Vehicle Safety Data

1998 FORD EXPEDITION Engine And Engine Coolingexhaust System Problems

2 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Engine And Engine Coolingexhaust System Issues in the 1998 FORD EXPEDITION

2 engine and engine coolingexhaust system complaints have been filed with NHTSA for the 1998 FORD EXPEDITION. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.

2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths

All Engine And Engine Coolingexhaust System Complaints

#10312591 |
1998 FORD EXPEDITION 4X4 4.6L, THE POOR QUALITY STEEL USED FOR THE EXHAUST MANIFOLDS AND BOLTS RUST VERY FAST. MINE RESULTED IN THE DRIVERSIDE BOLTS RUSTING AWAY CAUSING EXHAUST COMING DIRECTLY OUT OF THE ENGINE, ALSO THE EGR TUBE RUSTED OFF THE DRIVERS MANIFOLD CAUSING HOT EXHAUST TO BLOW TOWARD THE TOP OF THE ENGINE. ON THE PASSENGER SIDE THE MANIFOLD BOLTS/STUDS ALSO RUSTED AWAY CAUSING EXHAUST TO DISPERSE IN THE ENGINE BAY. ALSO ON THE PASSENGER SIDE THE MANIFOLD CRACKED ABOUT 3 INCHES LONG ON THE TOP OF THE MANIFOLD CAUSING HOT EXHAUST TO BLOW UPWARD TO THE UPPER ENGINE BAY. I CORRECTED THIS PROBLEM BY REPLACING THE BAD MANIFOLDS/STUDS WITH PACESETTER SHORTY HEADERS AND BOLTS, IT WAS THE CHEAPEST FIX. THE PACESETTER SHORTY HEADER KIT WAS $150 FROM WWW.SUMMITRACING.COM . THE TRUCK WAS EXTREMELY LOUD BEFORE I FIXED THIS PROBLEM AND I WAS PULLED OVER FOR IT BY...
#10182116 |
ON THE UNDERSIDE OF THE VEHICLE THERE IS AN AUDIBLE, HIGH FREQUENCY RATTLE OR VIBRATION THAT IS INCREASED WHEN THE VEHICLE IS IN GEAR, STOPPED AND IN IDLE. THE NOISE REDUCES AND OFTEN GOES AWAY WHEN THE ENGINE RPMS ARE INCREASED ABOVE 600 PER MINUTE. THE VEHICLE HAS BEEN EXAMINED BY THE DEALER THREE TIMES, HAS HAD ALL OF THE EXHAUST BRACKETS TIGHTENED OR REPLACED TO NO AVAIL. OWNER WAS INFORMED THAT IT WAS A "BACKED OUT BOLT IN THE EXHAUST HEAT SHIELD", THIS BOLT WAS CHANGED BY DEALER ON THE 3RD TRIP, WITH NO CHANGE, IN FAT, THAT MADE IT WORSE. TWO DIFFERENT MUFFLER SHOPS HAVE LOOKED AT AND NOTICE NOTHING ELSE LOOSE OR MISSING. ON THE LAST VISIT TO THE DEALER, OWNER WAS TOLD THAT THE REASON FOR THE NOISE IS THAT THE "EXHAUST PIPE IS TORQUED AND TWISTED A LITTLE BIT FROM HEAT CONTRACTION AND EXPANSION." *NM

Other 1998 FORD EXPEDITION Problem Areas

Electrical System 60 complaints Engine And Engine Coolingengine 58 complaints Vehicle Speed Control 43 complaints Suspensionfrontspringstorsion Bar 39 complaints Suspensionfrontstabilizer Bar 32 complaints Power Trainautomatic Transmission 29 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip 29 complaints Engine And Engine Cooling 28 complaints Engine And Engine Coolingenginegasoline 28 complaints Vehicle Speed Controlcruise Control 28 complaints Wheelslugsnutsboltsstuds 28 complaints Suspensionfront 26 complaints Tires 26 complaints Suspension 22 complaints Steeringlinkagestie Rod Assembly 20 complaints Electrical Systemignition 17 complaints Power Train 17 complaints Engine 16 complaints Unknown Or Other 14 complaints Visibilitywindshield Wiperwasher 14 complaints Electrical Systemwiringfront Underhood 13 complaints Suspensionrear 13 complaints Air Bagsfrontal 12 complaints Visibilitypower Window Devices And Controls 12 complaints Fuel System Gasoline 9 complaints Power Trainautomatic Transmissiongear Position Indication Prndl 9 complaints Wheels 9 complaints Exterior Lighting 8 complaints Steeringhydraulic Power Assist System 8 complaints Structurebodydoor 8 complaints Electrical Systemalternatorgeneratorregulator 7 complaints Engine And Engine Coolingcooling System 7 complaints Equipmentapplianceair Conditioner 7 complaints Interior Lighting 7 complaints Latcheslockslinkagesdoorslatch 7 complaints Tirestreadbelt 7 complaints Visibilityrear Window Wiperwashermotor 7 complaints Visibilityrearview Mirrorsdevicesexterior 7 complaints Electrical Systemignitionmodule 6 complaints Electrical Systemwiring 6 complaints Equipmentelectricalradiotape Deckcd Etc 6 complaints Seat Beltsrearother 6 complaints Steering Steering Wheelhandle Bar 6 complaints Trailer Hitches 6 complaints Vehicle Speed Controlaccelerator Pedal 6 complaints Air Bags 5 complaints Electrical Systemwiringinteriorunder Dash 5 complaints Exterior Lightingheadlights 5 complaints Power Trainautomatic Transmissionparkneutral Start Interlock Switch 5 complaints Seat Beltsfrontbuckle Assembly 5 complaints Service Brakes Hydraulicfoundation Componentsdiscrotor 5 complaints Steering 5 complaints Structure 5 complaints Suspensionfrontspringsair Suspension System 5 complaints Visibilitywindshield Wiperwashermotor 5 complaints Equipment 4 complaints Equipmentmechanicalcarrierrack 4 complaints Exterior Lightingturn Signalflasher Unit 4 complaints Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap 4 complaints Fuel System Other 4 complaints Fuelpropulsion System 4 complaints Seat Belts 4 complaints Seat Beltsfrontanchorage 4 complaints Seats 4 complaints Service Brakes 4 complaints Service Brakes Hydraulic 4 complaints Steeringlinkages 4 complaints Structurebody 4 complaints Structureframe And Members 4 complaints Tiressidewall 4 complaints Visibilitydefrosterdefoggerhvac Systemheater Core 4 complaints Visibilitywindshield 4 complaints Electrical Systemhorn 3 complaints Electrical Systemwiringfuses And Circuit Breakers 3 complaints Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe 3 complaints Power Trainautomatic Transmissionlever And Linkagecolumn Shift 3 complaints Power Traindrivelinedifferential Unit 3 complaints Power Traindrivelinedriveshaft 3 complaints Power Traintransfer Case 4 Wheel Drive 3 complaints Seat Beltsfrontretractor 3 complaints Service Brakes Hydraulicfoundation Components 3 complaints Steeringgear Box Other Than Rack And Pinion 3 complaints Visibility 3 complaints Visibilityglass Siderear 3 complaints Electrical Systemignitionswitch 2 complaints Engine And Engine Coolingexhaust Systememission Control 2 complaints Exterior Lightingturn Signal 2 complaints Exterior Lightingturn Signalswitch 2 complaints Fuel System Gasolinedeliveryfuel Pump 2 complaints Fuel System Gasolinestoragetank Assembly 2 complaints Latcheslockslinkages 2 complaints Power Trainaxle Assembly 2 complaints Seat Beltsfrontwebbing 2 complaints Seatsfront Assemblyrecliner 2 complaints Service Brakes Hydraulicfoundation Componentsdisc 2 complaints Service Brakes Hydraulicfoundation Componentsdiscpads 2 complaints Service Brakes Hydraulicfoundation Componentshoses Linespiping And Fittings 2 complaints Steeringcolumn 2 complaints Structurebodybumpers 2 complaints Structurebodytrunk Lid 2 complaints Suspensionfrontcontrol Arm 2 complaints Tirestemporaryemergency Spare Tire 2 complaints Vehicle Speed Controllinkages 2 complaints Visibilitywiper 2 complaints Air Bagsfrontaldriver Sideinflator Module 1 complaint Air Bagsfrontalsensorcontrol Module 1 complaint Air Bagssidewindow 1 complaint Child Seat 1 complaint Electrical System Instrument Clusterpanel 1 complaint Electrical System12v24v48v Battery 1 complaint Engine And Engine Coolingcooling Systemhoseslinespipingfittings 1 complaint Engine And Engine Coolingenginegasolinebelts And Associated Pulleys 1 complaint Exterior Lightingbrake Lights 1 complaint Fuel System Gasolinedelivery 1 complaint Fuel System Gasolinedeliveryhoses Linespiping And Fittings 1 complaint Fuel System Gasolinestorageauxillary Tank 1 complaint Fuel System Gasolinestorageauxillary Tankselector Devices 1 complaint Fuel System Otherstoragefuel Gauge System 1 complaint Fuel System Otherstoragetank Assemblyfillingcharging 1 complaint Parking Brake 1 complaint Parking Brakeconventionalmechanicallinkage And Cable 1 complaint Parking Brakeindicator Light 1 complaint Power Traindriveline 1 complaint Power Trainmanual Transmission 1 complaint Seat Beltsfront 1 complaint Seatsfront Assemblypower Adjust 1 complaint Seatsfront Assemblyseat Heatercooler 1 complaint Service Brakes Airantilock 1 complaint Service Brakes Airantilockwheel Speed Sensor 1 complaint Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule 1 complaint Service Brakes Hydraulicbrake Fluid Low Warning Lamp 1 complaint Service Brakes Hydraulicfoundation Componentsdrum 1 complaint Service Brakes Hydraulicfoundation Componentsmaster Cylinder 1 complaint Service Brakes Hydraulicpedals And Linkages 1 complaint Steeringcolumn Lockinganti Theft Device 1 complaint Steeringhydraulic Power Assisthose Piping And Connections 1 complaint Steeringhydraulic Power Assistpump 1 complaint Steeringlinkagesknucklespindlearm 1 complaint Structurebodyhood 1 complaint Suspensionfrontcontrol Armlower Arm 1 complaint Suspensionfrontcontrol Armlower Ball Joint 1 complaint Suspensionfronthub 1 complaint Suspensionfrontmacpherson Strut 1 complaint Suspensionfrontshock Absorber 1 complaint Suspensionfrontwheel Bearing 1 complaint Suspensionrearshock Absorber 1 complaint Suspensionrearspringsair Suspension System 1 complaint Suspensionrearspringsair Suspension Systemspringsbags 1 complaint Visibilitydefrosterdefoggerhvac System 1 complaint Visibilitydefrosterdefoggerhvac Systemfanmotor 1 complaint Visibilitydefrosterdefoggerhvac Systemrear Window 1 complaint Visibilitydefrosterdefoggerhvac Systemwindshieldelectrical Heating Element 1 complaint Visibilityrear Window Wiperwasherlinkages 1 complaint Visibilityrearview Mirrorsdevices 1 complaint Visibilityrearview Mirrorsdevicesinterior 1 complaint Visibilitysunmoon Roof Assembly 1 complaint Visibilitywindshield Wiperwasherswitchwiring 1 complaint
← Back to 1998 FORD EXPEDITION overview
Check any vehicle history by VIN - Free vehicle history report