2001 FORD F-350 SD Engine And Engine Coolingenginediesel Problems

2001 FORD F350 CAUGHT ON FIRE UNATTENDED IN THE DRIVEWAY. *TR

2001 FORD F-350 CAUGHT FIRE WHILE PARKED. AUTHORITIES CALLED THE FIRE DEPARTMENT TO COME EXTINGUISH THE FIRE. *KB THE CONSUMER STATED HE PREVIOUSLY HAD SOME WIRING REPAIRS MADE TO THE FUSE BOX GOING TO THE REAR LIGHTS, BECAUSE THE WIRING HAD MELTED. (OHIO TRAFFIC CRASH REPORT # 10-0110-50)*JB SENT IN ADDITIONAL VOQ. *KB UPDATED 04/14/08. *KB THE CONSUMER ALSO STATED THE FRONT WHEEL BEARING HAD FAILED PRIOR TO THE FIRE.

TL*THE CONTACT OWNS A 2001 FORD F350 SUPER DUTY. WHILE ACCELERATING TO 65 MPH, THE VEHICLE STALLED AND COULD NOT BE RESTARTED. THE VEHICLE IS CURRENTLY LOCATED ON THE SIDE OF THE ROAD WHERE THE FAILURE OCCURRED. THE CONTACT WAS UNABLE TO GET THE VEHICLE TO THE DEALER FOR SERVICE. THE FAILURE AND CURRENT MILEAGES WERE 165,638.

1.EVENTS - TAKING A TRIP FROM WASILLA, AK TO FAIRBANKS, AK (300 MILE TRIP) TEMP STARTED AT 28 DEG AT WASILLA -47 IN FAIRBANKS. AFTER ABOUT 150 MILES THE TRUCK STUTTER A FEW TIMES AFTER ABOUT 200 MILES THE TRUCK DIED. WOULD NOT START NOTHING. WAITED FOR ABOUT 20 MIN (IN -27DEG WEATHER) THEN THE TRUCK STARTED UP AND I GOT ABOUT ANOTHER 25 MILES NOW IT WAS ABOUT -32 SOMEONE PULLED OVER TO LET MY KIDS KEEP WARM THREE GIRLS AGES 2, 4, 6 AND LET ME TAKE WARM UP BRAKES IN THERE CAR WHILE I TRIED TO FIND OUT WHAT WAS FAILING. I HAD A CODE READER WITH ME. IT SHOWED NO CODES. THEN SOME GUY PULLED OVER HE WAS DRIVING A FORD AS WELL. BUT HE CARRIED A EXTRA C.P.S. WITH HIM AND THE TOOLS. 2.FAILURE AND CONSEQUENCES- THE FAILURE WAS A CPS IN THE 2001 F-350...

MY CAM POSITION SENSOR ON THE DIESEL ENGINE WENT BAD FOR THE THIRD TIME. MILEAGE IS 90,000. LAST TIME I LOST STEERING AND BRAKES WHILE PULLING A TRAILER AND WAS ALMOST REAR ENDED BY CARS COMING ONTO THE FREEWAY ON RAMP. THIS TIME IT WAS GOING DOWN A HILL AND I GAINED SPEED AND ALMOST LOST THE TRUCK OVER A CORNER BEFORE COMING TO A FLAT AREA. IM AFRAID TO DRIVE THIS TRUCK NOW AND ITS NOT FAIR CONSIDERING WHAT I PAID FOR IT. ALMOST EVERY DIESEL OWNER I KNOW HAS HAD AT LEAST ONE CPS FAILURE. I CAME TO REST UP AGAINST SOME TREE LIMBS AND HAVE SCRATCHED PAINT---IT COULD HAVE BEEN MUCH WORSE. *TR SEE ALSO 10153677. *DSY.

I HAVE SEVERAL COMPLAINTS WITH MY TRUCK....ALL OF WHICH WERE POTENTIAL SAFETY RISK. FIRST WAS THE TRANSMISSION FAILURE MINE AND MY DAD'S ,BOTH FAILED AT SIMILAR TIMES AT IDENTICAL TRUCKS. -AFTER FORD GAVE US THE RUN AROUND WE TOOK THE TRUCKS TO A REPAIR SHOP AND HAD TRANSMISSIONS FIXED.....NOTE THAT THE FAILURE OF THE COAST CLUTCH IN TRANSMISSIONS PREVENTED THE TRUCKS FROM ENGINE BREAKING. THIS WAS PARTICULARLY SERIOUS WHEN TOWING, WHICH WAS WHAT THIS TRUCK WAS MADE FOR. MY DAD FOUND OUT THE TRANSMISSION FAILED ON HIS WAY DOWN A MOUNTAIN PASS IN COLORADO PULLING A 11,000 POUND FIFTH WHEEL. THE NEXT COMPLAINT WAS REGARDING THE CAM POSITION SENSOR, WHICH FAILED FASTER THAN CAN REPLACED. THE NEXT COMPLAINT WAS ABOUT THE BRAKE SYSTEM. I HAVE DEALT WITH DEALERSHIPS TIME AND TIME AGAIN TO TRY TO RESOLVE THE PROBLEM, AND THEY COULDN'T DO IT, SO I FIXED IT MYSELF! THE PROBLEM...

2001 FORD F350 SUPER DUTY 7.3 DIESEL TRUCK. ENGINE STALLS WITH OUT WARNING, RESULTING IN LOST OF STEERING, AND BRAKING CONTROL. OCCURS FREQUENTLY. *JB

CPS- CAM POSITION SENSOR FAILURES. 2001 F350 7.3 POWERSTROKE. WHILE DRIVING THRU A CONSTRUCTION ZONE ON I-40 WESTBOUND, TRUCK JUST DIED. LUCKILY I WAS ABLE TO GET OFF THE ROAD WITH OUT BEING RUN OVER BY EXTREMELY HEAVY TRAFFIC. TRUCK WAS TOWED TO FORD DEALER AND THE TECHNICIAN SAID TRUCK DIED TO CPS FAILURE. 02/2005. CPS FAILURE AGAIN,04/18/2007 BUT THANK GOD THIS TIME IT WAS IN THE INTEL PARKING LOT. I HAD TRUCK TOWED HOME. 107 DOLLARS FOR CPS. REPLACED CPS AND TRUCK IS ONCE AGAIN RUNNING FINE. FORD CORPORATION IS FULLY AWARE OF THIS PROBLEM WITH THIS SENSOR AND WILL DO NOTHING ABOUT IT. THIS IS A EXTREMELY DANGEROUS PROBLEM THAT COULD HAVE ENDED TRAGICALLY FOR ME. *TR

THE CPS ON MY F-350 FORD HAS GONE OUT NOW TWO DIFFERENT TIMES. THIS IS A PART THAT SHOULDN'T BE FAILING ALL THE TIME. BOTH TIMES I WAS TOWING TRAILERS AND HAD A HARD TIME GETTING THE TRUCK TO STOP WHEN THE ENGINE TURNED OFF. *JB

MY FORD F-350 DIESEL JUST HAD THE CAM POSITION SENSOR GO OUT FOR THE THIRD TIME! I WAS HEADING DOWN HILL AND LOST POWER STEERING AND PARTIAL BRAKES. I WAS TOWING A SMALL TRAILER THAT HAD ELECTRIC BRAKES AND USED THOSE TO STOP US OR WE PROBABLY WOULD HAVE ALL DIED. ALMOST ALL THE DIESEL OWNERS I KNOW HAVE HAD THESE CPS'S GO BAD. HOW CAN FORD GET AWAY WITH THIS? IM AFRAID TO DRIVE THE TRUCK AGAIN. *JB SEE ALSO 10191279. *DSY

(1) ON 13 DEC 06 TRUCK (APPROXIMATELY 57000 MILES ON VEHICLE) QUIT RUNNING ON MAIN ARTERY, NO LEADING SYMPTOMS (2) HAD TRUCK SERVICED AT BLACK FOREST AUTO CENTER (LOCAL) AND REPLACE CPS- CAM POSITIONING SENSOR (3) TRUCK RUNS FINE...THIS IS THE SECOND. *JB

HIGH PRESSURE OIL PUMP SPRAYING OIL ALL OVER THE ROAD UNTIL VEHICLE QUIT RUNNING. FIRST TIME WAS AROUND 10,000 MILES- THEY PUT AND O-RING IN THIS TIME AND WITH IN ANOTHER 10,000 MILES IT DID IT AGAIN- THIS TIME THEY REPLACED THE PUMP AND IT LASTED UNTIL VEHICLE HAD 36,000 MILES AND IT DID IT AGAIN - THEY REPLACED THE O-RINGS AGAIN AND THIS TIME IT MADE IT TILL IT HAD 68,000 MILES AND IT DUMPED ABOUT 15 QUARTS OF OIL ON THE ROAD AGAIN. THIS TIME THE OIL PUMP BLEW APART. THIS IS 4 TIMES THIS VEHICLE HAS DONE THE SAME THING. THIS OIL PUMP IS WHAT MAKES THE FUEL GO TO THE CYLINDERS AND KEEPING THE ENGINE RUNNING, NO OIL PRESSURE AND THE ENGINE SHUTS DOWN IN THE MIDDLE OF THE ROAD WITHOUT WARNING. I HAVE MECHANIZED FOR 20 YEARS WITH UPS AND HAVE A KNOWLEDGE OF ENGINES...

2001 FORD F350 7.3 DIESEL. TRUCK STALLS WITHOUT WARNING CAUSING LOSS OF POWER, POWER STEERING AND BRAKES. HAS HAPPENED 3 TIMES IN LAST 7 DAYS. I LOST CONTROL OF TRUCK AND HIT A CURB FROM STALL. READ ON INTERNET TO REPLACE CAM SENSOR. I REPLACED SENSOR ON 10/6/06 *JB

CPS FAILURE ON A FORD DIESEL. *NM

MY F-350 SUPER DUTY DIESEL SUDDENLY SHUT DOWN WHILE DRIVING DURING RUSH HOUR WITHOUT ANY WARNING, LOSING TOTAL POWER: POWER STEERING AND BRAKES. NOT BEING ABLE TO MOVE IT DUE TO TRAFFIC AND SINCE IT WOULDN'T START POLICE WERE NOTIFIED SO THAT AN ACCIDENT WOULD NOT OCCUR. EVENTUALLY IT WAS TOWED TO A NEAR BY PARKING LOT AND THEN TOWED DIRECTLY TO THE DEALER WHERE THEY NOTIFIED ME THAT MY CAM SENSOR WAS BAD AND NEEDED TO BE REPLACED. NOT THINKING MUCH OF IT A FEW DAYS LATER SOMEONE TOLD ME THAT THEY ARE KNOWN FOR GOING BAD AND I HAD BETTER KEEP ONE IN MY GLOVE BOX AS A SPARE OR I MIGHT FIND MYSELF STRANDED AGAIN. THIS CONCERNS ME SINCE MY WIFE SOMETIMES DRIVES IT AND WE HAVE 3 CHILDREN, NOT TO MENTION THAT IT COST ME $420.00. *JB

I OWN A 2001 FORD F-350 7.3 LITER DIESEL TRUCK. LAST MONTH I WAS PULLING A TRAILER IN HEAVY TRAFFIC WHEN MY ENGINE DIED. I LOST BRAKES AND STEERING. IT WAS ALL I COULD DO TO FIGHT THE WHEEL OVER TO THE RIGHT AND I USED MY ELECTRIC TRAILER BRAKES TO PULL ME DOWN. WE WERE ALMOST HIT BY MANY CARS. AFTER BEING TOWED, WE FOUND THAT IT WAS A BAD CAM POSITION SENSOR, OR CPS. I HAVE SINCE SPOKEN TO OTHER FORD OWNERS AND MANY OF THEM HAVE HAD SIMILAR EXPERIENCES. THIS IS SCARY! I AM NOW AFRAID TO DRIVE THE TRUCK, ESPECIALLY TO PULL A LOAD. WHAT CAN BE DONE? THANKS. *JB SEE ALSO 10191279. *DSY

THE CPS ON THE VEHICLE FAILED THREE TIMES. TWO OF THE THREE FAILURES LEFT ME STRANDED FOR OVER TWO HOURS WHILE WAITING FOR FORD ROADSIDE ASSISTANCE TO RECOVER THE VEHICLE. THE FREQUENCY OF THE PROBLEM HAS CAUSED ME TO NOW CARRY A SPARE CPS IN MY GLOVEBOX IN THE EVENT OF A FUTURE FAILURE. *NM

I HAVE A 2001 FORD F-350 WITH THE 7.3 DIESEL MOTOR. I HAVE REPLACED THE CAM SENSOR IN IT TWICE AND THERE ARE MANY PEOPLE ON THE INTERNET UPSET ABOUT THIS. WHEN THE CAM SENSOR FAIL THE TRUCK SHUTS DOWN WHICH CAUSES LOSS OF POWER STEERING, POWER BRAKES, AND ALL CONTROL OF THE TRUCK AND THERE IS NO WAY TO TELL WHEN IT IS GOING TO FAIL. FOR HAS NO RECALLS ON THIS SENSOR AND HAS HAD MANY PROBLEMS WITH IT AND NOTHING IS BEING DONE. IF THIS PROBLEM IS NOT FIXED THEN ITS IS GOING TO KILL SOMEONE IF IT HASN'T ALREADY. I TOW A 3-CAR HAULER WITH THIS TRUCK, IT'S REALLY DANGEROUS WHEN THE ENGINE SHUT DOWN WITH NO WARNING. SOMETIMES THE ENGINE MAY BE RESTARTED AND OTHER TIME I HAD TO WAIT 45 MINUTES.

FORD POWER STROKE DIESEL CAM POSITION SENSOR FAILURE LEADING TO LOSS OF STEERING, BRAKES AND CONTROL OF VEHICLE. SENSOR CAN FAIL WITHOUT WARNING AT ANY TIME AND LEAVE VEHICLE INOPERABLE IN TRAVEL PORTIONS OF HIGHWAY. I WAS TOWING 9,500 LB AT THAT TIME. THE TRAILER BRAKES SAVED THE DAY. I HAD A SPARE CAM POSITION SENSOR ON HAND AND MADE THE REPAIR ON THE SIDE OF THE HIGHWAY. IT'S THE THIRD CAM POSITION SENSOR ON THE VEHICLE NOW.

DT: THE VEHICLE IS A 2001 FORD F350 SUPER DUTY SLD. THE TRANSMISSION FAILED. THE CONSUMER HAD BEEN EXPERIENCING PROBLEMS FOR ABOUT A MONTH AND GRADUALLY IT BECAME WORSE. THE TRANSMISSION WAS THE ONLY KNOW PROBLEM WITH THE VEHICLE. WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP, THEY TOLD HIM THAT IT HAS SLIPPING BETWEEN AND GEAR. THE TRANSMISSION WAS NOT FIXED AT THAT TIME. NOW IT WILL NOT GO INTO REVERSE AND IT IS LEAKING OIL. *JB

THIS TRUCK HAS HAD 4 TRANSMISSIONS, AND A NEW MOTOR ALONG WITH MANY REPAIRS. *AK