1997 FORD EXPEDITION Electrical System Problems

Vehicle will speed up or slow down in certain times for certain speeds without notice smell of smok and looked hurt wiring

WHEN EXAMINING MY VEHICLE WHICH SUPPOSEDLY HAD A RECALL ON THE CRUISE CONTROL SENSOR ON BRAKE MASTER CYLINDER, FOUND THAT FORD ONLY ADDED A FUSABLE LINK TO PREVENT FIRE AS THE SENSOR MAY NOT HAVE BEEN LEAKING AT THE TIME. IT HAS SINCE LEAKED AND THE ADDED BIT OF WIRE WITH THE BLUE TAG HAS BLOWN IT'S FUSES BUT I BELIEVE THE CRUISE CONTROL HAS NOW DISABLED MY HORN DURRING OPERATION. I AM REQUESTING MY VEHICLE BE SERVICED PROPERLY AS THE RECALL WAS NOT DONE CORRECTLY TO MY UNDERSTANDING. I WAS LOOKING ONLINE AND JUST REALIZED THIS SO I LOOKED AT MY VEHICLE AND SAW IT IS THE OLD DESIGN.

MISCELLANEOUS ELECTRICAL PROBLEMS CAUSED BY WATER LEAKING FROM DRIVER'S SIDE WINDSHIELD INTO THE FUSE BOX CAUSING, WINDSHIELD WIPERS TO QUIT. DOOR LOCK WON'T WORK, RADIO QUIT. PROBLEM IS NEVER THE SAME, DEPENDS ON WHERE THE WATER LEAK OCCURS. VERY SCARY AND DANGEROUS WHEN DRIVING AT NIGHT IN THE RAIN.

ELECTRICAL PROBLEMS ON MY 97 FORD EXPEDITION LIGHTS FLASHING RADIO ON AND OFF BY ITSELF. *TR

I WAS DRIVING DOWN THE STREET, GOING ABOUT 10 TO 15 MPH AND WHILE DRIVING I HAD NOT LIGHT ON MY DASHBOARD INDICATING ANY PROBLEMS ALL OF SUDDEN MY 97 FORD EXPEDITION MAKES THIS CRAZY SOUND AND COMPLETELY TURNS OFF. I WAS NOT ABLE TO START THE TRUCK UP AGAIN SO I HAD IT TOWED. AFTER TWO DAY PAST I TRIED STARTING THE TRUCK UP AND IT WOULD NOT DO ANYTHING. *TR

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. WHENEVER THE CONTACT DROVE THE VEHICLE HE NOTICED THAT THE DASHBOARD PANEL OCCASIONALLY FAILED TO FUNCTION. THE VEHICLE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 160,000.

THIS ISSUE WAS AT NIGHT WHILE DRIVING THE HEADLIGHT TO SEE AT NIGHT HAD TURNED OFF AT A 35 MPH SPEED NO BUMPS NO TURN JUST DRIVING STRAIGHT. THIS IS A SERIOUS ISSUE, YOU USE YOUR LIGHTS FOR NIGHT AND YOUR ARE LEFT WITH NO LIGHTS, AS A RESULT FOR THIS HUGE PROBLEM I RECEIVED A TICKET THAT IS HOW I FOUND OUT MY LIGHTS WERE NOT WORKING. THE HEADLIGHTS FUSES, MODULE COMPONENTS, WIRING WERE CHECKED NO ISSUES THERE, AS FOR ALL OTHER LIGHTS EXAMPLE EMERGENCY LIGHTS, REAR LIGHTS INTERIOR LIGHTS ARE FUNCTIONING. BUT AS THE ELECTRICIAN FOUND THE DIRECTIONAL SWITCH COMBO WAS BURNED LEFT WITH A WHITE SHADOW IN ONE AREA IT WAS REPLACED, AND NOW FUNCTIONING. AS FOR THE SUSPENSION NOT FUNCTIONING PROPERLY IS THIS AN ISSUE THAT HAS NOT BEEN ABLE TO BE RESOLVED. I HAVE TAKEN IT TO DIFFERENT SHOPS AND THERE IS NO AIR LEAKAGE...

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IDLED IN THE DRIVEWAY, HE NOTICED THAT THE EXTERIOR AND INTERIOR LIGHTS WERE FLASHING, THE STEREO WOULD TURN ON AND OFF, AND THE DOOR LOCKS WOULD LOCK AND UNLOCK. THE CONTACT UNPLUGGED THE BATTERY AND THE VEHICLE OPERATED AS NORMAL. IN ADDITION, THE CONTACT STATED THAT THE TRANSMISSION COMPLETELY FAILED AND THE CONTACT NOTICED WATER LEAKING IN FROM THE WINDSHIELD ONTO THE DASHBOARD. BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000 AND CURRENT MILEAGE WAS 197,000.

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WITH THE WINDSHIELD WIPERS ACTIVATED AND SUDDENLY WITHOUT WARNING THE WINDSHIELD WIPERS FAILED TO FUNCTION. IN ADDITION, THE ENTIRE ELECTRICAL SYSTEM FAILED WITH A STRONG BURNING ODOR EMITTING INSIDE OF THE VEHICLE. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THERE WAS WATER LEAKING INTO THE FUSE BOX AS A RESULT IT CAUSED A SHORTAGE WITHIN THE GEM MODULE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT THE MAIN COMPUTER, WHICH WAS HOUSED BEHIND THE MAIN FUSE BOX, WOULD ABSORB MOISTURE WHENEVER IT WOULD RAIN. THE FAILURE CAUSED SEVERAL FAILURES INCLUDING THE FAILURE OF ALL OF THE INSTRUMENT PANEL GAUGES, THE VEHICLE WOULD LOCK AND UNLOCK INDEPENDENTLY, THE INTERIOR LIGHTS WOULD ILLUMINATE INDEPENDENTLY, THE STARTER WOULD ATTEMPT TO ENGAGE WHEN THE VEHICLE WAS RUNNING AND WHEN THE KEYS WERE NOT IN THE IGNITION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO MADE SEVERAL REPAIRS TO NO AVAIL. IN ADDITION, THE MAIN COMPUTER WAS ALSO REPLACED B UT THE FAILURE PERSISTED AND WOULD ONLY RECUR WHEN IT RAINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 150,000. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

1997 FORD EXPEDITION LOST #7 SPARK PLUG. ALL 7 PEOPLE ON-BOARD DIED IN ENSUING FIRE. DEFECT KNOWN BY NHTSA AND FORD FOR MANY YEARS. NHTSA IS THE HEADLINE YOUR WAITING FOR? THIS IS YOUR RESPONSIBILITY. DO YOUR JOB. UPDATED 11/29/10 *BF UPDATED 12/07/10 *TR

CAR WAS DEAD WHEN I WOKE UP. JUMPED IT, SPEEDOMETER DIDN'T WORK AFTERWARD. LIGHTS IN RIGHT HAND CORNER BLINK ON AND OFF I WAS TOLD BY THE FORD DEALER IT IS A GEM MODULE IS GETTING WATER IN IT BUT I DO NOT HAVE A LEAK IN MY WINDSHIELD. I RESEARCHED ONLINE AND SEVERAL PEOPLE HAVE HAD THIS SAME PROBLEM. IT BECOMES DANGEROUS BECAUSE THE CAR WON'T MOVE SOMETIMES IN THE MIDDLE OF DRIVING ON THE FREEWAY. I SEEMS TO HAPPEN WHEN IT RAINS (WHICH IS EVERYDAY IN SEATTLE) I HAVE ALMOST BEEN HIT 3 TIMES BECAUSE OF THIS PROBLEM AND I JUST BOUGHT THE CAR. *TR

MY BRAKES STARTED SQUIKING, AND THAT WENT ON FOR ABOUT A WEEK AND THEN IT BECAME HARD FOR ME TO STOP. SO NOW I HAVE A LOT OF SQUIKING AND I HAVE TO STOP WAY BEFORE I AM SUPPOSE TO. I BOUGHT SOME BRAKE PADS THAT DID NOT FIX THE PROBLEM. *TR

1997 FORD EXPEDITION HAS WATER IN STEREO CAUSING ELECTRICAL FIRE IN DASH. NO WATER LEAKS FOUND. WINDSHIELD WAS RESEALED AND WATER TESTED. *TR

AFTER RAIN, WATER LEAKED THROUGH WINDSHIELD ON 1997 FORD EXPEDITION RESULTING IN ELECTRICAL ANOMALIES. THIS COULD POSE A FIRE HAZARD. *TR

START MY TRUCK AS USUAL EVERY MORNING TO LET IDLE BEFORE I GO TO WORK. 5 TO 10 MIN. *TR

TL*THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE FRONT DRIVER SEAT. SHE REMOVED HER DAUGHTERS FROM THE REAR SEATS AND WHEN SHE RETURNED, THE FRONT OF THE VEHICLE WAS ENGULFED IN SMOKE AND THE FRONT SEAT WAS IN FLAMES. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE IS CURRENTLY AT THE SAME LOCATION. THE CURRENT AND FAILURE MILEAGES WERE 150,000.

IN 1998, MY 1997 FORD EXPEDITION BEGAN HAVING ELECTRICAL PROBLEMS. WINDOW LOCKS GOING UP AND DOWN ON THEIR OWN, RADIO PLAYING WHEN NO ONE WAS IN THE CAR, CLICKING FROM UNDER THE DASH, SEATBELT LIGHTS COMING ON WHEN SEATBELTS WERE BEING WORN, WIPERS WORKING ON THEIR OWN. I HAD THIS VEHICLE IN THE SHOP MULTIPLE TIMES FOR THESE ISSUES. AFTER HAVING HIS VEHICLE IN THE SHOP NUMEROUS TIMES TO NO AVAIL, I THREATENED A LAW SUIT IF SOMETHING WASN'T DONE. THE DEALERSHIP CALLED IN A CREW THAT THEY REFERRED TO AS THE RAIN DOCTORS. COME TO FIND OUT, THE WINDSHIELD WAS LEAKING ON THE GEM MODULE AND SHORTING OUT THE ELECTRICAL SYSTEM. THE VEHICLE WAS UNDER WARRANTY AT THAT TIME. NOW, IN 2007, I AM STILL DRIVING THE SAME 1997 EXPED. IN THE LAST FEW WEEKS, ALL THESE PROBLEMS HAVE STARTED ALL OVER AGAIN. THIS TIME, THE 4X4 CLUSTER LIGHTS...

I'M HAVING SERIOUS ELECTRICAL PROBLEMS WITH MY 1997 FORD EXPEDITION. DURING HEAVY RAINS THE TRUCK WILL NOT START, WHEN I DO GET IT RUNNING THE DASH LIGHTS FLASH OFF AND ON. THE TRUCK STOPS RUNNING IN THE MIDDLE OF TRAFFIC. CLICKING NOISES ARE COMING FROM THE DASH, THE OVERDRIVE LIGHT FLASHES OFF AND ON THE DOORS WANT LOCK. I'M CONCERNED FOR MY FAMILIES SAFETY. A POSSIBILITY OF THE TRUCK CATCHING ON FIRE. FORD NEEDS TO DO A RECALL ON THE VEHICLES. *JB

MY 1997 FORD EXPEDITION CAUGHT ON FIRE IN THE PARKING STRUCTURE AT MY OFFICE. THE SPRINKLER SYSTEM PREVENTED THE FIRE FROM SPREADING TO THE OTHER CARS. VEHICLE WAS A TOTAL LOSS. *JB

MY 1997 FORD EXPEDITION HAS BEEN HAVING SERIOUS ELECTRICAL PROBLEMS. I HAVE HAD THE GEM MOD REPLACED AS WELL AS THE FUSE BOX. IT SEEMS AS THOUGH WATER IS LEAKING INTO THESE PARTS FROM THE WINDSHIELD. I AM STILL HAVING THESE PROBLEMS WITH A FAMILY OF SIX, I AM CONCERNED WITH THE PROSPECTS OF AN ELECTRICAL FIRE OR SOMETHING ELSE. WE HAVE HAD INSTANCES WHERE THE CAR LOST POWER WHILE ON THE HIGHWAY, THIS COULD CAUSE A SERIOUS ACCIDENT. PLEASE TALK TO FORD. THIS SEEMS LIKE A VERY COMMON PROBLEM! *JB

I HAVE A 1997 FORD EXPEDITION WHICH HAS HAD THE FOLLOWING SYMPTOMS: THE FAN BLOWER STAYS ON WHILE TRUCK IS OFF, THE BATTERY DIES FOR NO APPARENT REASON AFTER TRUCK HAS SAT UNUSED FOR SHORT PERIODS, VARIOUS LIGHTS ON INSTRUMENT PANEL COME ON AND OFF WHILE DRIVING(INCLUDING ABS, AIRBAG, ALL 4WD RELATED LIGHTS, LOW WASH, CHECK ENGINE), OVERDRIVE LIGHT BLINKS, SPEEDOMETER DOESN'T WORK, TRUCK DOESN'T ACCELERATE AND SHIFT PROPERLY, RADIO COMES ON WHEN TRUCK IS OFF. CLICKS AND BEEPS CAN BE HEARD SOMETIMES WHEN IN USE AND OFF. THE DEALER SAID THE GEM AND FUSE BOX WERE DAMAGED BY WATER LEAKING FROM WINDSHIELD. THEY REPLACED PARTS(FOR $600 AND TOLD ME THAT I HAD TO GO AND GET THE WINDSHIELD FIXED. I ASKED HOW THEY KNEW THE WATER WAS CERTAINLY COMING FROM WINDSHIELD, AND THEY SAID BECAUSE OF LOCATION ETC. AND I ASKED THEM WHAT WILL HAPPEN IF IT RAINS AFTER...

DT*: THE CONTACT STATED THE VEHICLE CAUGHT ON FIRE WHILE PARKED. THE DEALER AND THE MANUFACTURER WERE CONTACTED BUT WOULD NOT INVESTIGATE THE CAUSE OF THE PROBLEM TO DETERMINE IF IT WAS CAUSED BY A RECALL OR DEFECT. PICTURES OF THE INCIDENT WERE TAKEN.*AK

97 EXPEDITION THAT HAS MULTIPLE ELECTRICAL PROBLEMS, AIR BAG LIGHT STAYS ON, CLICKING UNDER DASH WET CARPET ON DRIVERS SIDE. LOCAL FORD DEALER TELLS ME OH THAT'S AN EASY FIX, ONLY $1200.00 TO REPLACE THE GENERIC ELECTRIC MODULE AND REMOVE AND REINSTALL THE WINDSHIELD! WENT ON TO TELL ME THEY DO THIS ALL THE TIME ON EXPEDITIONS! I ASKED WHY AND THEY TOLD ME THAT "THE FACTORY SCREWED UP WHEN THE WINDSHIELDS WERE INSTALLED AND THEY LEAK"! I THOUGHT THAT WAS WHY WE HAD RECALLS! IF THIS IS THE FACTORIES FAULT THEN WHY MUST I PAY FOR IT? *JB

I HAVE EXPERIENCED A PROBLEM WITH MY 97 FORD EXPEDITION NOT STARTING AFTER SITTING FOR LONGER THAN TWO DAYS FOR OVER A YEAR NOW. I HAVE HAD THE LOCAL FORD DEALERSHIP ATTEMPT TO FIND THE DRAW KEEPING THE VEHICLE FOR OVER A MONTH TOTAL. WHEN IT RAINED THE PROBLEM SEEMED TO BE WORSE. EVENTUALLY I WAS LEFT WITH HAVING TO HAVE A BATTERY BOOSTER IN THE BACK AND JUMP THE CAR AS IT NEEDED WITH NO SOLUTION FROM THE DEALER. TODAY I WENT OUT TO THE CAR ALMOST A YEAR LATER OF DEALING WITH THIS AND THE CAR WOULDN'T START AFTER LESS THAN 24 HOURS OF NOT DRIVING IT. THE CAR WAS NOT COMPLETELY DEAD AS THERE WAS CLICKING NOISES UPON TURNING THE IGNITION BUT DID NOT TURN OVER. REMOVED THE KEYS FROM IGNITION AND GOT OUT OF CAR TO GET BATTERY BOOSTER FROM THE BACK AND HEARD POPPING AND...

DT: FORD EXPIDITION CAUGHT FIRE THIS PAST SATURDAY ON JULY 16, 2005. NO KEYS WERE IN IGITION, IT HAD BEEN SITTING FOR ABOUT 5 MINUTES, GOT IN AND BEGAN TO DRIVE IT, BACKED IT UP AND SMELLED SOMETHING FUNNY, SO LEFT IT THERE. THE FIRE DEPARTMENT HAD A HARD TIME PUTTING OUT THE FIRE. THEY SAID FIRE WAS SO BAD THEY COULDN'T DETERMINE WHAT STARTED IT OR WHERE IT STARTED FROM. COULDN'T EVEN TELL THERE WAS AN ENGINE IN THE TRUCK. IT BURNT THE FRONT OF THE VEHICLE. CONTACTED DEALER, THEY SAID THERE WAS NOTHING THEY COULD DO. . AT THIS POINT HAVE NOT CONTACTED THE MANUFACTURER.*AK

CRUSE CONTROLL BRAKE SWITCH BURNED UP WHILE ATTEMPTING TO BACK CAR OUT OF THE GARAGE. WHEN THIS SWITCH BURNED UP IT CAUSED THE STOP LIGHT FUSE TO ALSO BURN OUT AND AND THIS CAUSES THE SHIFT LEAVER TO LOCK IN THE PARK POSITION. NOW WE HAVE AN ELECTRICAL FIRE AND CAN'T GET THE CAR OUT OF THE GARAGE. A GOOD FRIEND OF MINE HAS HIS OWN SHOP AND HE USED TO A CHIEF MECHCANIC FOR FORD SO I CALLED HIM AND HE CORECTED THE PROBLEM. HE GAVE ME THE PARTS THAT BURNED UP AND TOLD ME TO CALL FORD BECAUSE THEY HAD A RECALL OUT FOR THIS PROBLEM ON THIER 2000 & 2001 MODLES. MY CAR IS A 1997 AND THEY SAID THEY COULD NOT HELP ME. ANY SUGGESTIONS. P.S. I STILL HAVE THE PARTS FROM THE CAR.

FORD EXPEDITION CAUGHT ON FIRE.***NO ANSWER REQUIRED***. *MR THE VEHICLE HAD BEEN SITTING FOR 6-8 HOURS BEFORE IT CAUGHT ON FIRE. *NM

DT:CONSUMER STATED THAT SINCE T SHE BOUGHT VEHICLE IT HAD ELECTRICAL PROBLEMS. DEALER TOLD CONSUMER HAD CONSUMER TO TAKE VEHICLE TO A SPECIAL SHOP, THEY WOULD TRY TO FIGURE OUT THE PROBLEM. CONSUMER SAID THAT WITHIN THE FIRST THREE MONTHS VEHICLE HAD TWO IGNITION SWITCHES INSTALLEDT HAT CONSUMER DID NOT HAVE TO PAY FOR. VEHICLE HAD SEVERAL OTHER ELECTRICAL PROBLEMS. CONSUMER SAID THAT WITHOUT THE KEY IN IGNITION THE WINDSHIELD WIPERS /RADIO CAME ON, AND THE AIR BAG DEPLOYED. SOMETIMESM THE WINDOWS WOULD NOT ROLE BACK UP AFTER BEING ROLLED DOWN. CONSUMER ARRIVED HOME AFTER DRIVING VEHICLE ALL DAY. CONSUMER PARKED AND WENT INSIDE THE HOUSE. ABOUT FIVE MINUTES LATER, FOUND OUT THAT VEHICLE WAS ON FIRE. FIREMEN STATED THEY COULD NOT TELL WHAT CAUSED THE FIRE.*AK

JUNE 7, 2005, I PICKED UP MY SON AT SCHOOL; WE DROVE HOME AND GOT OUT OF THE TRUCK. WE WERE IN THE HOUSE 3-4 MINUTES WHEN I HEARD A VERY LOUD NOISE AND THEN STARTED TO SMELL SMOKE. I LOOKED OUTSIDE AND MY 1997 FORD EXPEDITION WAS ENGULFED IN FLAMES. I IMMEDIATELY CALLED THE FIRE DEPARTMENT WHO ARRIVED WITH THE POLICE DEPARTMENT. THE FIRE DEPARTMENT SAID IT WAS A FIRE THAT STARTED UNDER THE HOOD AND BURNT THE ENTIRE TRUCK UP.

1997 FORD EXPEDITION CAUGHT ON FIRE WHILE PARKED. *MR THE CONSUMER WAS INFORMED THAT SMOKE WAS COMING FROM THE HOOD ALONG WITH FLAMES ON THE DRIVERS SIDE OF THE VEHICLE. THE FIRE SPREAD TO THE VEHICLE PARKED BESIDE THE CONSUMERS VEHICLE AND DAMAGED THE REAR DRIVER SIDE QUARTER PANEL OF THE OTHER VEHICLE. *SC *JB

MY 97 FORD EXPEDITION CAUGHT ON FIRE WHILE PARKED IN HOME DEPOT PARKING LOT 10-29-05. THE FIRE WAS ELECTRICAL, AND IT STARTED UNDER THE HOOD ACCORDING TO THE INSURANCE REPORT. *JB

1997 FORD EXPEDITION WAS PARKED IN DRIVEWAY. UNDER HOOD FIRE AND SMOKE ERUPTED. CRUISE CONTROL DISCONNECT SWITCH HAD BURST INTO FLAMES AND SET BRAKE FLUID ON FIRE. SIGNIFICANT DAMAGE. PARTS REPLACED, OLD PARTS AVAILABLE.

CHECK ENGINE LIGHT COMES ON STAYS ON. AT FIRST, I WAS TOLD THIS WAS BEING CAUSED BY A GAS CAP NOT HOLDING PRESSURE. I PURCHASED A NEW GAS CAP WHICH SEEM TO TAKE CARE OF THE PROBLEM AND THE COMPUTER WAS RESET BY TAKING THE CABLE OFF THE BATTERY. THIS LAST ABOUT A MONTH UNTIL I WAS TOLD IT WAS THE EVAP CAN SOLINOID, WHICH WAS REPLACED UNDER THE EXTENDED WARRANTY PURCHASED. THE COMPUTER WAS RESET BY REMOVING THE CABLE FROM THE BATTERY. THIS LASTED ABOUT A MONTH AND WAS TOLD TO CHECK THE GAS CAP AND THE COMPUTER RESET BY REMOVING THE BATTERY CABLE. THE CHECK ENGINE LIGHT WILL GO OUT WITH FRESH TANK OF HIGH OCTANE GAS, BUT WILL REAPPEAR WITH LOWER GRADE OF FUEL AFTER A WHILE. I AM TOLD NOW THAT 1 OF 4 O2 SENSORS ARE BAD AND NEED TO BE REPLACED. FURTHERMORE, IT IS...

THE CONSUMER WAS UNABLE TO START THE VEHICLE. THE ENGINE LIGHT ILLUMINATED THE DASH BOARD AND FLASHED VERY FAST. IT MADE A CLICKING NOISE IN THE FRONT END OF THE VEHICLE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHO REPLACED THE KEYS AND, THE PCM, THE PCM BURNED OUT AGAIN, AND THE CONSUMER WAS TOLD SOME WIRES WERE PULLING FROM THE FRONT TO THE TRANSMISSION. THE VEHICLE IS OUT OF SERVICE AGAIN WITH THE SAME PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION.

ENGINE COMPARTMENT FIRE WHILE VEHICLE WAS PARKED. VEHICLE HAD BEEN PARKED 30 MINUTES. ALTERNATOR REPLACED 1 MONTH AGO. CRUISE CONTROL USED SOMETIMES. LAST USED 1 MONTH AGO AND IT WORKED. NO AFTER MARKET EQUIPMENT. BRUCE YORK WENT TO SEE VEHICLE AND TOOK PICTURES.*AK

WET CONDITIONS CAUSE ELECTRICAL MALFUNCTIONS ON MY 1997 FORD EXPEDITION. WAS TRAVELING ON 01-10-05 ON SNOW PACKED ROADS WITH 4X4 ACTIVATED. FOUR WHELL DRIVE CLUSTER ON THE INSTRUMENT PANEL STARTED TO FLASH INTERMITTENTLY CAUSING THE VEHICLE TO SHIFT VERY AKWARDLY. TOOK CAR OUT OF 4X4 AND SEEMED TO CORRECT THE PROBLEM. NEXT OCCURANCE WAS ON 01-21-05, TRAVELING ON WET ROADS. TURNED OFF VEHICLE IN PARKING LOT AND INTERIOR LIGHTING AND RUNNING BOARD LIGHTS WOULD NOT SHUT OFF FOR A FEW MINUTES. AFTER THE VEHICLE HAD DRIED OUT AFTER A FEW DAYS THE PROBLEM SEEMED TO FIX ITSELF AGAIN. THE NEXT INCIDENT WAS ON 01-29-05, ONCE AGAIN WET ROAD CONDITIONS. PARKED VEHICLE IN DRIVEWAY OVERNIGHT WENT OUT TO START THE NEXT DAY AND HEATER BLOWER WAS STILL RUNNING WITHOUT THE KEY IN THE IGNITION. VEHILCLE HAD DEAD BATTERY, JUMP STARTED THE CAR AND THE INTERIOR LIGHTS WOULD NOT TURN OFF, AS...

MY HUSBAND WENT OUT TO START VEHICLE. HE HEARD A POP. TURNED OFF THE TRUCK. SAW THAT THE COIL AND PLUG BLEW OUT OF THE CYLINDER HEAD. HAD IT TOWED TO FORD DEALER WHO SAID ALL THEY COULD DO IS CHARGE ME $2700 TO REPLACE THE HEAD THAT WAS DAMAGED FROM THE SPARK PLUG BLOWING OUT. I'VE SEEN OTHER COMPLAINTS ON THIS WEBSITE SIMILAR TO MY PROBLEM AND YES, IT SHOULD BE A MANDITORY RECALL. WILL NEVER BUY ANOTHER FORD. ALSO TALKED WITH FORD COMPANY WHO ACTED LIKE THEY HAD NEVER HEARD THIS COMPLAINT BEFORE. FORD DEALER HAS WORKED ON TRUCK EACH TIME IT NEEDED REPAIR. BUYING A CHEVROLET.*AK

PARKED VEHICLE AT 12 PM AT AROUND 5 PM THE VEHICLE CAUGHT ON FIRE. ONE DAY PRIOR TO THE FIRE THE LOW WASHER FLUID LEVEL LIGHT CAME ON. THEN THE LIGHT CLUSTER FOR THE 4 WHEEL DRIVE FLASHED A FEW TIMES. THE DAY OF FIRE, THE VEHICLE WAS DRIVEN ABOUT 14 MILES. THE SAMES LIGHTS WERE FLASHING AND THEN THE ODOMETER STOPPED WORKING. TOOK IT TO LOCAL GAS STATION AND THEY SAID PROBABLY A LOOSE WIRE. CAR STARTED IT SELF AND THE STARTER MOTOR KEPT TRYING TO START THE VEHICLE ON ITS OWN. POPPED HOOD AND SAW LOTS OF SPARKING AND POPPING. SO VIDEO TAPED IT AS IT HAPPENED. FIRE SEEMED TO COME FROM THE PASSENGER SIDE. DID NOT USE CRUISE CONTROL AND SO DO NOT KNOW IF WORKED.

PAINT AND FINISH ON ROOF OF VEHICLE PEELING, CRACKING, FLAKING OFF - OXIDATION FROM RUST, RUINING ENTIRE OUTER CAR SURFACE - HAVE BEEN ADVISED THAT PRIMER COAT WAS EITHER MISSED OR SKIMPED DURING THE PRODUCTION PROCESS... FORD WILL NOT ADDRESS THIS ISSUE - ONE MALE REP FROM FORD STATED: "THE PAINT JOB IS ONLY SUPPOSED TO LAST 2 YEARS" NOT AN ACCEPTABLE ANSWER...ALSO, CHILD SAFETY LOCKS ENGAGE THEMSELVES, THUS PREVENTING OCCUPANTS IN REAR SEATS TO EXIT VEHICLE, CAN CAUSE INJURY OR DEATH IN AN EMERGENCY SITUATION... ALSO, VEHICLE REAR WHEELS AND OR AXELS "CHATTER" AT LOW SPEED TURNS... ALSO, AN AUDIBLE HUM IN VEHICLE AT NORMAL HIGHWAY SPEEDS...ALSO, AUDIBLE SQUEAKING FROM INTERIOR SIDE PANELS...FORD DEALER STATES: CAUSE CANNOT BE LOCATED...ALSO, LEATHER SEATS HAVE CRACKED AND SHOW SIGNS OF ABNORMAL WEAR - THIS IS APPARANT IN ALL LEATHER SEAT COVERINGS BUT ESPECIALLY IN THE FRONT "BUCKET" OR "CAPTAIN" SEATS...FORD STATES WARRANTY...

THE CONSUMER WENTTO WARM THE VEHICLE, HE SMELLED SOMETHING BURNING, THEN LOOKED AROUND AND SAW THAT THE FUSE BOX MELTED AND WIRES WERE HANGING. *SC *JB

I OWN 1997 FORD EXPEDITION 4.6L 2WD AND HAVE HAD A FEW INSTANCES WHERE I THINK WATER HAS LEAKED THROUGH THE WINDSHIELD. THE WATER IS LEAKING SOMEWHERE ON THE DRIVER SIDE. IT IS CAUSING THE RADIO TO TURN ON AND STAY ON WITHOUT THE KEYS IN THE IGNITION. IT ALSO CAUSES THE AIRBAG LIGHT TO COME ON SO I DO NOT KNOW IF THERE IS A REAL PROBLEM OR NOT. THE WINDSHIELD WASHER FLUID LIGHT COMES ON ALSO. I AM AFRAID THIS MIGHT TRIGGER SOME EXTREMELY DANGEROUS REACTION WHILE DRIVING IF THE WRONG THING GETS WET. I WOULD HAVE IT FIXED BUT I DO NOT KNOW WHAT IS WRONG WITH IT. I TOLD THE DEALER BUT THEY COULD NOT FIGURE IT OUT BECAUSE IT DRIED AND STOPPED. THIS HAS HAPPENED A FEW TIMES IN THE LAST TWELVE MONTHS. I HAVE READ ON THIS SITE I AM NOT THE ONLY ONE...

I HAVE OWENED A 1997 FORD EXPEDITION FOR 1 YEAR. IN THIS TIME I HAVE HAD THE SAME PROBLEM TWICE. THE SPARK PLUGS COME LOOSE FROM THE PISTON HEAD AND ARE BLOWN OUT AND DAMAGE THE COIL PACK. THERE IS THEN UN-BURNT FUEL COMING FROM THE PISTON CHAMBER AND THE SPARK PLUG IS STILL FIRING WITH THE POSSIBLITY OF A FIRE. THE DEALERSHIP HAS TOLD ME THAT THIS IS A KNOWN AND ADDRESSED ISSUE BY FORD MOTOR COMPANY, BUT FORD WILL ONLY PAY FOR REPAIRS UPTO 75,000 MILES. THIS LAST TIME THIS HAPPENED IT DAMAGED THE HEAD AND WILL REQUIRE MAJOR REPAIRS. I AM MOSTLY CONCERNED WITH THE FIRE SAFTEY AND BELIEVE THAT THIS SHOULD BE A MANDITORY RECALL.*AK

WHILE DRIVING SPARK PLUG FELL OUT, CAUSING VEHICLE TO HAVE NO POWER. DEALER NOTIFIED. *AK

5.4L FORD ENGINE IN 1997 EXPEDITION. SPARK PLUG BLOW-OUT IN 3 POSITION. EXPEDITION HAS 64,000 MILES ON IT!! ALSO , THIS VEHICLE WAS SOLD TO ME AS A DEMO MODEL THAT WAS NEVER TITLED, WARRANTY SHOULD HAVE STARTED WHEN I PURCHASED IT. *NLM

VEHICLE WAS PARKED INSIDE OF THE DRIVEWAY AND HORN WAS BLOWING. THEN THERE WERE FLAMES COMING FROM UNDERNEATH THE HOOD. VEHICLE WAS ON FIRE, AND WAS TOTALED. *AK FLAMES WERE COMING FROM THE HOOD BEFORE THE HORN STARTED TO BLOW. THERE WAS NO WARNING OF ANY PROBLEM BEFORE FIRE. TRUCK HAD NOT BEEN DRIVEN FOR HOURS PRIOR TO FIRE. IT WAS DETERMINED THAT THE FIRE WAS DUE TO AN ELECTRICAL SHORT NEAR THE POWER DISTRIBUTION BOX. *TT

WHILE VEHICLE WAS NOT RUNNING AND IT WAS RAINING, HEATER FAN AND RADIO WOULD TURN ON INTERMITTENTLY. ALSO, AIR BAG LIGHT ON THE INSTRUMENT PANEL WOULD COME ON DURING OPERATION OF VEHICLE. DEALERSHIP HAS EXAMINED VEHICLE AND DETERMINED THERE WAS WATER IN THE ELECTRICAL SYSTEM. GEM MODULE(FUSE SYSTEM) WAS FAULTY, AND WAS BEING REPLACED. *AK *TT

INTERIOR DOME AND RUNNING BOARD LIGHTS DO NOT SHUT OFF AFTER ALL THE DOORS ARE SHUT TIGHTLY, POSSIBLE ELECTRICAL PROBLEMS. *ET

I HAVE HAD SEVERAL ELECTRICAL MALFUNCTIONS IN THE PAST 9 MONTHS. FIRST STARTING MAY 2000, CLICKING NOISES UNDER DASH, DASH LIGHTS BLINKING ON AND OFF SEEMS LOW WASHER FLUID LIGHT IS EFFECTED MOST. BEEPING NOISES FROM BEHIND GLOVE BOX. A/C COMES ON WITHOUT KEY IN IGNITION. TOOK IT TO FORD IMEDIATLY THEY COULDN'T FIND A PROBLEM. NEXT INCIDENT, WAS DURING A WEEKEND AND IT SEEMED TO CORRECT ITSELF. SECOND TIME TO THE SHOP, SAME PROBLEM AS FIRST. THEY COULD NOT FIND WHAT WAS CAUSING THE PROBLEM. THIS PROBLEM HAS HAPPENED SEVERAL TIMES EITHER AT NIGHT OR ON WEEKEND AS THIS IS THE ONLY TIME THE CAR IS DRIVEN. BY MONDAY AM PROBLEM IS GONE. IN JUNE ANOTHER INCIDENT THIS TIME WINDOWS AND DOOR LOCKS AFFECTED. WINDOWS ROLLED UP AND DOWN BY SELVES, THEN WOULD NOT PERFORM AT ALL. DOOR LOCKS CAME UP ON THEIR OWN. DEALERSHIP COULD NOT FIND PROBLEM....

ELECTRICAL FAILURES CAUSED VEHICLE TO STALL IN TRAFFIC MANY TIMES.