junction Box as prescribed. This fixed the vehicle for a few weeks, but now the issue is back. There is no water intrusion in the BSB junction box.

my back rear view camera quit working immediately about 4 or 4 weeks ago. I tried to see if I had a loose wire but. One seemed loose or broken. I only have a blue screen. My rear facing camera over the cab stop light works fine if the switch is pushed. Now I have noticed there are thousands of Ford vehicles already recalled for rear camera issues. However when I called my dealership I was told I’m not on the recall list. As far as I can tell it’s because my Ford F350 is a 2022 built in July of 2021. I hate to say it but I believe the recall needs to be expanded. As I’m sure there are a whole lot more vehicles with this rear camera issues. Please take this case into consideration and hopefully get it included in the recall.

The contact owns a 2022 Ford F-350 SD. The contact stated that while depressing the brake pedal, the trailer brakes failed to assist with slowing the vehicle. The message that the trailer was disconnected was displayed on the instrument panel. The vehicle was taken to the dealer however, the vehicle was not diagnosed. The vehicle was not repaired. The contact became aware of NHTSA Campaign Number: 22V193000 (Electrical System); however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the VIN was not included in NHTSA Campaign Number: 22V193000 (Electrical System). The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 102,195.

Minor issue started during heavy rain last week, went out in morning and power steps would not function. After starting, the rear sliding window opened and would not shut. Researched solution and reset the steps in the computer. Let truck sit for 5 hours at work (not raining) and apparently circuit dried out and window was able to close. Fast forward to Thursday night (4/1), flood rains had started. On the way home from work, the rear sliding window started opening again by itself, but was able to close it with the switch. It did this several times. Went out to start the truck Friday evening and all i got was flickering lights that dimmed when the start button was pushed. No controls worked. By Saturrday morning, there was no lights or any control. all electronics are non-functional. I checked and the batteries are fully charged, so it is not...

I had a trailer hooked to my truck. while driving down the road the tailgate came down by it's self. not knoing it was down there was damage to the tailgate $4,400.00 worth risk is not being able to turn.ford in baraboo wi looked at as well as my insurance. no warning lamps or message came on

The contact owns a 2022 Ford F-350 SD. The contact stated that while hauling a horse trailer and driving approximately 65 MPH, the rear tailgate door erroneously opened. The contact stated that the failure had occurred on several occasions. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The failure mileage was 25,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? Transfer case shift motor failure, transmission slipping in 3,2,1 gear and when accelerating from 7-8 gear. Electronics on dash have gone out while driving multiple times. Tailgate opened up while driving multiple times. Trailer brake. Drivers side faulty window (glass) fracture across entire window when not moving. Yes, all can be inspected or paper work reviewed for repairs complete. How was your safety or the safety of others put at risk? Could not use 4 wheel drive in icy/snowy conditions to get to destination. Transmission slipping caused my foot to come off brake pedal and immediately had to reengage brake pedal due to the force of the transmission slipping (like the transmission was falling out from under the truck), nearly hitting the car in front of me on both occasions. Has the problem been reproduced...

Trailer brake control module shorts out intermittently causing trailer brakes to not work. This causes the vehicle and trailer to not be able to stop on time in a short distance. Dealer has confirmed that this is the issue. Error message is “trailer wiring fault” and “trailer disconnected” while driving with trailer attached.

The vehicle has a Gross Combined Weight Rating (GCWR) of 30,000 LBS. While towing, the vehicle would show on the dash at intermittent times "Trailer not connected." When this occurs, the trailer brakes are no longer operating placing all braking on the tow vehicle with the potential for brake fade or complete brake failure and catastrophic loss. This intermittent failure of the electrical brake system does not occur on other tow vehicles that were equipped with after-market brake controllers, such as Tekonsha. The vehicle was brought into the Ford Dealership to look into the issue. Ford had the truck for nearly two weeks and could not figure out the problem. After much self-research, it was determined that the factory installed brake controller cannot discriminate between trailers using electric brakes and trailers using electric/hydraulic brakes. The fix is to install an actuator (ETrailer Code DX35FR - Adapter Module for BrakeRite Electric...

The contact owns a 2022 Ford F-350 SD. The contact stated while driving 65 MPH with the trailer hitched to the vehicle, the vehicle downshifted suddenly to 37 MPH. There was no warning light illuminated. The passenger's side of the trailer went sideways and blocked the roadway; however, the trailed remained hitched to the vehicle. The contact then disengaged the towing mode and was able to drive the trailer into a ditch in order to clear the roadway. The contact then drove to his residence. The vehicle was taken to the dealer where the integrated trailer brake control module software was updated under NHTSA Campaign Number: 22V193000 (Electrical System). Additionally, the contact stated that there was no oil in the rear axle differential. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 5,800.