1998 FORD CONTOUR Engine And Engine Coolingcooling System Problems

DRIVING ON INTERSATE 66 FROM MANASSAS VA INTO WASHINGTON DC AT 65MPH WHEN NOTICED COLD AIR BLOWING OUT OF HEATER VENTS. CAR IS SEVERELY OVERHEATED BEFORE SAFE EXIT FROM HIGHWAY. WATER PUMP'S PLASTIC IMPELLER HAD SHATTERED WITH 53K MILES ON THE CAR. FORD REPLACED WATER PUMP FOR $527. AFTER OVERHEATING THE CAR ALSO BEGINS TO LEAK OIL FROM SEVERAL LOCATIONS. THE OIL PAN GASKET IS REPLACED FOR $407 AT 63K MILES. THE REPLACEMENT WATER PUMP'S GASKET IS DISCOVERED TO BE LEAKING AT 66K MILES WHILE TRYING TO LOCATE THE SOURCE OF ADDITIONAL OIL LEAKS - THIS TIME THE OIL PRESSURE SENDING UNIT.

THIS CAR HAS BEEN NOTHING BUT PROBLEMS, SPRINGS, BRAKES LAST 4 MONTHS,WATER PUMPS WENT AT 63,000, TIRES WEAR OUT IN LESS THAN A YEAR, TEMPERATURE GAUGES DO NOT READ RIGHT. ENGINE RACES, SOLENOID WENT....VERY EXPENSIVE TO FIX. I DO NOT UNDERSTAND WHY EVERYONE IS HAVING THE SAME PROBLEMS BUT NO HELP? *LA

SUFFERED A WATER PUMP FAILURE. THE PLASTIC/BAKELITE IMPELLER SHATTERED CATASTROPHICALLY, RESULTING IN PARTS STREWN THROUGHOUT COOLANT SYSTEM. TOTAL REPAIR COST: $470. SINCE PART WAS REPLACED AT AN INDEPENDENT GARAGE, FORD WILL NOT REPORT THE FAULTY PART. PERHAPS PROPYLENE GLYCOL, THE PRINCIPLE CHEMICAL FOUND IN COOLANT, CAUSES THE PLASTIC PART TO BECOME BRITTLE AND SHATTER, BUT NO ONE AT FORD WILL LISTEN TO THAT. NUMEROUS COMPLAINTS FOUND ON WEB REGARDING THIS SAME ISSUE. TIME FOR A RECALL - THE TORONTO FIELD OFFICE TOLD ME THAT THERE IS NO RECALL ON THIS PROBLEM.*AK

I'VE HAD TO REPLACE THE WATER PUMP 4 TIMES ON MY 1998 FORD CONTOUR. DEC. 28, 2001 - 1ST INCIDENT: WATER PUMP FAILURE, ALSO HAD TO REPLACE SENSOR AND THERMOSTAT BECAUSE THE RADIATOR HAD ZERO WATER IN IT. MARCH 26, 2002 - 2ND INCIDENT: WATER PUMP FAILURE. MAY 24, 2002 - 3RD INCIDENT: WATER PUMP FAILURE. OCTOBER 24, 2002 - 4TH INCIDENT: WATER PUMP FAILURE, ALSO HAD TO HAVE A BELT ON THE PUMP REPLACED. I CALLED NORMA AT THE FORD CUSTOMER RELATIONSHIP CENTER (1-800-392-3673) AND SHE TOLD ME THERE IS NOTHING THAT FORD CAN DO SINCE THE PARTS WARRANTY (12 MONTH/12,000 MILES) IS OVER THE MILEAGE. I WILL HAVE TO PAY FOR THE REPLACEMENT OF A WATER PUMP AND IF THERE ARE FUTURE FAILURES UNDER THE WARRANTY ONCE I'VE PAID FOR THE REPAIRS IT WILL BE REPLACED AT NO CHARGE. I INFORMED NORMA THAT THE DEALERSHIP STATED THAT THEY...

PLASTIC IMPELLER BLADES ON WATER PUMP HAVE REPORTEDLY FAILED ON NUMEROUS CONTOURS, RESULTING IN ENGINE OVERHEATING. COOLANT FROM RESERVOIR SPRAYED INSIDE ENGINE COMPARTMENT. UPON LIFTING HOOD, BOILING COOLANT WAS VISIBLE IN RESERVOIR. THIS PRESENTS AN INJURY HAZARD FROM THE HOT COOLANT, AS WELL AS FROM POSSIBLE ENGINE FAILURE DURING VEHICLE USE.*AK

WHILE DRIVING DRIVER'S SIDE SEAT CAME LOOSE AND FELL INTO THE FLOOR OF VEHICLE, ALMOST CAUSED AN ACCIDENT, CONSUMER STATED THE FRAME OF THE SEAT WAS CRTACKED. *AK THE RECALL (99B23) ON THE WATER PUMP EXPIRED BECAUSE THE DEALER WAS BOOKED UP SEVERAL TIMES AND THE CONSUMER WAS UNABLE TO LEAVE THE VEHICLE AT THE DEALER. *YH

CONSUMER STATES THE WATER PUMP FAILED.*YD

RECALL 99V243000/AIR BAG SENSOR ASSEMBLY:DEALER:M&M FORD, MUSCATINE, IA; PHONE 563-263-5324 REFUSED TO HONOR RECALL BECAUSE VEHICLE HAD TOO MUCH MILEAGE. MANUFACTURER WAS NOTIFIED. *AK THE WATER PUMP FAILED AND WAS REPLACED. THE CONSUMER STATES THERE WAS A RECALL ON WARNING LIGHT BUT THE DEALER DID NOT FIX THE RECALL DUE TO HIGH MILEAGE ON THE VEHICLE. *YH

CONSUMER WAS TRAVELING ON HIGHWAY, AND WITHOUT PRIOR WARNING WATER PUMP SHUT DOWN, AND TRANSMISSION VIBRATED WHEN APPLYING BRAKES. DEALERSHIP WAS AWARE OF PROBLEM.*AK

MANY OTHER FORD CONTOUR OWNERS EXPERIENCED THIS PROBLEM AS WELL. ON WWW.CONTOUR.ORG MESSAGE BOARDS. NO SAFETY DEFECTS LISTED. *AK

1998 FORD CONTOUR SE, 2.5L V6 - WATER PUMP IMPELLER SHATTERED WHILE DRIVING ON HIGHWAY, CAUSING LOSS OF COOLANT FLOW. ENGINE OVERHEATED. FORTUNATELY THERE WAS A LINCOLN-MERCURY DEALER LESS THAN 1 MILE AWAY FROM THE LOCATION WHERE THE PART FAILED, SO ENGINE DID NOT RUN IN OVERHEATING CONDITION FOR VERY LONG. WATER PUMP WAS REPLACED BY THIS LOCAL DEALER ($371 TOTAL). THE CAR IS STILL MY DAILY DRIVER, AND NOW APPEARS TO BE OPERATING NORMALLY WITH THE NEW WATER PUMP.

CONSUMER STATES THE WATER PUMP FAILED.*YD

WATER PUMP IMPELLER FAILURE. *AK

COOLING GUAGE SHOWS ENGINE RUNNING AT HIGH END-ALMOST TO RED. *AK

THE WATER PUMP AND NOW THE FUEL PUMP. THIS HAS BEEN A VERY BAD EXPERIENCE WITH FORD THE INCONVIENCE AND THE FREEDOM OF PURCHASING A NEW CAR HAS LEFT ME FRUSTRATED AND AFRAID TO TRUST THE CAR. *AK

WATER PUMP STOPPED WORKING WHILE CONSUMER WAS DRIVING AND CAUSED ENGINE TO OVERHEAT AND STOP. CONTACTED DEALER, AND DEALER WOULDN'T DO ANYTHING.*AK

WHILE TRAVELING AT 75MPH THE ENGINE WATER PUMP GOES OUT. ONLY THING HEARD OR SEEN WAS A ENGINE KNOCK. THE ENGINE HAD TO BE REPLACED. *AK

VEHICLE WAS RUNNING HOT THE 1ST TIME DEALER KEPT IT FOR 2 WEEKS & CLAIMED IT WAS FIXED. VEHICLE WENT TO THE DEALER AGAIN THIS TIME FOR 47 DAYS WHICH A LOANER VEHICLE WAS GIVEN & IT WAS RETURNED WITH NO EXPLANATION WHAT WAS WRONG. IT'S STILL RUNNING HOT. *AK

HAVE HAD 5 RECALLS SINCE BUYING THE CAR. ALSO, HAVE HAD TO HAVE THE WATER PUMP CHANGED. THE PROBLEM IS TRYING TO GET THE RECALLS DONE. I HAD TAKEN THE CAR IN PREVIOUSLY ONLY TO BE TOLD THEY DIDN'T HAVE THE PARTS AND HAD TO RESCHEDULE. THE LAST TWO RECALLS I STRESSED THE IMPORTANCE OF GETTING THESE DONE WHEN SCHEDULE. THE AIR BAG AND THE BRAKES WERE THE LAST TWO. I SCHEDULED THEM FINALLY IN APRIL THIS YEAR. ON SATURDAY AFTERNOON I WENT TO PICK UP MY CAR ONLY TO BE TOLD THEY DID NOT HAVE THE PARTS. I EXPRESSED AGAIN HOW HARD IT WAS FOR ME TO COME IN BECAUSE I WORK 5-6 DAYS A WEEK. AGAIN I RESCHEDULED FOR JULY. I CALLED AND MADE AN APPOINTMENT VERIFIED THE PARTS WERE THERE. I BROUGHT THE CAR IN. AGAIN LATE SATURDAY AFTERNOON WENT TO PICK UP THE CAR ONLY TO...

ODOR OF ANTI-FREEZE IS VERY STRONG INSIDE CAR AT TIMES; DEALER CHECKED FOR LEAKS AND SAID THERE WERE NONE.........NO SOLUTION TO PROBLEM. *AK

TEMPERATURE GAUGE READS IN VERY HIGH NORMAL RANGE UNDER NORMAL DRIVING CONDITIONS; CAR COMES VERY CLOSE TO OVERHEATING. HAVE I MISSED A RECALL NOTICE ON THIS PROBLEM? *AK

THE CONSUMER RECEIVED A MANUFACTURER'S RECALL ON WATER PUMP. A WEEK LATER, CONSUMER HEARD A KNOCKING NOISE. TOOK VEHICLE BACK TO THE DEALERSHIP, AND MECHANIC TOLD HIM THAT THE BOLTS WERE LOOSE ON THE WATER PUMP. ALSO, WHEN CONSUMER APPLIED BRAKES THERE WAS A HUMMING NOISE. *AK

WHILE DRIVING BACK FROM CHICAGO ON I55, THE WATER PUMP (WHICH SUPPOSEDLY HAD A RECALL OF WHICH I WAS NOT NOTIFIED) WENT OUT. WARNING LIGHTS DID NOT APPEAR ANYWHERE ON THE DASHBOARD, AND THE ONLY INDICATION THAT ANYTHING MIGHT BE WRONG WAS A WHINING SOUND UNDER THE HOOD WHICH STOPPED AFTER A SHORT INTERVAL. WITHIN AN HOUR, THE ENTIRE CAR WAS DESTROYED. A NEW ENGINE, WATER PUMP, ELECTRICAL SYSTEM, AND RADIATOR NEEDED TO BE REPLACED. ALL OF THAT IS STILL BEING DONE, TWO WEEKS LATER. THEY HAVE DONE THE WORK WITHOUT CHARGE, AND HAVE GIVEN ME A RENTAL CAR TO USE IN THE MEANTIME, HOWEVER, WITH A NEW ENGINE, THEY ARE ONLY WILLING TO GIVE ME A 9,000 MILE WARRANTY ON THE CAR REPAIRED. SINCE THIS WAS NOT MY FAULT, A FAIRLY NEW CAR, AND A LACK OF COMMUNICATION ON THE FORD MANUFACTURER THAT THIS WAS A PROBLEM, I FEEL...

CONSUMER IS NOT ABLE TO HAVE RECALL REPAIR COMPLETED DUE TO BACK ORDER OF WATER PUMPS, HOWEVER VEHICLE IS OVERHEATING DUE TO FAILURE. *MJS

VEHICLE EXPERIENCED FAILURE OF THE WATER PUMP PRIOR TO RECALL NOTICE, RESULTING IN HAZARDOUS CONDITION WHEN LEAK CAUSED DRIVE BELT TO FALL OFF. MJS

VEHICLE EXPERIENCED FAILURE OF THE WATER PUMP PRIOR TO RECALL NOTICE, RESULTING IN HAZARDOUS CONDITION WHEN LEAK CAUSED DRIVE BELT TO FALL OFF. MJS

VEHICLE EXPERIENCED FAILURE OF THE WATER PUMP PRIOR TO RECALL NOTICE, RESULTING IN HAZARDOUS CONDITION WHEN LEAK CAUSED DRIVE BELT TO FALL OFF. MJS

TEMPERATURE GAUGE GOES ALL THE WAY TO THE RED AREA. WHEN CAR OVERHEATS IT LOSES POWER. SINCE CONSUMER PURCHASED THE CAR SHE HAD NOTHING BUT PROBLEMS AND RECALL NOTICES. *AK

WATER PUMP LEAKING. *YC

WAS DRIVING VEHICLE ABOUT 40MPH IT STALLED OUT FOR NO REASON. HAD CHECKED UNDERHOOD, THE TIMING BELT BROKE. ALSO, THE WATER PUMP & HEAD GASKET FAILED. HAD THE VEHICLE TOWED TO DEALER.*AK

WATER PUMP FAILED.