1996 DODGE RAM Vehicle Speed Control Problems

The contact owns a 1996 Dodge Ram. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 97V068000 (Service Brakes, Hydraulic), 01V037000 (Vehicle Speed Control), and 00V135000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

WHEN THE CONSUMER STARTED THE VEHICLE, IT SUDDENLY ACCELERATED. THE RPM'S HAD GONE INTO THE RED. THE CONSUMER HAD TAKEN THE VEHICLE TO THE REPAIR SHOP, BUT THE MECHANIC COULD NOT REPAIR IT BECAUSE HE COULD NOT DUPLICATE THE PROBLEM. *AK THE TOW TRUCK DRIVER HAD VIEWED ONE OF THE CABLES IN A "U" SHAPE AND IT WAS STUCK INTO A SPRING ON THE GAS PEDAL. *SCC *JB

CONSUMER STILL HAVING PROBLEM AFTER THE RECALL REPAIR HAS BEEN PERFORMED ON THE VEHICLE. RECALL#01V037000 THROTTLE CONTROL. COMMUNITY MOTORS 354 SOUTH HWY55 PRICE, UT 84501 1800-944-0219. *MR

CONSUMER WAS SENT A RECALL NOTICE (01V037000) FOR THE THROTTLE STICKING ON THE VEHICLE. CONSUMER MADE AN APPOINTMENT UNDER THE ASSURANCE THE PARTS WOULD BE IN. THEY WERE NOT IN SO THEY WERE ORDERED. CONSUMER BROUGHT VEHICLE BACK AND THE REPAIR WAS COMPLETED. THE VEHICLE NOW IDLES HIGH AND THE THROTTLE IS WORSE. CONSUMER OILED THE LINKAGES AND THE PROBLEM WAS BETTER. CONSUMER BROUGHT VEHICLE BACK TO THE REPAIR SHOP AND WAS INFORMED THE THROTTLE ROD WAS BAD AND WOULD COST FOR REPLACEMENT. CONSUMER FEELS NO CHARGE SHOULD ACCOMPANY THE ADDED WORK BECAUSE THE RECALL FAILED TO REMEDY THE PROBLEM. *JG

SHIFTED FROM PARK TO REVERSE. ENGINE IDLED FAST, TRUCK TOOK OFF IN REVERSE AND COULD NOT BE STOPPED BY PRESSING ON THE BRAKE. SPEED PROBABLY ACCELERATED TO 20 MPH BEFORE HIT 3 OTHER VEHICLES. WITNESSES SAID THE REAR TIRES WERE SPINNING AND THE ENGINE NOISE WAS HIGH PITCHED AND OSCILLATING.*AK

CONSUMER IS NOT SATISIFIED WITH THE LENGTH OF TIME IT IS TAKING TO PERFORM RECALL, EVEN AFTER HAVING PARTS ORDERED IN ADVANCE, CONSUMER REQUESTED THAT VEHICLE BE SERVICED THE SAME DAY, HOWEVER HE RECEIVED A CALL STATING THAT THE REPAIRS HAD NOT BEEN STARTED, CONSUMER THEN RETURNED VEHICLE ONLY TO LATER BE INFORMED THAT THE PART BROKE AND WAS SAID TO DEFECTIVE, AND ANOTHER PART WAS TO BE ORDERED.*JB

CONSUMER IS NOT SATISIFIED WITH THE LENGTH OF TIME IT IS TAKING TO PERFORM RECALL, EVEN AFTER HAVING PARTS ORDERED IN ADVANCE, CONSUMER REQUESTED THAT VEHICLE BE SERVICED THE SAME DAY, HOWEVER HE RECEIVED A CALL STATING THAT THE REPAIRS HAD NOT BEEN STARTED, CONSUMER THEN RETURNED VEHICLE ONLY TO LATER BE INFORMED THAT THE PART BROKE AND WAS SAID TO DEFECTIVE, AND ANOTHER PART WAS TO BE ORDERED.*JB

RECALL 01 V 037 000/THROTTLE CABLE: DEALER / MANUFACTURER IS TELLING CONSUMER THAT THIS RECALL DOES NOT EXIST; ASKING NHTSA HELP IN THIS MATTER.*AK *SLC

ON THREE OCCASIONS VEHICLE ACCELERATED SUDDENLY AND UNEXPECTEDLY. DEALER HAS BEEN NOTIFIED. *AK

THROTTLE CABLE FRAYED ONCE AT 70MPH. DEALER HAS BEEN NOTIFIED..*AK CRUISE CONTROL CABLE ALSO FRAYED. *YH

ON JANUARY 26, 2001 DURING AN INSPECTION, I NOTICED SEVERAL FRAYED STRANDS ON THE ACCELERATOR CABLE WHERE IT EMERGES FROM THE SHEATH NEAR THE INJECTOR PUMP. I BOUGHT A NEW CABLE THAT SAME DAY AND NOTICED IT IS OF A DIFFERENT DESIGN THAN THE ORIGINAL. IF THERE WAS ENOUGH OF A PROBLEM TO CAUSE A REDESIGN OF THE PART, IT SEEMS DC CORP. SHOULD HAVE NOTIFIED THE OWNERS. WITH THE POWERFUL TORQUE OF THIS ENGINE, THIS IS A DEFINATE SAFETY CONCERN AS IT WOULD BE HARD TO BRING IT TO A STOP SHOULD THE CABLE FAIL AT HIGHWAY SPEEDS.*AK

THE THROTTLE CABLE FAILED, CAUSING ABS AND BRAKE LIGHTS TO BE ILLUMINATED, ALSO CAUSED CRUISE CONTROL TO HUNT, CONSUMER TAPPED TO DISENGAGE CRUISE CONTROL AND THE ACCELERATOR STUCK. *SLC

AIRBAG LIGHT CAME ON AFTER BEING HIT ON BACK END OF VEHICLE. DEALER FOUND INTERNAL WIRING PROBLEM, AIRBAG SENSOR HAD TO REPLACED. *AK

WHILE DRIVING MY TRUCK ON THE INTERSTATE HWY AT A SPEED OF 60 MPH, WITH THE CRUISE CONTROL INGAGED MY TRUCK EXCELERATED TO SPEED OF 90+ MPH, I WAS UNALBE TO STOP THE VECHICAL.

WHILE DRIVING MY TRUCK ON THE INTERSTATE HWY AT A SPEED OF 60 MPH, WITH THE CRUISE CONTROL INGAGED MY TRUCK EXCELERATED TO SPEED OF 90+ MPH, I WAS UNALBE TO STOP THE VECHICAL.

WHILE DRIVING VEHICLE SUDDENLY ACCELERATED, CAUSING A CRASH. SUDDEN ACCELERATION PROBLEM HAPPENED ONCE BEFORE. DEALER COULD NOT DETERMINE THE PROBLEM. *AK BRAKE FAILED. *YD

WHILE DRIVING ON THE FREEWAY AND TOWING A TRAILER THE THROTTLE LINKAGE JAMMED ALL THE WAY ON. I HAD TO TURN THE IGNITION OFF TO STOP. THE THROTTLE CABLE HAD BECOME FRAYED INSIDE OF A SHEATH ON THE LINKAGE CABLE AND JAMMED INSIDE THE SHEATH.

REPLACE MISSING BOLT ON THROTTLE LINKAGE WERE IT BOLTS TO FUEL PUMP, REINSTALL DRIVE SHAFT, RUN AND CHECK ENGINE.

CRUISE CONTROL FAILED DUE TO IMPROPER INSTALLATION OF THE SECURITY SYSTEM.

WHEN PRESSING ON THE ACCELERATOR THE TRUCK HESITATED AND THEN IT ACCELERATED. .*AK

DURING VEHICLE OPERATION AT 25 MPH. A SUDDEN ACCELERATION HAS BEEN EXPERIENCED TWICE.*AK

SUDDEN ACCELERATION. *SD

SHIFTED INTO REVERSE, VEHICLE SURGED ABOUT FIFTY FEET. HIT CAR AND TREE DUAL AIR BAGS DID NOT DEPLOY. *AK