2001 FORD EXPEDITION Visibilitywindshield Problems

I HAVE EXPERIENCED A WINDSHIELD LEAK ON MY 2001 FORD EXPEDITION. THIS HAS LEAD TO UNWANTED ELECTRICAL ACTIVITY WHEN THE VEHICLE IS UNATTENDED. THIS HAS INCLUDED THE RADIO COMING ON OR THE BLOWER MOTOR RUNNING AND EVEN THE STARTER ENGAGING WITH THE KEY REMOVED. I AM VERY CONCERNED ABOUT A POSSIBLE FIRE! *TR

WINDSHIELD LEAKING WATER CAUSING ERRATIC AND UNPREDICTABLE INTERMITTENT ELECTRICAL FAILURES IN A 2001 FORD EXPEDITION. THIS IS DANGEROUS. *TR

IN THE LAST FEW MONTHS, I HAVE NOTICED THAT WHEN IT RAINS, MY BLOWER MOTOR WILL RUN ON HIGH-SPEED AND MY LIGHTS WILL FLICKER AFTER I TURN THE VEHICLE OFF. AT FIRST IT WOULD STOP AFTER A FEW SECONDS, HOWEVER THIS LAST TIME, IT RAN FOR ABOUT 10 MINUTES AND FINALLY SHUT OFF. I HAVE A CO-WORKER WHO HAS THE EXACT SAME EXPEDITION AND ASKED HIM IF HE'S HAD THIS HAPPEN TOO HIM, WHICH HE STATED YES AND HAS BEEN GOING ON FOR AROUND 6 MONTHS. I CALLED FORD MOTOR CO TO INQUIRE ABOUT A RECALL, SINCE THIS IS VERY UNIQUE IN NATURE, AND (OF COURSE) THEY HAVE NO RECORD NOR KEEP ANY DATA ON ANYTHING (ACCORDING TOO THE REP). NOT QUITE SURE WHAT THEIR JOB IS! SO I CALLED THE LOCAL DEALER AND THEY WERE 'FAMILIAR' WITH MY PROBLEM AND HAD A 'FEW' FIXED. WELL, AFTER DOING SOME RESEARCH...

WATER LEAK IN THE FRONT WINDSHIELD (FOLLOWING A FEW CONSECUTIVE RAINY DAYS), CAUSING ELECTRICAL FAILURE OF THE DOME LIGHT, WIPERS, RADIO AND GEAR SELECTOR. FORD SERVICE ADVISED REPLACING THE FUSE BOX AND GEM MODULE FOR $1,100. THIS IS MY FAMILY VEHICLE AND I AM DEEPLY CONCERNED THAT THIS MAY CAUSE AN ELECTRICAL FIRE OR UNWNATED ELECTRICAL ACTIVITY WHEN THE CAR IS UNATTENDED. MY CAR IS JUST UNDER 80K MILES. I HAVE DONE SOME RESEARCH AND CAN SEE THAT THERE ARE MANY OTHERS THAT ARE EXPERIENCING SIMILAR PROBLEMS. THIS IS A SAFETY CONCERN THAT SHOULD SHOULD BE ATTENDED TO IMMEDIATELY. I HOPE THIS CAN BE RESOLVED WITHOUT TAKING LEGAL ACTION. *TR

AFTER RAIN OR HEAVY FOG WE EXPERIENCED MANY ELECTRICAL ISSUES ON OUR 01 EXPEDITION INCL. HORN NOT WORKING NORMAL,FRONT & REAR WIPERS NOT WORKING OR COMING ON BY THEMSELVES,DOOR LOCKS LOCKING/UNLOCKING WHILE DRIVING, INTERIOR & EXTERIOR LIGHTS NOT WORKING,ALARM SYSTEM GOING OFF WHILE SUV WAS BEING DRIVEN,FAN BLOWER ON AFTER SUV WAS TURNED OFF, RADIO WORKING INTERMITTENTLY, ETC. THE LATEST OCCURRED 1/16/08 AFTER HEAVY RAINS THE PRIOR NIGHT. SUV WOULDN'T START IN THE MORNING AND HAD TO BE JUMPED. IT WAS DRIVEN THAT DAY WITH ONLY ISSUE BEING INTERIOR LIGHTS COMING ON THEMSELVES. ON 1/17/08 SUV WOULDN'T TURN OVER AND AGAIN WAS JUMPED. THERE WAS CLICKING NOISE FROM ENGINE COMPARTMENT THAT SEEMED TO BE COMING FROM KELSEY HAYES BLACK BOX. WE IMMEDIATELY TOOK SUV TO DEALERSHIP AND ASKED FOR TECH TO WITNESS ISSUE. TECH CONFIRMED NOISE COMING FROM THE K-H ABS MODULE, SAID PROBLEM WAS PROBABLY DUE TO WINDSHIELD LEAK...

AFTER A RAIN AND ICE STORM WATER LEAKED AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS. WATER ENTERED THE ENGINE OF THE VEHICLE THROUGH AN IMPROPERLY SEALED WINDSHIELD CAUSING THE POWER DISTRIBUTION BOX AND THE GENERIC ELECTRONIC MODULE TO GET WET. THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE. THIS CAUSED THE VEHICLE TO STOP RUNNING. ELECTRICAL DAMAGE HAD TO BE REPAIRED AND A NEW WINDSHIELD HAD TO BE INSTALLED. THIS CAUSED THE OWNER TO PAY OVER $2000 IN OUT OF POCKET EXPENSES. *NM

MY WINDSHIELD ON MY 201 FORD EXPEDITION IS LEAKING AND HAS CAUSED MY GEM MODULE TO ACT UP. MOST NOTABLY WINDSHIELD WIPERS NOT WORKING, RADIO ON AND OFF. *NM

DT*: THE CONTACT STATED THE FRONT WINDSHIELD LEAKED RAINWATER INTO THE VEHICLE AND THE DASH PANEL AREA. AFTERWARDS, THE POWER AND ELECTRICAL FEATURES DID NOT WORK. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED DUE TO THE HEAVY RAIN THE WINDSHIELD SEAL LEAKED AND THE WATER CAUSED AN ELECTRICAL FAILURE OF THE CENTRAL JUNCTION BOX.

WINDSHIELD ON 2001 EXPEDITION LEAKS AND GEM MODULE HAS SHORTED OUT. *NM

FORD EXPEDITION 2001 WINDSHIELD LEAKING THROUGH HAND HOLDS ON RIGHT AND LEFT SIDE. DIAGNOSED AS WINDSHIELD SEALANT FAILURE BETWEEN THE HAND AND THE GLASS OVER APPROXIMATELY 75% OF THE SEALANT BAND AREA. SOLUTION: REMOVE GLASS, STRIP ALL SEALANTS, PRIME BODY, PRIME GLASS, REPLACE GLASS (BROKEN DURING REMOVAL). *JB

LEAKY WINDSHIELD CAUSED ELECTRICAL FAILURE OF THE GENERAL ELECTRONIC MODULE, CAUSING MOST SYSTEMS IN VEHICLE TO MALFUNCTION, INCLUDING TRANSFER CASE SWITCHING, TRANSMISSION SHIFTING. FORD, NOR ADVANTAGE WARRANTY COMPANY WOULD STAND BEHIND THE COST OF THIS FAILURE BROUGHT ON BY POOR QUALITY IN MANUFACTURING. *NM

2001 FORD EXPEDITION WINDSHIELD LEAKING INTO FUSE BOX AND GEM MODULE , CAUSING ELECTRICAL PROBLEMS AND SHORTS.*AK

MY WINDSHIELD ON MY 2001 EXPEDITION IS LEAKING WATER IN THE DRIVER SIDE LOWER CORNER. IT'S SEEPING INTO THE FLOOR BOARDS AND INTO THE ENGINE ELECTRICAL COMPARTMENT UNDER THE HOOD. *JB

DT: CONTACT STATES THE WINDSHIELD IS LEAKING, CAUSING THE COMPUTER IN THE FUSE PANEL TO SHORT OUT. THE STEREO, WINDSHIELD WIPERS, AND THE AIR CONDITIONER COME ON WHEN THE VEHICLE WAS NOT IN USE. WINDSHIELD WAS REPLACED. WARRANTY EXPIRED , AND ELECTRONIC PANEL HAD NOT BEEN REPLACED. FORD MANUFACTURER HAS BEEN CONTACTED.*AK

2001 FORD EXPEDITION (EDDIE BAUER) HAS HAD REPEATED WATER LEAKS IN FRONT WINDSHIELD. I'VE HAD THE WINDOW REPLACED ONCE AND REPAIRED 2 MORE TIMES, SO FAR IN THE PAST 2 YEARS. IT CAUSED MY AUTOMATIC HEAD-LIGHT CONTROL SWITCH TO FAIL. ALSO MY REAR-WINSHIELD WIPERS FAILED ONCE, BUT I'M NOT SURE IF IT WAS RELATED TO A WINDSHIELD LEAK.

THERE IS A LEAK THROUGH THE WINDSHIELD, ENABLING WATER TO RUN DOWN THROUGH THE ELECTRONIC MODULE. THIS IS CAUSING THE DASHBOARD LIGHTS TO TURN ON INTERMITTENTLY, AND CAUSING THE VEHICLE TO SHUT OFF. DEALER WILL REPAIR FOR THE SECOND TIME AT CONSUMER'S EXPENSE.*AK

WHILE BACKING UP, DRIVER'S SIDE WINDOW BUSTED, CAUSING INJURIES TO DRIVER.*AK *TT

WHEN THERE IS A GLARE THERE ARE A TON OF SPOTS ON WINDSHIELD AND IT DISTURBS CONSUMER WHEN DRIVING. CONTACTED DEALER WHO COULD NOT FIND CAUSE. *AK DEALER REPLACED THE WINDSHIELD, HOWEVER THE REPLACEMENT ALSO HAS SPOTS WHICH ARE ONLY SEEN DURING THE EARLY MORNING AND EVENING, THE DEALER IS WILLING TO REPLACE WITH ANOTHER BRAND OF GLASS, HOWEVER THE FORD REP DECLINED PAYMENT. *SLC

WHILE DRIVING AT 66 MPH VEHICLE VIBRATES AND SHAKES, CONSUMER TOOK THE VEHICLE THE TO DEALER, CAUSE UNKNOWN. *AK CONSUMER STATES CV BOOTS FAILED CAUSING FRONT-END TO SQUEAK, THE SEAT BELT HOLD STRAP FELL OFF, DRIVERS WINDOW DOES NOT CLOSE PROPERLY AND IT MAKES NOISE AND THE PASSENGER SIDE MIRROR SHAKES WHILE DRIVING. *YD