2024 FORD EXPEDITION Electrical System Problems

The fuel line/fuel pump was leaking. Smelled fumes from the gasoline. Fuel was leaking over the fuel tank from the top of the tank. The vehicle was drivable when fuel was leaking. Very concerned that their could have been a fire due to the fuel leak. Took the vehicle to the Ford service department where it was purchased. Service shop stated that during inspection they noticed that something chewed through the fuel line/fuel pump. Comments made by the service advisors stated that they have seen squirrels/rodents attracted to the soy based ingredients of the parts/wiring. The repair would not be covered under warranty due to "outside influence". The manufacturer is installing a similar part and not covering under warranty. No warning lights; no warning messages. If the same type of soy based part is being installed, what is going to prevent the same thing from happening. Ford is not offering...

The contact owns a 2024 Ford Expedition. The contact stated that while driving at various speeds, the message "Drive Assist Unavailable" was displayed. The contact stated that when the vehicle was turned off and restarted, the system was functional. The contact had taken the vehicle to a local dealer, who checked the 12-Volt battery and found that the battery was operational and there were no other electrical issues. The contact stated that later, while starting the vehicle, the message "Loss of Power Steering Assist" was displayed, and the steering wheel was difficult to turn to the left or the right. The vehicle was turned off and restarted, and regained power steering functionality; however, the failure reoccurred. The contact attempted to reset the electrical system by disconnecting the battery terminals. The contact stated that loss of power steering reoccurred with the loss of the Lane Keep Assist feature. The contact had...

I am filing this complaint regarding Ford Safety Recall 25S49 (NHTSA Campaign Number 25V315). My vehicle is a 2024 Ford Expedition Max, VIN [XXX] . The Ford pass app and the Ford recall site both show the remedy for the recall as "Available", but when I contact my dealer (Maxwell Ford in Austin, TX) they say that the repair cannot be performed because the update is not yet active in the Oasis dealer system. Ford has had months to release the software fix, but continues to delay the rollout to dealerships. Meanwhile, I have been without my vehicle because the rearview camera is unreliable and considered a safety hazard under the recall. I am paying for a new vehicle that is parked at the dealership and undriveable due to Ford's failure to provide a timely remedy. I have contacted Ford Executive Relations and their social media team, but have received...

Passenger sideview mirror does not open upon unlocking and starting the vehicle. I need to stop (if started driving) turn to park, turn off car, open driver's door to signal car that I have left, lock car using remote, wait few seconds and then unlock to reset car then it usually opens. Issues with mirror began happening a month after purchasing brand new car (5/24), first mirror was "popping or clicking" upon turning outright, mirror had been replaced once, over last year issue has been on going and brought to dealershop " deemed a technological glitch" - no warning lights or messages appear - sometimes my control panel screen will turn black upon starting the car which I now know means to look at my passenger mirror. This last occurred on Friday 7/25/25.

6/10/25- car turned off in the middle of the road 6/12/25- car would not start 7/6/25- car would not start 6/16/25 and 7/12/25 car apparently had warning in the ford system of a malfunction

The issue involves the purchase of a 2024 Ford Expedition Max, VIN [XXX] , which purchased on [XXX] from Legacy Ford in Corbin, KY. Since purchasing this vehicle, I have encountered the following persistent issues that substantially impair the use, value, or safety of the vehicle: The vehicle was sold to me seemingly infested with rodents, which ate away much of the internal wiring of the engine compartment. The wiring is manufactured with soy-based sheathing, which is a well-known defect and further known to attract rodents/vermin and as I only possessed the vehicle in question for 3 weeks and 5 days (when first sensor light came on and only drove it 1383 miles (7 weeks total). I have been forced to make an insurance claim for this damage, which I feel was resultant of a manufacturing defect, but due to the inexcusable part delay in obtaining replacement wiring, the rental...

I HAVE FORD EXPEDITION 2024 , I HAVE TAKEN MANY TIMES TO DEALERSHIP, THEY ARE MAKING EXCUSES AND SAYING ITS SOFTWARE ISSUE BUT ITS NOT ADN THEY ARE UNABLE TO FIX THAT, IT HAS SCREEN PROBLEM THE SCREEN FREEZES FULL WAY,HALF WAY SOMETIME ALL BLACK OUT, CONNECTS DISCONNECTS ITSELF, ITS ANNOYING AND ITS SAFETY ISSUE YOU GET DISTRACTED BY IT, IF YOU HAVE NAVIGATION ON OR ON THE PHONE ALL OF SUDDEN CONNECTS DISCONNECTS FREEZES THEN YOU HAVE TO TAKE OUT YOUR CELLPHONE AND KEEP TOUCHING AND PANICKING AND THEY ARE NOT DOING ANYTHING ITS DANGERIOUS FOR THE DRIVING AND FOR THE PUBLIC LETS SAY IF YOU WANNA GO SOMEWHERE AND NAVIGATION IS ON ADN ALL OF SUDDEN PROBLEM OCCURS MANUFACTURE IS NOT DOING ANYTHING ABOUT IT ALSO SAME PROBLEM OCCURS IN MY 2024 FORD EXPEDITION AND THEY NOT FIXING IT, AND AS PER LAW YOU ARE NOT ALLOW TO...

I recently purchased this vehicle new from Denny Menholt Ford in Butte, MT. When purchasing I was told they added a third brake light Pulse system as a requirement on all of their vehicles. Just today I learned that per NHTSA rules it is illegal to have any pulsing brake lights on a vehicle. I wanted to make you aware of the practices of this dealership, as they informed me that the Pulse brake light is a mandatory add on and not negotiable.

The contact owns a 2024 Ford Expedition. The contact stated that after the vehicle had been parked overnight, the vehicle failed to start the following morning. The vehicle was taken to the dealer, where it was determined that rodents had eaten the soy-based wiring harnesses underneath the power distribution box, near the engine. The dealer informed the contact that eight wiring harnesses needed to be replaced and provided the contact with an estimate for the repair. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 17,304.

Malfunction: powered running board on the passenger side of vehicle while vehicle was in park with door open and engine running. It closed while my hisband was resting his right foot on it and then it opened and closed and his foot and lower ankle was getting crushed. I had to run around to passenger side and when I opened the right rear passenger door the running board released and opened up. The car will be going to the dealer for its first oil change etc. and I will talk to them about this incident.