2005 FORD EXPLORER Vehicle Speed Control Problems

1) ABS, BRAKE, AND WRENCH FAILURE LIGHTS FLASHED ON FOR ABOUT 3 SECONDS AND TURNED OFF WHEN DECELERATING WITH CRUISE CONTROL FROM 55 MPH TO 45 MPH ZONES AT COURLAND, VA. VEHICLE MANUAL PROVIDES NO GUIDANCE ON THIS FAILURE MODE; ONLY 'WARNING LIGHTS TURN ON AND CONTINUE FLASHING, REDUCE SPEED AND TAKE VEHICLE TO NEAREST SERVICE PROVIDER' AND 'WARNING LIGHTS TURN ON AND STAY ON, STOP DRIVING IMMEDIATELY AND HAVE VEHICLE TOWED TO NEAREST SERVICE PROVIDER.' 2) APPROXIMATELY TEN MINUTES LATER, DRIVER BEGAN APPLYING BRAKES TO DISENGAGE CRUISE CONTROL AND SLOW FROM 60 MPH TO 35 MPH SCHOOL ZONE SPEED ABOUT 50 TO 60 M BEFORE SCHOOL ZONE WARNING SIGN AT CAPRON ELEMENTARY, VA, ON STATE HIGHWAY 58. 3) DRIVER CHECKED SPEED UPON ENTERING SCHOOL ZONE AND FOUND CRUISE CONTROL LIGHT STILL ON AND VEHICLE STILL TRAVELING AT 60 MPH. DEPRESSED BRAKE APPROXIMATELY 1/3 TOTAL BRAKING RANGE (4 CM), WHICH...

WHEN USING THE CRUISE CONTROL AND THE 2005 FORD EXPLORER IS GOING DOWN HILL OR WHEN PRESSING COAST BUTTON, THE 2005 FORD EXPLORER STALL, ENGINE CUTS OUT. STEERING AND BRAKING BECOMES DIFFICULT.

I WAS BACKING UP FROM MY DRIVEWAY AND MY CAR ACCELERATED WHEN PUT INTO REVERSE AND IT PEELED OUT AND HAD TO HIT THE BRAKES REALLY HARD.SOMETIMES THE ENGINE SHAKES WHEN GOING FORWARD FOR A FEW SECONDS THEN IT GOES AWAY.

MY GAUGES GO HAYWIRE THE NEEDLES SHAKE WHILE DRIVING AND WHEN CAR IS OFF NO KEY IN IGNITION. THE LIGHTS FLASH AS WELL. CAR WILL STALL IN TRAFFIC AT A STOP, THE RPM WON'T GO ABOVE 2 EVEN WHEN HWY GOING 60 MPH. MECHANIC SAID IT'S ELECTRICAL, THE DEALER TOOK OUT TOP COUNSEL AS A WORK AROUND FOR THIS ELECTRICAL ISSUE CLAIMING IT WAS NOT A RECALL.

THE VEHICLE HAS A HARD TIME ACCELERATING, WHEN IT DOES, A "CLUCK" SOUND CAN BE HEARD, SOMETIMES ACCELERATION FAILS ALL TOGETHER. O/D LIGHT COMES ON AND BLINKS. CHECK TRANSMISSION LIGHT COMES ON.

THE VEHICLE SHUTS OFF WHILE DRIVING CAUSING LOSS OF POWER STEERING, POWER BRAKES WITH A COMPLETE LOSS OF POWER. THIS IS AN ONGOING PROBLEM AND HAS HAPPEND DURING HIGHWAY HIGH SPEED DRIVING. IT HAPPENS ON CARS BUILT 11/24/04 AND PRIOR. THE CODES ARE P2106 AND P2135. IT'S CAUSED BY A FAULTY THROTTLE POSITION SENSOR AND REQUIRES A POWERTRAIN CONTROL MODULE RESET B36.11, B37.2 OR HIGHER. THIS HAS BEEN AN ONGOING PROBLEM THAR FORD READILY ACKOWLEDGES. THEY HAVE UGRADED THE THROTTLE POSITION SENSOR TWICE WITHOUT SOLVING THE PROBLEM.

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. WHILE DRIVING AT 5 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE UNEXPECTEDLY ACCELERATED. AS A RESULT, THE VEHICLE CRASHED INTO THE CONTACT'S GARAGE AND OTHER VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000. UPDATED 09/10/15*LJ

DRIVING DOWN THE ROAD, SUDDENLY THE WRENCH LIGHT CAME ON AND THE FAIL SAFE LIGHT CAME UP. VEHICLE WOULD BARELY RUN. CLEANED THROTTLE BODY AND IT SEEMED FINE FOR A WHILE. THEN THE SAME THING HAPPENED AGAIN, DRIVING NORMAL, THEN BAM. THIS TIME IT SHUT DOWN AND WOULD BARELY STAY RUNNING...JUST ORDERED A NEW THROTTLE BODY. I WILL NOT OWN ANOTHER FORD.

OUR 2005 EXPLORER WITH V8 ENGINE HAS DEVELOPED A SERIOUS PROBLEM WHEN CRUISE CONTROL IS ENGAGED AND A HILL IS CRESTED (FOR EXAMPLE) AND THE ENGINE GOES TO IDLE IT DROPS BELOW STALL SPEED AND DIES WHILE DRIVING. DRIVER MUST MOVE SHIFTER INTO N AND RESTART, OBVIOUSLY CRITICALLY DANGEROUS PROBLEM. THE CAR HAS NO PROBLEM WITH NORMAL DRIVING OR IDLING WITHOUT CRUISE ON. THIS PROBLEM IS PERSISTENT AND EASY TO REPRODUCE EVEN ON FLAT SURFACES WHEN CRUISE BACKS OFF THE THROTTLE TO SLOW DOWN. A/C CAN BE ON OR OFF. *TR

2005 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO VEHICLE REAR AXLE LEAKING. *SMD THE CONSUMER STATED THE REAR AXLES WERE REPLACED AT 59,752. A YEAR LATER AFTER LISTENING TO THE NOISE IN THE REAR END FOR QUITE SOME TIME, THE PROBLEM RETURNED. SIX MONTHS LATER, THEY WERE REPLACED AGAIN. ALSO, THE REAR PANEL BENEATH THE WINDOW WAS RUSTED AND THE THROTTLE NEEDS TO BE REPLACED, AS IT IS CAUSING VEHICLE HESITATION.*JB

WHEN SPEED CONTROL IS SET, AND COAST BUTTON IS PRESSED FOR MORE THEN A FEW SECONDS, ENGINE WILL STALL. *TR

THE GEARS IN THE POWERED BRAKE/GAS PEDAL ASSEMBLY SEEM TO STRIP. THEN THE BRAKE/GAS PEDAL WON'T CHANGE POSITION. THAT CREATES A DANGEROUS SITUATION FOR THE DRIVER BECAUSE THE PEDALS GET STUCK TOO FAR AWAY FOR SOME DRIVERS AND TOO CLOSE FOR OTHERS. THIS IS A FLEET WIDE ISSUE FOR ALL FORDS WITH ADJUSTABLE PEDALS. *TR

MY 2005 FORD EXPLORER ENGINE SHUTS OFF WHILE DRIVING WHEN CRUISE CONTROL IS ON. THE ENGINE ALSO HAS A HUM SOUND WHILE CRUISE CONTROL WAS ON. *TR

WHILE DRIVING, WHEN I APPLIED THE BRAKES, THE CAR LURCHED AND MADE A NOISE. ABOUT 1 MINUTE AFTER THAT, A WARNING LIGHT THAT STATED "ENGINE FAIL SAFE MODE" AND A LITTLE WRENCH SHOWED UP ON THE LEFT OF THE INSTRUMENT PANEL. I WAS DRIVING HOME, AND THE CAR STARTED TO SPEED UP WITHOUT MY INCREASING THE SPEED USING THE GAS PEDAL. THE CAR CONTINUED TO LURCH OFF AND ON UNTIL I GOT HOME. I RESEARCHED THIS PROBLEM ON THE INTERNET AND IT SEEMED TO BE THE THROTTLE BODY ASSEMBLY THAT HAD FAILED. UPON TAKING IT TO THE MECHANIC, THAT IS EXACTLY WHAT IS WAS. THE CAR WAS DANGEROUS TO DRIVE, I COULD HAVE BEEN KILLED HAD THE CAR'S SPEED KEPT INCREASING. THE REPAIR WAS $1026.00.

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT ON THREE SEPARATE OCCASIONS WHILE DEPRESSING THE BRAKES, THE VEHICLE ABNORMALLY ACCELERATED AND THE CONTACT WAS UNABLE TO STOP THE VEHICLE. ON THE THIRD INSTANCE OF THE FAILURE, THE VEHICLE ACCELERATED AND CRASHED INTO A PARKED VEHICLE. THERE WERE NO INJURIES REPORTED AND NO POLICE REPORT. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FOR THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 97,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 25,000.

TODAY, I STARTED OUR 2005 FORD EXPLORER TO DRIVE MY TWO CHILDREN TO THE BUS STOP. THE ELECTRONIC THROTTLE CONTROL LIGHT ON THE INSTRUMENT CLUSTER WENT ON OUT OF THE BLUE. I'VE HAD MANY CARS BUT THIS IS THE FIRST FORD AND SINCE AUGUST WE'VE PUT IN AN ALTERNATOR, NEW ENGINE AND NOW THE ELECTRONIC THROTTLE CONTROL LIGHT. OUR PRIOR SUV WAS A 1999 DODGE DURANGO AND WE DIDN'T HAVE TO PUT ANY OF THESE REPAIRS INTO IT. *TR

ELECTRICAL SYSTEM , BODY STRUCTURE , GAS PEDAL. *TR

I HAVE A PROBLEM WITH THE CRUISE CONTROL ON MY 2005 FORD EXPLORER. MY SON FIRST DISCOVERED IT BACK IN JULY-AUGUST 2010. WHILE HE WAS ADJUSTING HIS SPEED FOR THE CRUISE CONTROL WHILE ON THE HIGHWAY, THE CAR COMPLETELY STALLED OUT AND HE LOST ALL POWER STEERING AND BRAKES. THANK GOODNESS, HE HAD THE PEACE OF MIND TO PUT THE CAR IN NEUTRAL AND TURN THE KEY TO START IT AGAIN. I WOULD NOT HAVE THOUGHT TO DO THAT WHILE TRAVELING AT A HIGH SPEED TRYING TO CONTROL THE VEHICLE WITHOUT POWER BRAKES OR STEERING. SINCE THAT INITIAL EPISODE, BOTH MY SON AND MY HUSBAND HAVE TESTED IT AT SLOWER SPEEDS AND HAVE HAD THE SAME RESULTS. SO WE BROUGHT IT TO A FORD DEALER IN OUR AREA TO HAVE IT CHECKED OUT. THEY EVENTUALLY DETERMINED THAT IT WAS A PROBLEM WITH THE ELECTRONIC THROTTLE BOX AND THAT IT WOULD...

I WAS DRIVING ON 77 NORTH IN FANCY GAP, VA, WHEN SUDDENLY I LOST POWER STEERING AND ACCELERATION. I NOTICED SMOKE COMING FROM CAR AND IN FACT THE CAR IN FRONT OF ME SAID HE NOTICED BLACK SMOKE AND FLAMES UNDERNEATH THE CAR. I PULLED OVER TO THE SHOULDER AND THE CAR WAS IMMEDIATELY IN FLAMES. I EXITED THROUGH DRIVER SIDE DOOR. MY PASSENGER HAD TO EXIT THROUGH DRIVER DOOR AS WELL BECAUSE FLAMES WERE SPREADING ACROSS THE PASSENGER SIDE OF THE CAR. WE DISTANCED OURSELVES FROM THE VEHICLE AS THE ENTIRE THING BECAME ENGULFED IN FLAMES. CARROLL COUNTY FIRE DEPARTMENT AND VA STATE POLICE ARRIVED. IT TOOK OVER 45 MINUTES FOR THE FIRE TO BE EXTINGUISHED; THE CAR KEPT RE-IGNITING, EVEN AFTER SEVERAL APPLICATIONS OF WATER AND ANTI-FLAME CHEMICALS. THE ENTIRE VEHICLE MELTED, INCLUDING TIRES. NOTHING WAS SALVAGEABLE. THE VEHICLE WAS A 2005 FORD EXPLORER WITH ONLY 47,000 MILES....

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. WHEN ATTEMPTING TO START THE VEHICLE, THE ENGINE BEGAN TO SPUTTER. SHE RESTARTED THE VEHICLE TO RESUME NORMAL VEHICLE OPERATION. ON ANOTHER OCCASION WHILE DRIVING, THE POWER STEERING AND BRAKES FAILED WITHOUT WARNING, WHICH CAUSED HER TO CRASH INTO A FENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION ON TWO SEPARATE OCCASIONS. THE FAILURE WAS CONTRIBUTED TO THE FUEL SENSOR AND THROTTLE POSITION SENSOR. THE THROTTLE POSITION SENSOR WAS REPLACED. THE REPAIR DID NOT REMEDY THE FAILURE. THE FAILURE MILEAGE WAS 45,000. THE CURRENT MILEAGE WAS 80,000. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2005 FORD EXPLORER XLT. WHILE DRIVING IN REVERSE OUT OF A PARKING SPACE SHE LIGHTLY PLACED HER FEET ON THE ACCELERATOR PEDAL AND SUDDENLY THE VEHICLE ACCELERATED AND CRASHED INTO A PARKED VEHICLE. THE PARKED VEHICLE WAS PUSHED INTO TWO OTHER PARKED VEHICLES. SHE STATED THAT HER VEHICLE DOES NOT HAVE FLOOR MATS. THERE WERE NO INJURIES. THE INSURANCE COMPANY WILL INVESTIGATE THE FAILURE. THE VEHICLE'S BODY WAS REPAIRED. THE POLICE REPORT NUMBER IS 09-19790. THE CURRENT AND THE FAILURE MILEAGES WERE 52,287. UPDATED 11/18/09.LJ UPDATED 11/19/09

VEHICLE: 2005 FORD EXPLORER; MILEAGE 62,300; SYSTEM MALFUNCTION INDICATING SERVICE WAS NEEDED; DIAGNOSTIC CODES INDICATE THE BRAKE PRESSURE SWITCH FOR DEACTIVATION OF SPEED CONTROL NEEDS REPLACED. CURRENT NHTSA/FORD RECALL DOES NOT APPLY TO 2005 MODEL YEAR VEHICLES. CALL TO FORD CUSTOMER SERVICE CENTER INDICATES LACK OF INTEREST IN PROBLEM. *TR

THIS MORNING, AS I WAS IN MOTION OF (64MPH). MY CRUISE CONTROL WAS ON AND I PRESSED THE OFF BUTTON ON WHEEL TO DISENGAGE. MY TRUCK COMPLETELY SHUT DOWN, THE GAS PEDAL FELT LIKE THE TRUCK WAS NOT ON- IT DID NOTHING, THE STEERING WHEEL WAS ALMOST IMPOSSIBLE TO TURN, THE BRAKE PEDAL VERY HARD TO PUSH AND WOULD NOT BRING THE TRUCK TO A STOP, THE DASH LIGHTS DIMMED VERY LOW. AFTER WRESTLING WITH THESE OBSTACLES, I PUT THE TRUCK IN PARK AND TURNED ENG. OFF, THEN BACK ON AND I HAVEN'T TRIED THE CRUISE SINCE. *TR

CAR WAS PARKED AND OFF OUT IN FRONT OF GARAGE, ALL DOORS LOCKED. APPROXIMATELY ONE HOUR WE NOTICED THE CAR WAS ON FIRE OUTSIDE. FIRE WAS COMING FROM INSIDE ENGINE HOOD. FIRE DEPARTMENT SHOWED UP, PUT OUT FIRE AND KICKED IN THE WINDOWS. DAMAGE WAS SEVERE AND LIFE-THREATENING; LARGE FIRE ALMOST CAUGHT THE ENTIRE APARTMENT BUILDING ON FIRE. THE FIREMAN SAID THAT THIS SEEMED DUE TO AN ELECTRICAL PROBLEM AND NOT ARSON DUE TO THE WAY THE FIRE CAME FROM THE ENGINE, ALL DOORS AND WINDOWS OF THE CAR WERE CLOSED WITH NO EVIDENCE OF BREAK-IN. THIS PROBLEM SEEMS TO BE SIMILAR TO THE RECALL FOR SCDS THE CRUISE CONTROL DEACTIVATION FORD MADE ON SUVS AND PICKUPS 1998-2002 BUT THIS OCCURRED ON A 2005 FORD EXPLORER. PLEASE HELP! PEOPLE ALMOST DIED DUE TO THIS TERRIBLE HAZARD FORD HAS NOT FIXED. *TR

05 FORD EXPLORER HAS REPEATED (ENGINE THROTTLE CONTROL) LIGHT WARNINGS. THE VEHICLE, WHILE MOVING, LOSES POWER AND THEN STALLS. I SHUT THE VEHICLE OFF, THE PROBLEM SEEMS TO RESET AND THE VEHICLE THEN RUNS FINE. THIS HAS HAPPENED ON (2) OCCASIONS AND NOW FEEL THE VEHICLE MAY NOT BE SAFE. *TR

MY GAS PEDAL IS STICKING. I INITIALLY THOUGHT MY BRAKES WERE GOING. I JUST HAD MY REAR BRAKES REPLACED AND MY CAR PASSED INSPECTION. I WAS TOLD I'D NEED NEW FRONT BRAKES IN THE NEXT SIX MONTHS. THREE TIMES, I'VE HAD THE GAS PEDAL STICK. WHEN I TRY TO APPLY BRAKES, IT BARELY SLOWS DOWN THE CAR AND THE MOTOR GETS REALLY LOUD. *TR

WHILE DRIVING THE VEHICLE AT ANY GIVEN SPEED AND NO MATTER HOW MUCH GAS I HAVE THE VEHICLE SHUTS OFF AND ALL POWERWAS LOST. I WAS ABLE TO RESTART VEHICLE ONLY IF I CAE TO A COMPLETE STOP AND PUT VEHICLE IN PARK, THEN VEHICLE RE-STARTED AND ACTED NORMALLY. THIS HAPPENED SOMETIMES 3 TO 4 TIMES A DAY OR NOT FOR A MONTH. I WAS TOLD BY MY FORD DEALER THAT THEY COULD NOT DUPLICATE THE PROBLEM DESPITE DRIVING THE VEHICLE HOME AND HOOKING UP THE COMPUTER TO IT. THE LAST ADVICE I RECEIVED FROM FORD WAS TO GET THE VEHICLE TOWED IN WHEN STOPPAGE OCCURS. THATWAS NOT THAT EASY WHEN YOU NEED THE VEHICLE TO GET YOU TO YOUR DESTINATION OR YOU WERE STUCK IN A BAD AREA. THIS OCCURRED 1 YEAR AFTER PURCHASE. ALSO, I HAVE A NOTICED THAT THE VEHICLE SURGESD WHEN THE BRAKEWA S APPLIED AS...

TL*THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE AUTOMATICALLY ACCELERATES AT RANDOM AND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE FAILURE OCCURRED AGAIN WHILE DRIVING INTO THE SERVICE BAY AT 5 MPH. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. THE ENGINE SIZE IS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 23,000.

FORD EXPLORER WITH A DEFECTIVE ACCELERATOR/BRAKE PEDAL CUSTOMER STATES THAT THE BRAKE PEDAL ACTS LIKE THE GAS PEDAL SOMETIMES**CC THE CONSUMER STATED THE SURGE ALWAYS HAPPENS WHILE DRIVING AT LOW SPEEDS. 4/23/07 *TR

DT*: THE CONTACT STATED THE VEHICLE STALLED ON 3 OCCASIONS WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE HAS NOT BEEN TO A SERVICE DEALER AND THE CONTACT WAS UNSURE OF WHAT CAUSED THE PROBLEM.

DT*: THE CONTACT STATED WHEN ACTIVATING THE CRUISE CONTROL AND THE SPEED SET AT 70 MPH, THE CRUISE CONTROL DEACTIVATES ITSELF WITH NO INTERACTION FROM THE CONTACT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION; HOWEVER THE PROBLEM COULD NOT BE DUPLICATED. VEHICLE SPEED CONTROL DEACTIVATED 3 TIMES WHILE IN USE. IN FEBRUARY 2006, AFTER SPEED CONTROL DEACTIVATED IT TOOK 3 TO 5 MINUTES TO TURN IT BACK ON. DEALER FOUND NO PROBLEM. IN MARCH 2006, IT DEACTIVATED ONCE. *AK

SPEED CONTROL ON 2005 FORD EXPLORED WILL ACCELERATE WHEN COAST BUTTON PUSHED. CAN BE TURNED ON BY PRESSING OFF BUTTON. OPERATES OK FOR SOME OF THE TIME AND IS UNPREDICTABLE WHEN WILL MALFUNCTION. OCCASIONALLY ONLY TAP BRAKE WILL TURN OFF SPEED CONTROL. OFF BUTTON DOES NOT WORK. WILL ACCELERATE AFTER SPEED CONTROL OFF SEVERAL MINUTES LATER. UNINTENDED ACCELERATION BY SPEED CONTROL. *JB

DT: THE CONTACT OWNS A 2005 FORD EXPLORER. WHEN STEPPING ON THE ACCELERATOR THERE IS A DELAYED THROTTLE RESPONSE OF 3-5 SECONDS BEFORE ONE FEELS ANY ACCELERATION. THE CONTACT NOTICED THIS AFTER HE BOUGHT THE CAR IN 8-05. HE TOOK IT TO THE DEALER, AND THEY AGREED WITH HIM. THEY TEST DROVE ANOTHER 2005 FORD EXPLORER AND IT DID THE SAME THING. THE DEALER CALLED FORD, AND FORD SAID THEY KNEW ABOUT THIS, AND THEY ALLOWED THE TRANSMISSION TO SHIFT BEFORE IT ACCELERATED. THEY WILL NOT ALLOW THE DEALERSHIP TO CHANGE THIS. IT HAPPENED WHETHER THE CRUISE CONTROL WAS ON OR OFF. IT HAPPENS AT ANY SPEED.*AK *NM

WHILE TURNING AROUND IN A LARGE DRIVEWAY AT LOW SPEEDS, MY 2005 FORD EXPLORER SUDDENLY AND UNEXPECTEDLY ACCELERATED CAUSING IT TO RUN INTO A FENCE CAUSING DAMAGE TO THE FRONT END OF THE VEHICLE (MINOR) ALSO RIPPING OFF THE RUNNING BOARD AFTER RUNNING OVER A LARGE LOG. THIS CAR HAS ALSO FAILED TO START AT TIMES AND ONCE THE ENGINE DIED WHILE DRIVING ON THE FREEWAY FOR NO APPARENT REASON. *NM