2003 FORD EXPLORER SPORT TRAC Engine And Engine Coolingengine Problems

ENGINE & MULTIPLE PARTS IN 2003 FORD ARE NOT 2003, THEY ARE 2001 & 2002. 2002 ENGINE AND EARLIER HAD A TSB FOR THE TIMING CHAIN GUIDES & OILING. EVEN THOUGH TAKEN INTO THE DEALERSHIP WITH THAT COMPLAINT, MINE WAS SUPPOSED TO BE 2003, NOT AFFECTED BY THOSE PROBLEMS, SO SERVICE DID NOT REPAIR FOR TSB. LATER ON TIMING JUMPED BECAUSE GUIDES NOT REPLACED, BENT VALVE AND RUINED THE ENGINE TO TUNE OF $5,000, PLUS PARTS SPENT TO GET TO THAT POINT & RENTAL CARS. SHOULD BE NOTED THE FIRST REPLACEMENT MOTOR INSTALLED BY FORD RAN ONLY 15 MINUTES BEFORE IT BLEW FROM TIMING CHAIN DEFECT/POOR MANUFACTURING. HISTORY: BEFORE END OF 75,000 MILE EXTENDED WARRANTY I TOOK THE SPORT TRAC INTO THE DEALER TO TAKE CARE OF ALL THE LITTLE COMPLAINTS. ONE COMPLAINT WAS SLIGHT RATTLE TYPE OF SOUND WHEN THE CAR WAS COLD/COLD MORNING. DEALER SUGGESTED AN ENGINE FLUSH...

VEHICLE SHUTS DOWN WHEN DRIVING---BOTH LOW AND HIGH SPEED--BRAKES, STEERING, ELECTRICAL, GAS--ALL QUIT. AFTER A FEW MINUTES THE CAR WILL START AGAIN. HAS HAPPENED NUMEROUS TIMES. DEALER, VISTA FORD, SAYS NOTHING WRONG/CAN'T DUPLICATE. *NM

I PURCHASED MY 2003 SPORTRACK IN DECEMBER OF 2002 FROM SUNRISE FORD. I DROVE MY SUV HOME, PARKED IT AND WENT INSIDE FOR LESS THAN 20 MINUTES. WHEN I CAME OUT TO DRIVE DRIVE MY GUESTS AROUND THE BLOCK, THE VEHICLE WOULD NOT START. I CALLED SUNRISE FORD AND SPOKE WITH THE SERVICE DEPARTMENT. THEY SENT THE SALES PERSON TO MY PLACE RATHER THAN A MECHANIC. HE BASICALLY BELITTLED ME INFRONT OF MY GUESTS BY TELLING ME I DID SOMETHING TO MY CAR. IT WAS EMBARASSING ENOUGH THAT THE VEHICLE WOULD NOT START NOW I HAD TO DEAL WITH THE SALES PERSON, WHO AS IT TURNS OUT KNEW ABSOLUTELY NOTHING ABOUT THE SPORTRACK, TELLING ME I DID SOMETHING WRONG TO MY VEHICLE TO MAKE IT NOT WANT TO START. HE FINALLY CALLED THE SERVICE DEPARTMENT, HAD A MECHANIC COME OUT AND THEY TRIED TO START IT. NO LUCK. LONG STORY...

VEHICLE ENGINE MISSING AND LOST POWER WHILE ATTEMPTING TO ACCELERATE ONTO ON-RAMP. ATTEMPT TO RESTART FAILED. HAD TO CALL FOR TOW. DEALERSHIP COULDN'T FIND ANYTHING WRONG. *NLM

THE VEHICLE EXPELLED GASOLINE EVERYTIME THE CONSUMER WAS REFUELING THE TANK AND THE GAS PUMP AUTOMATICALLY SHUT OFF, AS IT IS DESIGNED TO DO. THE PROCESS OF FILLING THE TANK INCREASED FIVE FOLD, TAKING APPROXIMATELY 25-30 MINUTES, BECAUSE THE PUMP REPEATEDLY SHUT OFF AND EXPELLED GAS. THE MANUFACTURER WAS NOTIFIED AND WAS AWARE OF THE PROBLEM BUT THERE WAS NO CURRENT FIX FOR THE PROBLEM. THE EMERGENCY BRAKE NEEDED ADJUSTING AND THE CHECK ENGINE LIGHT ILLUMINATED. *MR *SCC *NLM