2005 FORD EXPEDITION Electrical System Problems

Engine Missing

CRANK NO START, AFTER REPLACED NEW FUEL PUMP, FILTER AND OTHER PARTS WOULD NOT START AND NOT GETTING FUEL. WAS IN MOTION AND DIED AFTER MAKING A RIGHT TURN AFTER FILLING FUEL TANK.

FUEL PUMP DRIVER MODULE FAILED DUE TO DESIGN FLAW WHICH CAUSED GALVANIC CORROSION. ALUMINUM BODY OF COMPONENT ACTS AS THE SACRIFICIAL ANODE FOR THE FRAME WHICH IS STEEL. THIS CAUSED MY VEHICLE TO STALL AT 65MPH AND LOSE POWER AND THUS CAUSED THE LOSS OF POWER STEERING AND HYDRAULIC BRAKE BOOSTER WHILE TRAVELING A HIGH RATE OF SPEED. THIS COULD BE ESPECIALLY DANGEROUS ON HIGHWAYS, CONGESTED AREAS, OR AREAS WITH PEDESTRIANS SUCH AS SCHOOLS. I HAVE ALSO NOTIFIED FORD OF THIS PROBLEM.

THIS CAR JUST NUMEROUS OF PROBLEM..... WHO EVER BUILT THIS CAR DID NOT HAVE A GOOD JOB OF DOING IT

SAME AS EVERYONE ELSE DRIVING NORMALLY AND TRUCK COMPLETELY SHUTS OFF 4 DIFFERENT TIMES ALL DIFFERENTLY I CHANGED THE FUEL PUMP DRIVER MODULE HAD FUEL TANK DROPPED AND CHANGED FUEL FILTER AND PUMP I'M NOT GOING TO LIE I LOVE MY BABY SHE'S BEEN GOOD TO ME BESIDES THIS I HAVE 250,000 PLUS MILES ON HER AND COUNTING AND NEVER FACED PROBS TILL NOW I'VE RECENTLY THIS YEAR (TECHNICALLY) REBUILT HER MOTOR AND THAT'S IT . ALSO PASSANGER OVER HEAD LIGHTSTART HAVE BEEN ACTING FUNNY SOME WORK SOME DON'T AND AC IN THE 3RD ROW SOMETIMES GOES OUT OR MAKES A CLICKING NOISE AND HEATER DON'T WORK AT ALL ON THE 2ND OR 3RD ROW I AM A SINGLE FEMALE WITH 3 YOUNG KIDS ID LOVE TO KEEP MY BABY RUNNING SO PLEASE HELP AND I'VE HAD ONE OTHER PROB ONE TIME ON HIGH WAY I HAD A FENDER BENDER...

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND EMITTED HOT AIR FROM THE VENTS WHEN ACTIVATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC SEVERAL TIMES WHERE THE BLENDER DOOR ACTUATOR, COMPRESSOR, AND CONTROL PANEL WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE MECHANIC STATED THAT THE FAILURE COULD NOT BE REMEDIED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE CONTACT WAS ALSO ADVISED THAT THE FAILURE COULD HAVE BEEN ATTRIBUTED TO THE CONTROL HEAD THAT WAS LOCATED BEHIND THE CONTROL PANEL. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 118,000.

I HAVE A 2005 FORD EXPEDITION AND HAVE MAINTAINED MY VEHICLE MAINTENANCE AND ONLY HAVE 124,000 MILES ON THIS VEHICLE. IT CONTINUES TO SHUT OFF THE ENGINE AND CODE FAIL SAFE MODE ON CODE APPEAR AND WHEN I'M DRIVING ON THE HIGHWAY IT IS DANGEROUS. AFTER READING SO MANY COMPLAINTS THIS IS UNSAFE. ALSO, THE COMPUTER ISSUES WITH LOCKING DOORS, FAILURE OF THE TRANSMISSION (WHICH I HAD TO REPLACE) SUCH A DISAPPOINTMENT OF A VEHICLE. FORD SHOULD RECALL ENGINE AND COMPUTER ISSUES. I PURCHASED THIS VEHICLE BRAND NEW $50,000 + AND HAVE NOT BE ABLE TO DEPEND ON THE STABILITY SINCE I'VE HAD IT.

MY 15 YEAR OLD SON AND MY LIFE WERE PLACED IN SERIOUS DANGER, BY THE GROSS NEGLIGENCE AND DECEPTIVE BUSINESS PRACTICES PROMOTED BY THE FORD MOTOR COMPANY, REGARDING SCAN CODE P2106. SINCE AS EARLY AS FEBRUARY 26, 2013 FORD MOTOR COMPANY WAS MADE AWARE OF A DANGEROUS DEFECT CONCERNING THE MECHANICAL AND ELECTRICAL COMPONENTS OF THEIR MANUFACTURED PRODUCT RELEASED TO THE CONSUMER PUBLIC FOR PROFIT. THE VEHICLES ARE FORD TRUCKS, MANUFACTURED FROM 2003 - 2008, WITH THE V8 5.4 L ENGINE. PUBLIC RECORD REVEALS CASE NO. 12-7222, JASON SCHMIDT, (PLAINTIFF) VS. FORD MOTOR COMPANY, (DEFENDANT) FILED IN THE UNITED STATES DISTRICT COURT FOR THE EASTERN DISTRICT OF PENNSYLVANIA, THAT FORD MOTOR COMPANY IS WELL AWARE OF THIS ISSUE. I BELIEVE THAT FORD MOTOR COMPANY HAS MADE NO ATTEMPTS TO INFORM FORD DEALERSHIP OWNERS, THE FORD DEALERSHIP MANAGERS OR FORD SERVICE REPAIR SHOP MANAGERS AT THE FORD DEALERSHIPS AND CONSUMERS WHO...

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION.....UPDATED 08/25/15 *BF

THE DASH MESSAGE CENTER LIGHTS HAVE PROGRESSIVELY BEEN GETTING DIMMER TO THE POINT THE MILEAGE INFORMATION, DIRECTION OF TRAVEL AND TEMP ARE UNREADABLE IN DAYLIGHT HOURS. HOWEVER, AT NIGHT, WHEN THE AUTO LIGHTS TURN ON, THE MESSAGE CENTER IS QUITE CLEAR. *TR

WHILE DRIVING ALONG AT 55 MPH ENGINE SHUT DOWN. NO POWER BRAKES, STEERING, ETC. INDICATOR MESSAGE ON DASHBOARD SAID "CHECK ELECTRONIC IGNITION". REPAIR COST $ 724.19. *TR

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION. *TR

FOR THE 3RD TIME IN THE PAST YEAR I AM DRIVING DOWN THE ROAD AT ABOUT 40 MPH - ENGINE LIGHTS COMES ON, MESSAGE "CHECK ELECTRONIC THROTTLE CONTROL" COMES ON - I HAVE NO POWER, I COAST TO THE SIDE LANE TURN ON HAZARD LIGHTS, TURN KEY TO OFF POSITION. RESTART THE CAR (TAKES A COUPLE OF TRIES) AND CONTINUE - THIS IS EXTREMELY DANGEROUS AND SHOULD BE ADDRESSED BY FORD ( I HAVE REPORTED THIS ISSUE) LOOKING ON LINE AND ON ONE SITE HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPEDITION/2005/ENGINE/VEHICLE_SPEED_CONTROL.SHTML THERE ARE 52 COMPLAINTS WITH THE SAME ISSUE. THERE ARE MANY OTHER SITES REPORTING THE SAME EXACT PROBLEM. I AM TAKING MY VEHICLE TO THE DEALER TOMORROW - WHAT ELSE SHOULD I BE DOING TO RESOLVE THIS ISSUE. - IT'S APPARENT THAT MANY OTHER PEOPLE ARE HAVING THIS SAME EXACT ISSUE- DOES IT TAKE SOMEONE DYING TO GET THE CAR MANUFACTURERS TO LISTEN TO THEIR...

I WAS DRIVING MY 2005 FORD EXPEDITION AT 25MPH AND CAME TO A STOP LIGHT. I STOPPED. I TRIED TO ACCELERATE BUT I COULDN'T. MY RPM WHERE MOVING BUT CAR WOULD NOT. THEN THE CHECK ELECTRIC THROTTLE CONTROL MESSAGE POPPED ON. CAR FINALLY STARTED TO ACCELERATE BUT DIED OUT. IT THEN RESTARTED AND DROVE NORMALLY FOR 4 BLOCKS, BEFORE NOT ACCELERATING AT ALL. HAD TO BE TOWED TO FORD DEALER. THIS NEEDS TO BE RECALLED. *TR

VEHICLE DIED UNEXPECTEDLY WHILE TRAVELING DOWN HIGHWAY AT A HIGH RATE OF SPEED. THERE ARE HUNDREDS OF COMPLAINTS JUST LIKE THIS ON HERE. IF A RECALL ISN'T IN ORDER PEOPLE WILL DIE AND THE LAWSUITS WILL BEGIN. IT'S OBVIOUSLY A MAJOR MECHANICAL PROBLEM. FORD AND THE NHTSA SHOULD BE LIABLE. THIS IS SERIOUS AND READING THROUGH ALL OF THESE COMPLAINTS IT DOESN'T SEEM LIKE THE NHTSA IS DOING THEIR JOB. *TR

WHILE DRIVING HOME DOWN A SLIGHT DECLINE, I HEARD A BEEP AND THE MESSAGE ON THE DASH READ (CHECK ELECTRONIC THROTTLE CONTROL) WHICH I THEN MENTALLY ADDED TO MY LIST OF THINGS TO DO. NOT UNTIL A NEEDED TO START ACCELERATING AGAIN DID I REALIZE THAT MY THROTTLE WAS COMPLETELY INOPERABLE. LUCKILY, A WORD USED FREQUENTLY BY OTHER OWNERS TO DESCRIBE THIS SAME ISSUE, I WAS ABLE TO COAST TO A STOP WHILE OTHER VEHICLES WENT AROUND ME. TURNING OFF THE VEHICLE AND RESTARTING IT SEEMED TO "RESET" THE THROTTLE CONTROL. I DO NOT TRUST THAT IT WILL BE SAFE TO USE, PARTICULARLY WITH THE WINTER DRIVING CONDITIONS THAT I ENCOUNTER. I HAVE AN APPOINTMENT SCHEDULED FOR MONDAY. WITH ALL THE COMPLAINTS I HAVE SEEN REGARDING THIS SAME ISSUE, I AM SHOCKED THAT MORE ACTION (RECALL) HAS NOT BEEN TAKEN. DOES A CRASH, FIRE, INJURY, OR FATALITY NEED TO OCCUR...

WHILE DRIVING 55MPH ON INTERSTATE 95 IN PHILADELPHIA, PA WITH MY WIFE AND 2 CHILDREN THE VEHICLE STOPPED RUNNING AND I WAS DANGEROUSLY STALLED IN THE MIDDLE OF INTERSTATE 95. THE CHECK ENGINE LIGHT CAME ON AND CHECK ELECTRONIC THROTTLE MESSAGE CAME ON. THIS IS A FAMILY VEHICLE AND MY WIFE AND I REFUSE TO DRIVE IT NOW IN FEAR OF THIS INCIDENT OCCURRING AGAIN RESULTING IN DEATH OR SERIOUS INJURY. BASED UPON MY RESEARCH, IT APPEARS TO BE A WELL KNOWN PROBLEM THAT OCCURRED TO THOUSANDS OF FORD EXPEDITION OWNERS. I WOULD APPRECIATE THE PROBLEM BEING ADDRESSED EXPEDITIOUSLY BEFORE PEOPLE ARE KILLED AND/OR INJURED. *TR

DRIVING ON HIGHWAY AT ABOUT 60 MPH CHANGING LANES AND A ODB MESSAGE APPEARS "CHECK ELECTRONIC THROTTLE CONTROL" AND THE CAR JUST SHUTS DOWN. IT WAS A LIFE THREATENING MOMENT FOR MY FAMILY AND I AS A TRUCK THAT WAS ON COMING FROM BEHIND WITH SPEED HAD TO SLAM ON THE BRAKES IN ORDER NOT TO COLLIDE WITH ME SINCE I HAD NO POWER TO ACCELERATE. I WAS ONLY FORTUNATE THAT THE TRUCK HAD A CLEAR LANE TO CHANGE INTO ABRUPTLY. THE ELECTRONIC THROTTLE MESSAGE AFTER FURTHER RESEARCH IS A WIDE SPREAD KNOW ISSUE AMONG FORD CARS AND I AM LIVID AND VERY ANGRY THAT THE NHTSA HAS NOT ISSUED A RECALL ON THIS KNOW ISSUE AS IT IS PUBLIC KNOWLEDGE ONLINE. THIS NEEDS TO BE ADDRESSED IMMEDIATELY TO AVOID ANY POTENTIAL FUTURE TRAGEDIES. I HOPE FORD DOES NOT WANT BLOOD ON THERE HANDS! *TR

I WAS DRIVING WITH 4 KIDS IN THE CAR, WHEN ALL THE SUDDEN MY CAR TURNED OFF, ALL THE LIGHTS CAME ON THE DASH. LUCKILY I WAS ABLE TO MOVE OVER TO A PARKING LOT. I TURNED THE CAR OFF, TURNED BACK ON, NOTHING. TRIED AGAIN AND IT WORKED. I WAS ABLE TO DRIVE 50 MILES HOME AND AS I WAS TURNING IN MY DRIVEWAY IT HAPPENED AGAIN. *TR

REAR DRIVER SIDE PASSENGER WINDOW WENT DOWN BY ITSELF AND THERE IS NO WAY TO SEND IT UP. IS STUCK OPEN. I AM REPORTING BECAUSE I FOUND MORE THAN 20 FORUMS ONLINE WITH HUNDREDS OF REPORTED COMPLAINTS ON THE SAME ISSUE AND I DON'T SEE THE NECESSARY RECALL ON THIS ITEM. *TR

WHILE DRIVING AT 40 MPH ENGINE STOPPED WORKING MAKING BRAKES AND STEERING FAIL. LIMPED OFF BUSY ROAD LUCKILY! ENGINE LIGHT SHOWED ELECTRONIC THROTTLE FAILURE. NOW CHECK ENGINE LIGHT IS ON. GOING TO DEALERS FOR REPAIR TODAY-SINCE THIS IS AN OBVIOUS PROBLEM FOR FORD WHY HAVEN'T THEY ADDRESSED IT! COULD BE DEADLY IF FAILS IN HEAVY TRAFFIC CONDITIONS. *TR

THE SPARK PLUG BROKE IN THE ENGINE COSTING A LOT OF MONEY TO REPAIR. NOW ANOTHER ONE IS STUCK AND I CANT AFFORD TO GET IT FIXED. THIS COULD POSSIBLY CAUSE FIRE AND CREATE A SAFETY HAZARD. THERE ARE NUMEROUS COMPLAINTS OUT THERE AND THIS REALLY NEEDS TO BE A RECALL SITUATION. *TR

FIRST TIME IT OCCURRED I WAS TRAVELING TO WORK THE CAR STALLED WHILE DRIVING APPROX. 20 MPH AND THERE WAS NO CONTROL OF THE CAR - WAS ABLE TO MOVE TO SIDE OF ROAD AND RESTART. FAULT ON THE CONSOLE WAS "ELECTRONIC THROTTLE". HAS HAPPEN APPROX 4 MORE TIMES AT VARIOUS SPEEDS AND CONDITIONS WITH THREE DIFFERENT DRIVERS. NO PROBLEM EVER FOUND BY DEALER. HAS HAPPENED AT HIGH SPEED ON THE FREEWAY COMPLETE LOSS OF STEERING AND POWER OCCURS MORE CONCERNING IT CAN HAPPEN AT ANY TIME WITHOUT WARNING. I FIND THIS TO BE EXTREMELY DANGEROUS AND A DEATH TRAP WAITING TO HAPPEN. THE LAST TIME IT OCCURRED WHEN BY TEENAGE DAUGHTER WAS DRIVING SHE WAS SCARED TO DEATH REFUSING TO DRIVE IT HOME. THIS REMINDED ME OF TOYOTA PRIUS SO I TOOK IT UPON MYSELF TO REPORT MY INCIDENTS. LOOKING AT THE INTERNET I NOW FIND IT OCCURS FREQUENTLY...

MY 2005 EXPEDITION WAS TRAVELING AT A SPEED OF 40MPH WHEN IT STOPPED ACCELERATING AND DIED IN TRAFFIC WHILE I WAS TAKING MY KIDS TO SCHOOL. I COULDN'T TURN THE STIRRING WHEEL TO GET OFF OF THE ROAD. THIS IS A VERY DANGEROUS PROBLEM AND IT HAS HAPPENED TO ME ABOUT THREE OR FOUR TIMES. ONCE IT HAPPENED WHEN I WAS PULLING OUT INTO TRAFFIC ON A HILL THANK GOD NO ONE ELSE WAS COMING. *TR

THE AIR CONDITIONING UNIT IS LEAKING EXCESSIVE AMOUNTS OF WATER UNDER THE CARPET AND THE WATER IS POOLING UNDER THE RUG AND FLOWING INTO THE CHANNEL WHERE THE WIRING HARNESS IS LOCATED. THIS WIRING HARNESS DOES NOT LOOK TO BE PROTECTED FROM WATER AND IT IS A MATER OF TIME BEFORE THE INSULATION ON THIS WIRE BREAKS DOWN AND SHORTS OUT TO THE FRAME. *TR

WARNING LIGHT SAID ELECTRONIC THROTTLE CONTROL, THIS IS THE THIRD TIME I HAVE ALMOST HAD A MAJOR ACCIDENT AND FORD TELLS ME TO CALL THEM WHEN I HAVE AN ACCIDENT OR THE CODE SHOWS BACK UP. THEY ADMIT THAT THEY ARE AWARE OF THIS ISSUE BUT IT MUST FAIL COMPLETELY BEFORE IT CAN BE REPLACED UNDER WARRANTY OR RECALL. ALSO THE TRUCK CUTS OUT AT 60MPH AND JERKS UNTIL YOU SPEED UP. THEY ADVISED THEY ARE ALSO AWARE OF THIS PROBLEM AND COME BACK WHEN IT BREAKS DOWN. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED. THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND A WARNING NOTIFICATION APPEARED, INDICATING THERE WAS A CHARGING SYSTEM FAILURE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING AND THE TECHNICIAN STATED THE COMPUTER HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

I WAS DRIVING ON FOUR LANE HIGHWAY IN RIGHT LANE AT 40MPH. I NOTICED THE CAR STARTING TO SLOW DOWN AND WHEN I PRESSED THE GAS PEDAL IT DID NOT REACT AND THE CAR CONTINUED TO SLOW DOWN. I LOOKED AT MY GAUGES ON THE DASH AND THERE WERE NO WARNING LIGHTS AND ALL GAUGES READ NORMALLY. I THOUGHT I COULD SMELL SMOKE, AND THE CAR CONTINUED TO SLOW DOWN, AND I KNEW I NEEDED TO GET OFF THE ROAD AS TRAFFIC WAS HEAVY. AS I PULLED OFF THE ROAD INTO THE PARKING LOT FOR THE STRIP MALL, THE CAR STALLED, LIGHTS CAME ON THE DASH TO INDICATE THE CAR STALLED AND I WAS ABLE TO STOP THE CAR, PUT IT IN PARK AND TURN THE CAR OFF. I COULD SMELL SMOKE AND I COULD SEE SMOKE GOING OUT THE CAR WINDOWS FROM INSIDE THE CAR AS I HAD THE...

I WAS DRIVING THE VEHICLE AND IT IMMEDIATELY LOST ACCELERATION. AN ALARM ON DASH IDENTIFIED THE PROBLEMS AS ELECTRONIC THROTTLE CONTROL FAILURE. THIS WAS VERY DANGEROUS AND I WAS LUCKY NO ONE WAS FOLLOWING ME CLOSE. MY WIFE IS NOW SCARED TO DRIVE THE VEHICLE AND I DON'T KNOW WHAT TO DO. THERE ARE MANY COMPLAINTS ON THE WEB ABOUT THIS ISSUE WHICH I WOULD HAVE THOUGHT A RECALL WOULD BE INITIATED BY FORD. I SEARCHED AND FOUND OUT THAT THERE WAS NO RECALL ON THIS ISSUE. I CALLED FORD MOTOR COMPANY AND THEY INFORMED ME THAT I WAS THE FIRST ONE TO COMPLAIN ABOUT THIS ISSUE. I FIND THAT VERY HARD TO BELIEVE WITH EVERYTHING I HAVE READ ON THE WEBSITE. ANYONE ONE WHO READS THIS THAT HAS HAD THE PROBLEM SHOULD CALL FORD MOTOR COMPANY AND COMPLAIN. JUST GO TO FORD.COM AND CLICK ON SUPPORT TO GET THE...

VEHICLE HAS BEEN STALLING FOR ALMOST A YEAR. VEHICLE SHUT OFF ON BUSY HIGHWAY AND TOWED TO NEARBY REPAIR SHOP. MECHANIC FOUND FUEL PUMP CONTROL MODULE COMPLETELY CORRODED FROM BEHIND AND CIRCUIT BOARD EXPOSED TO MOISTURE. THE FPCM FRIED AND SHORTED OUT ONE LEG OF THE FUEL PUMP. BOTH PIECES HAD TO BE REPLACED. NEW FPCM INSTALLED WAS OBVIOUSLY REDESIGNED SO MODULE WOULD NOT SUFFER THIS FLAW AGAIN. I AM FINDING AN ALARMING AMOUNT OF COMPLAINTS ON THE INTERNET OF FORD EXPEDITION OWNER EXPERIENCING THE EXACT SAME PROBLEMS UNDER MORE DANGEROUS CONDITIONS. *KB

TRAVELING ALONG CONGESTED CITY STREET DURING MORNING RUSH AND VEHICLE LOOSES ALL POWER. INSTRUMENT CLUSTER LIGHTS ARE ALL ON. MESSAGE SAY "CHECK ELECTRONIC THROTTLE" I WAS ABLE TO TURN THE VEHICLE OFF AND BACK ON TWICE BEFORE THE ERROR CLEARED. I HAVE AN APPOINTMENT AT THE DEALERSHIP IN THE MORNING. BUT THESE OTHER REPORTS DON'T GIVE ME MUCH HOPE. AND I JUST PAID OFF THE NOTE LAST WEEK. *TR

2005 EXPEDITION RANDOMLY STALLS AT VARIOUS SPEEDS USUALLY AROUND 45 - 50 MILES PER HOUR. YOU HAVE TO TRY TO GET TO THE SIDE OF THE ROAD, STOP AND GIVE THE CAR A COUPLE OF MINUTES AND CRANK IT AGAIN. I HAVE TAKEN TO FORD DEALERSHIP AND I NEED A THROTTLE POSITION SENSOR. IT WILL BE $700 TO FIX. THE PERSON THAT OWNED THE VEHICLE BEFORE ME HAD ALREADY REPLACED THIS SAME PART. MY CONCERN IS I SPEND THE $700 AND STILL HAVE THE SAME PROBLEM. THIS IS A SERIOUS SAFETY ISSUE, I STAY IN CONSTANT FEAR THAT IT IS GOING TO STALL AT ANY MINUTE. I CAN'T BELIEVE FORD HAS NOT RECALLED THIS. THIS IS MY SECOND FORD BUT WILL BE MY LAST. *TT

OUR VEHICLE IS A 2005 FORD EXPEDITION LIMITED. ON TWO OCCASIONS THIS VEHICLE HAS UNEXPEDTEDLY LOST ALL POWER WITH THE MESSAGE "CHECK ELECTRONIC THROTTLE" APPEARING. ON ONE OCCASSION WE WERE MAKING A LEFT TURN ON A BUSY ROAD. WHEN THE VEHICLE LOST POWER WE WERE STUCK IN THE MIDDLE OF THE ROAD WITH ONCOMING TRAFFIC HAVING TO STOP SUDDENLY TO KEEP FROM HITTING US BROADSIDE. TURNING OFF THE IGNITION AND RESTARTING THE CAR MADE THE PROBLEM GO AWAY. LAST WEEK MY WIFE AND SON WERE IN THE VEHICLE COMING TO A STOP AT AN INTERSECTION. WHEN APPLYING THE BRAKE THE VEHICLE SUDDENLY ACCELERATED. MY WIFE HAD TO BREAK HARD AND NARROWLY MISSED HITTING THE CAR IN FRONT OF HER. THE VEHICLE WAS BROUGHT TO THE DEALERSHIP WHERE I WAS INFORMED THAT THEY WILL NEED TO REPLACE THE THROTTLE BODY. AFTER RESAEARCHING THIS ISSUE ON THE INTERNET IT APPEARS THAT BOTH...

WE WIFE HAS A 2005 FORD EXPEDITION, IT IS USED MAINLY FOR HER TO HAUL OUR KIDS TO PRACTICE AND SCHOOL BACK AND FORTH. THE TRUCK IS CONSTANTLY DYING WHILE DRIVING IT. THE DISPLAY SHOWS CHECK ELECTRONIC THROTTLE CONTROL". THIS MORNING SHE WAS TAKING THE KIDS TO SCHOOL WHEN IT DIED WHILE GOING THROUGH AN INTERSECTION. I HAVE TALKED TO SEVERAL DIFFERENT DEALERS WHO SAY THEY NEVER HEARD OF THIS PROBLEM, BUT CAN CHECK IT OUT FOR $$$$$$ YET I CAN SEARCH THE INTERNET AND FIND THE SAME PROBLEM HAPPENING TO THESE EXPEDITIONS. MY QUESTIONS IS WHY ISN'T FORD BEING RESPONSIBLE AND GETTING THESE RECALLED AND REPAIRED BEFORE SOMEONE IS KILLED IN THESE VEHICLES. CAN YOU IMAGINE DRIVING WITH YOUR LOVED ONES AND LOOSING FULL CONTROL OF YOUR VEHICLE AT ANYTIME.WE HAVE EXPERIENCED THE SHUTDOWN AT ALL SPEEDS. IT IS GETTING WORSE. WHERE IS THE RECALL FORD?? BEFORE SOMEONE IS...

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT HEARD A BEEPING NOISE AND THEN NOTICED THAT THE CHECK ELECTRONIC THROTTLE WARNING LIGHT WAS ILLUMINATED AS THE VEHICLE LOST POWER. THE FAILURE RECURRED ON FOUR SEPARATE OCCASIONS. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHO ADVISED THE CONTACT THAT THE ELECTRONIC CONTROL MODULE HAD FAILED. HE REMOVED THE BATTERY TERMINAL, RESET THE COMPUTER, CLEARED ALL CODES, REPLACED THE THROTTLE POSITION CENSOR, AND CLEANED THE THROTTLE BODY. THE DEALER WAS NOTIFIED OF THE PREVIOUS FAILURES AND DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS 110,000 AND THE FAILURE MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE. UPDATED 04/25/11 *BF THE CONSUMER STATED THE PROBLEM HAPPENED FOR A SECOND TIME. UPDATED 06/20/11

CARS SHUTS OFF WHILE DRIVING! I HAVE EXPERIENCE THIS FOUR TIMES AT VARIOUS SPEEDS. THE CAR SHUTS OFF AND THE CHECK ELECTRONIC THROTTLE CONTROL LIGHT COMES ON. TWICE HAVE BEEN ON THE FREEWAY AT 65 MILES PER HOUR WITHOUT WARNING. BOTH TIMES I WAS ABLE TO START ENGINE BY PUTTING IT IN NEUTRAL WHILE DRIVING. ALTHOUGH I WOULD NOT RECOMMEND PERFORMING THIS TECHNIQUE AS YOU MAY ACCIDENTALLY PUT THE CAR INTO REVERSE AND AT THAT SPEED IT COULD BE RISKY. HOWEVER, I HAD NO CHOICE BECAUSE OF THE LANE I WAS IN. AS MOST HAVE MENTIONED, THIS IS SERIOUS PROBLEM ESPECIALLY WHEN DRIVING WITH FAMILY IN VEHICLE. MY WIFE WILL NOT DRIVE THE CAR BECAUSE SHE'S AFRAID...I DON'T BLAME HER. FORD SELLS ITSELF AS A FAMILY ORIENTED COMPANY SO LETS PROTECT OUR FAMILIES AND FIX THE PROBLEM. THESE COMPLAINTS DATE AS FAR BACK AS 2005. ARE THEY WAITING UNTIL SOME...

DRIVING AT 45 MPH VEHICLE JUST TURNS OFF AND HAS NO POWER. HARD TO STEER AND BRAKE. DASH SAYS "CHECK ELECTRONIC THROTTLE CONTROL". AFTER PULLING OVER VEHICLE WILL RESTART. THIS HAS HAPPENED THREE TIMES NOW AND DEALER SAYS THERE IS NOTHING WRONG. *TR

I WAS DRIVING UP THE HIGHWAY WITH MY TWO KIDS IN MY CAR. I WAS TRAVELING ABOUT 40 MPH. ALL OF A SUDDEN I HEAR THE BEEP ON MY SYSTEM AND IT STATED THAT I NEEDED TO " CHECK ELECTRONIC THROTTLE CONTROL". I LAID OFF THE GAS AND WENT THRU A LIGHT WHEN I ATTEMPTED TO HIT THE GAS AGAIN I REALIZED I HAD NO POWER AT ALL AND I WAS COASTING. I GOT IN THE TURNING LANE AND HAD TO PULL IN FRONT OF A CAR JUST SO I WOULD NOT BE STUCK IN THE MIDDLE OF THE ROAD WHERE MY KIDS AND I WOULD HAVE BEEN IN AN ACCIDENT. I WAITED ABOUT 10 MINUTES AND THE VEHICLE FIRED UP. I WAS IN TEARS TRYING TO MAKE IT TO MY OFFICE BECAUSE I FELT LIKE IT MIGHT HAPPEN AGAIN. THE WHOLE MILE IT TOOK FOR ME TO GET THERE...

I WAS TRAVELING W/B ON I-96 NEAR THE OKEMOS EXIT WHEN MY 2005 FORD EXPEDITION'S ENGINE SUDDENLY SHUT OFF. A WARNING STATING, "CHECK ELECTRONIC THROTTLE CONTROL" CAME ON. I EXITED THE EXPRESS WAY. THE ENGINE STILL RAN IN IDLE, BUT WOULD NOT RUN ANY FASTER THAN THAT. I PULLED INTO A PARKING LOT AND SHUT OFF THE ENGINE. I RESTARTED THE VEHICLE AND IT BEGAN RUNNING NORMALLY AGAIN. APPROXIMATELY FIVE MINUTES LATER, WHILE I WAS EXITING A PARKING LOT, THE SAME THING HAPPENED AGAIN. THIS TIME THE ENGINE WOULD NOT RUN AT ALL AND THE POWER STEERING STOPPED WORKING. I RESTARTED THE VEHICLE AGAIN AND IT RAN FINE. HOWEVER, THE CHECK ENGINE LIGHT IS NOW ILLUMINATED. I HAVE RESEARCHED ONLINE AND HAVE OBSERVED THAT THIS IS A PROBLEM FOR MANY PEOPLE. THERE ARE FORUMS OF COMPLAINTS ABOUT THIS EXACT SAME PROBLEM FOUND ON COUNTLESS WEBSITES. FURTHERMORE, THIS IS A VERY...

THIS IS THE FIFTH INCIDENT REGARDING THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE THE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT ANY FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #5), THE CAR WAS TRAVELING AT APPROXIMATELY 25 MPH SOUTH ON 14TH ST NW IN WASHINGTON, DC, WHEN THE CAR LOST THE ABILITY TO ACCELERATE, AND THE "CHECK ELECTRONIC THROTTLE CONTROL" WARNING APPEARED IN THE DASHBOARD MESSAGE CENTER. DUE TO TRAFFIC AND STREET PARKING CONDITIONS,...

WHILE TRAVELING 50 MPH ON BUSY STREET CAR POWER FAILED, SHUTTING OFF COMPLETELY INCLUDING LOSS OF POWER STEERING. ENGINE FAILURE LIGHT CAME ON. RESTARTED AFTER THAT AND DROVE FINE. SINCE THEN IT HAS OCCURRED 3 TIMES OVER LAST MONTH. LAST WEEK OCCURRED AT WHEN I WAS ATTEMPTING TO TURN WITH A TURN SIGNAL BUT SHUT OFF BEFORE I COULD MAKE THE TURN. THIS IS A LIFE THREATENING PROBLEM AND NEEDS TO BE RECALLED. THOUGHT IT HAD TO DO WITH LOW GAS TANK BUT HAD PLENTY OF GAS LAST WEEK. *TR

THIS IS THE FOURTH INCIDENT REGARDING THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE THE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT ANY FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #4), THE CAR WAS TRAVELING AT APPROXIMATELY 10 MPH AND WAS TURNING RIGHT INTO A SUPERMARKET PARKING LOT IN CHEVY CHASE, MARYLAND. AS THE CAR PULLED INTO THE PARKING LOT, THE CAR LOST THE ABILITY TO ACCELERATE, THE "CHECK ELECTRONIC THROTTLE CONTROL" WARNING APPEARED IN...

STOPPED AT A TRAFFIC LIGHT INTERSECTION TO MAKE A RIGHT TURN. WHILE I WAS MAKING THE RIGHT TURN ABOUT 5 MPH, THE 2005 FORD EXPEDITION STALLED AND ALL THE LIGHTS WENT ON. I WAITED FOR ABOUT 10 SECONDS TO TURN ON THE CAR. THE CAR STARTED. I STOPPED 5 MINUTES LATER TO STOP THE ENGINE TO SEE IF EVERYTHING WAS OK. IT TOOK TWO TRIES TO START THE ENGINE. I TOOK IT TO A FORD DEALER THE NEXT DAY TO GET IT INSPECTED. THEY CLAIM IT WAS THE "THROTTLE POSITION SENSOR". I GOT THAT REPLACED FOR ~$340.00. *TR

I OWN A 2005 FORD EXPEDITION AND HAVE EXPERIENCED LOSING ALL THROTTLE CONTROL ON THE FREEWAY. I WAS LUCKY ENOUGH TO MAKE IT SAFELY TO THE SIDE OF THE ROAD. I WAS SCARED . THERE WERE 5 PEOPLE IN THE VEHICLE INCLUDING TWO YOUNG CHILDREN. VERY DANGEROUS! THIS HAPPENS WITHOUT WARNING. AFTER ABOUT 5 MINUTES, THE VEHICLE STARTED UP AGAIN WITHOUT ANY PROBLEMS. TODAY I HAVE A DIFFERENT PROBLEM. O/D LED FLASHES ON DASH AND VEHICLE WILL NOT ACCELERATE PROPERLY. I HAD IT TOWED TO THE NEAREST MECHANIC. THEY SUSPECT A TRANSMISSION FAULT. I WISH I NEVER DECIDED ON GETTING THIS SUV. I SHOULD NOT BE SCARED TO DRIVE MY CAR. FORD NEEDS TO FIX THIS PROBLEM ASAP!!!!! *TR

THIS IS INCIDENT 3 OF 3 WITH RESPECT TO THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #3), THE CAR WAS TRAVELING AT APPROXIMATELY 25 MPH ON A TWO-LANE (ONE LANE IN EACH DIRECTION) DC CITY STREET. THE CAR LOST POWER COMPLETELY, AND THE DRIVER WAS NOT ABLE TO MOVE THE CAR OUT OF THE LANE OF TRAFFIC, THEREBY BLOCKING THE...

THIS IS INCIDENT #1 OF 3 WITH RESPECT TO THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #1), THE CAR WAS TRAVELING AT APPROXIMATELY 35 - 40 MPH ON A THREE-LANE (IN EACH DIRECTION) STATE HIGHWAY. THE DRIVER WAS ABLE TO MOVE THE CAR FROM THE MIDDLE LANE TO THE RIGHT LANE BEFORE LOSING ALL POWER TO ACCELERATE. THIS ROAD HAS...

THIS IS INCIDENT #2 OF 3 WITH RESPECT TO THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #2), THE CAR WAS TRAVELING AT APPROXIMATELY 60 MPH ON A FOUR-LANE (IN EACH DIRECTION) INTERSTATE HIGHWAY (THE INNER LOOP OF THE CAPITAL BELTWAY IN MONTGOMERY COUNTY, MD). THE DRIVER WAS ABLE TO MOVE THE CAR FROM THE SECOND LANE FROM THE RIGHT TO...

2005 FORD EXPEDITION. WHILE DRIVING ON THE HWY THE "CHECK ELECTRONIC THROTTLE CONTROL" LIGHT CAME ON AND SHUT DOWN MY CAR.. I HAD NO ACCELERATOR PEDAL CONTROL. THIS OCCURS ON AVERAGE ONCE A MONTH. WHEN THIS HAPPENS ,YOU HAVE NO POWER. YOU HAVE TO COAST TO THE SIDE OF THE ROAD AND CALL FOR HELP. *TR

I WAS DRIVING 55MPH ON HIGHWAY, WHEN ALL OF A SUDDEN THERE WAS NO POWER TO GAS PEDAL. THE CHECK ELECTRONIC THROTTLE CONTROL LIGHT FLASHED, I PULLED OVER THREE LANES TO SIDE OF ROAD. I SAT THERE TRYING TO START VEHICLE CONTINUOUSLY, FINALLY AFTER 10 MINUTES IT STARTED. *TR

OUR 2005 FORD EXPEDITION HAS SHUT OFF WITHOUT WARNING TWICE NOW. THE FIRST TIME THIS HAPPENED WE WERE DRIVING BACK FROM MISSOURI TO VIRGINIA AFTER THE HOLIDAYS IN JANUARY OF THIS YEAR. WE WERE ON THE INTERSTATE DRIVING ABOUT 70 MPH WHEN THE CAR JUST STOPPED AND THE CHECK ENGINE LIGHT CAME ON. WE CALLED FORD AND THEY SAID TO LET IT SIT FOR 30 MINUTES AND THEN TRY TO START THE CAR AGAIN. WE DID AND IT WORKED. THE TECHNICIAN EXPLAINED THAT IT MAY HAVE BEEN THE COLD WEATHER. JUST YESTERDAY 12 SEPT 2010 MY WIFE WAS DRIVING HOME FROM WORK WHEN THE CAR SHUT OFF ON ITS OWN AGAIN AND THE CHECK ENGINE LIGHT ILLUMINATED. SHE WAITED A FEW MINUTES AND THE CAR STARTED AGAIN. THE COLD HAD NOTHING TO DO WITH IT YESTERDAY. BOTH TIMES WE WERE FORCED TO COAST TO THE SIDE OF THE ROAD IN...