2010 FORD F-250 SD — Problems, Recalls & Safety Data
N/A
Safety Rating
48
Owner Complaints
1
Recall
0
Service Bulletins
0
Investigations
Overview of the 2010 FORD F-250 SD
The 2010 FORD F-250 SD has received a total of 48 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with SUSPENSION:FRONT:STABILIZER BAR, STEERING, EQUIPMENT. The most commonly reported problems involve the Steering (13 complaints), Suspension (9 complaints), and Engine And Engine Cooling (7 complaints).
Recalls for the 2010 FORD F-250 SD
NHTSA has recorded 3 recalls for the 2010 FORD F-250 SD, potentially affecting up to 306 vehicles.
Recall 20E090000 — SUSPENSION:FRONT:STABILIZER BAR
| 102 vehicles affected
Defect: Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Consequence: If the steering locks, it can increase the risk of a crash.
Remedy: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.
View full details →Recall 20E090000 — STEERING
| 102 vehicles affected
Defect: Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Consequence: If the steering locks, it can increase the risk of a crash.
Remedy: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.
View full details →Recall 20E090000 — EQUIPMENT
| 102 vehicles affected
Defect: Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Consequence: If the steering locks, it can increase the risk of a crash.
Remedy: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.
View full details →Owner Complaints for the 2010 FORD F-250 SD
48 complaints have been filed with NHTSA for the 2010 FORD F-250 SD. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Steering | 13 | 1 | 0 | 1 | 0 |
| Suspension | 9 | 1 | 0 | 1 | 0 |
| Engine And Engine Cooling | 7 | 0 | 0 | 0 | 0 |
| Electrical System | 2 | 0 | 0 | 0 | 0 |
| Engine And Engine Coolingengine | 2 | 0 | 0 | 0 | 0 |
| Engine And Engine Coolingexhaust System | 2 | 0 | 0 | 0 | 0 |
| Fuel System Gasoline | 2 | 0 | 0 | 0 | 0 |
| Power Train | 2 | 0 | 0 | 0 | 0 |
| Tires | 2 | 0 | 0 | 0 | 0 |
| Wheels | 2 | 0 | 0 | 0 | 0 |
| Engine | 1 | 0 | 0 | 0 | 0 |
| Engine And Engine Coolingcooling System | 1 | 0 | 0 | 0 | 0 |
| Fuel System Diesel | 1 | 0 | 0 | 0 | 0 |
| Power Trainautomatic Transmission | 1 | 0 | 0 | 0 | 0 |
| Service Brakes Hydraulic | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
ISSUE #1 AT HIGHWAY SPEEDS AND AFTER HITTING A BAD BUMP ON ROAD, THE TRUCK WOULD GO INTO AN UNCONTROLLABLE WHEEL HOP. THE ONLY WAY TO BRING VEHICLE BACK UNDER CONTROL IS TO SLOW DOWN BELOW 40 MPH. THIS NEARLY CAUSED A WRECK ON THE INTERSTATE. ISSUE #2. THE TRUCK CAB BUSHINGS WILL CRUMBLE IN YOUR HAND. THIS CAUSES A VERY HARSH RIDE OVER ANY TYPE OF BUMPS. I WAS TOLD BY FORD DEALERSHIP THIS IS NOT COVERED EVEN THOUGH THERE IS ONLY 62K MILES ON IT. IT COST OVER $1600 TO HAVE THESE 2 ISSUES FIXED. I HAVE 3 OTHER FRIENDS WITH THE SAME YEAR MODEL TRUCK THAT HAD TO HAVE THE SAME THINGS REPLACED. THE DEALERSHIP SAY THEY REPLACE THE SAME THINGS ON 3 TO 4 TRUCKS A MONTH. THIS IS A KNOWN ISSUE FORD SHOULD BE REPLACING FREE OF CHARGE.
TIRES REPLACED DUE TO BELT SEPARATION AT THE EDGE OF THE TREAD, CAUSING A SEVERE VIBRATION ABOVE 35MPH. THE TIRES DOT WAS CHECKED WITH MANUFACTURERS LIST OF RECALLS AND EVEN THOUGH THE TIRES WERE MANUFACTURED IN 2009, THEY WERE NOT INCLUDED. I FEEL THEY SHOULD ALSO BE INCLUDED SINCE THE SAME SET OF CONDITIONS ARE APPLICABLE TO THESE TIRES.
FRONT WHEEL WOBBLE AKA DEATH WOBBLE. VEHICLE BECAME SEVERELY UNSTABLE AT HIGHWAY SPEED (70 MPH) AFTER HITTING BUMP IN ROAD, FRONT OF VEHICLE BEGAN TO SHAKE VIOLENTLY CAUSING LOSS OF STEERING CONTROL. HAD TO SLOW VEHICLE TO 25 MPH TO STOP SHAKING.
CONTINENTAL CONTITRAC. I ALREADY REPORTED ISSUE WITH ONE TIRE 12/15/15 #10854773 AND NOW HAVE HAD TO REPLACE ANOTHER 2 TIRES. ONE CAUSED VIBRATION EVEN AT SLOW SPEED. IT WAS TOO DANGEROUS TO DRIVE SO WE HAD TO TOW THE CAR TO GET THE TIRE REPLACED. WHILE AT STORE, WE WERE INFORMED ABOUT CRACKS ON ANOTHER TIRE AND HAD TO GET IT REPLACE. THERE WAS A RECALL FOR 2008 AND 2009 ORIGINAL TIRES ON F250 BUT NOT FOR 2010.
HOSE TO RADIATOR LEAKING, TOOK TO FORD DEALER, THEY SAID NEW HOSES AND NEEDED A NEW RADIATOR. SAID IT WAS STILL UNDER FORD EXTENDED WARRANTY. FORD WARRANTY DENIED THE NEW RADIATOR AND HOSES SAYING THAT THE HOSE LEAK CRACKED THE RADIATOR AND THAT WAS THE OWNERS FAULT. TRUCK HAS JUST UNDER 44K MILES AND IS GARAGED AND WELL TAKEN CARE OF. WHAT GOOD IS AN EXTENDED WARRANTY, FIRST. AND SECOND, WHY SHOULD A RADIATOR GO BAD IN SHORT TIME. QUOTE FOR JOB WAS OVER $2000.00.
Safety Rating for the 2010 FORD F-250 SD
NHTSA has not yet tested the 2010 FORD F-250 SD in its New Car Assessment Program.
Technical Service Bulletins for the 2010 FORD F-250 SD
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2010 FORD F-250 SD
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the FORD F-250 SD
- 2005 FORD F-250 SD — 381 complaints
- 2006 FORD F-250 SD — 353 complaints
- 2007 FORD F-250 SD — 85 complaints
- 2008 FORD F-250 SD — 175 complaints
- 2009 FORD F-250 SD — 33 complaints
- 2010 FORD F-250 SD (current)
- 2011 FORD F-250 SD — 189 complaints
- 2012 FORD F-250 SD — 97 complaints
- 2013 FORD F-250 SD — 32 complaints
- 2014 FORD F-250 SD — 37 complaints
- 2015 FORD F-250 SD — 31 complaints
Other FORD Models
- FORD F-150 — 45,660 total complaints
- FORD EXPLORER — 42,140 total complaints
- FORD ESCAPE — 34,654 total complaints
- FORD FOCUS — 29,539 total complaints
- FORD FUSION — 28,243 total complaints
- FORD TAURUS — 23,867 total complaints
- FORD WINDSTAR — 19,456 total complaints
- FORD EDGE — 17,247 total complaints